Tesla Model S Transmission Problems

Transmission complaints by model year

Which parts fail

• Driveline › Driveshaft
  2

Components named in complaints (automatic and manual transmissions, CVT, axles, driveshaft, 4WD/AWD).

Mileage when the problem started

• Under 25k
  1825%
• 25k–50k
  1926%
• 50k–75k
  912%
• 75k–100k
  811%
• 100k–150k
  1521%
• 150k+
  45%

What owners report

The vehicle is over reporting it's speed by 5% this is a large discrepancy which effects safety by causing people drivers around you to change lanes because you are traveling under the speed limit. Tesla is unable to calibrate the speedometers are the service center. They have documented the failure. It also adds miles to the odometer prematurely. This problem started after Tesla upgraded the car with a Track Package which is a $24,000 upgrade

I have the plaid version... and this care wears out the rear ties within 12-14 thousand miles.. which is super fast and you can't tell because it's the inside of the tire. The metal shoes and is potentially dangerous and life threatening

My Tesla Model S 2022 unexpectedly shut down while parked in a covered garage on [redacted], after I had driven for an hour. This occurred after I returned from a family trip to Lima, Peru, where I did not use the car. Tesla service center diagnosed it as water damage requiring a $20,578.50 battery pack replacement, which was covered by my insurance. There were no warning signs prior to failure. Within 20 minutes of the tow truck dropping off my car at Tesla, a representative informed me it was water damage, citing a system error and claiming over 20 vehicles had the same issue. This suggests a widespread problem and Tesla's awareness of it. This incident raises serious safety concerns about a potential design flaw and the lack of a water intrusion warning system. If this occurred while driving, it could lead to a sudden loss of power and an accident. …

The gear shifter is unreliable without visually checking the gears on screen. It may or may not register the shift during selection. When merging from residential traffic to a main road turning right, the driver has to pull forward to check the incoming traffic. In ideal situation, if the other vehicles are approaching at speed, the driver would want shift in to reverse and backup from hanging over main road and back to the residential alley. However the inconsistencies of the gear selector make it dangerous during those occasions. The car could fail to register the shift, or cannot shift fast enough to reverse. It poses significant risks to the driver and other vehicles on the road. A front/rear cross traffic alert or a better mechanism to shift into reverse should be implemented. …

The contact owns a 2020 Tesla Model S. The contact stated while driving at various speeds, the vehicle started to vibrate in the shutter shaft unit. There were no warning lights illuminated. The vehicle was taken to the dealer and was diagnosed with front CV axle failure. The vehicle was repaired; however, the failure persisted. On a separate occasion, the vehicle started to shudder, and the vehicle was taken back to the dealer. The vehicle was repaired for the most recent failure however, the contact stated the vehicle had been repaired three times, for the CV axle failure. The manufacturer was made aware of the failure. The failure mileage was approximately 32,807.

Stability control disabled, steering assist disabled, airbags disabled, brake system altered for weeks before service request. In addition, steering wheel moved uncontrollably while parked, with car off, and no one in it for over eight hours. Finally, entire system locked after a factory reset. Locking the doors, preventing entry, and showing the transmission in neutral. Tesla's service model is inhuman, meaning they don't allow conversation with a human, but instead require scheduling service through their phone app. The app recorded these issues and were attached to the service request. Tesla's service center claims they resolved the issue by adding wiper fluid and checking the tire pressure. After two weeks, they cannot find anything in the car logs, after previously stating the car logs every aspect of operation.

Sept 9th, 2023 while driving on the interstate the vehicle lost all propulsion power, red lights shown in "gear, P N D" indicator area. I was in left lane and had to get to the side of the road, 4 lanes over, where putting the car in park and back in drive allowed for it to move forward again. I proceeded to a charging station to inspect the car and during this I hear a thump in the trunk area when going over bumps. Upon inspection under the car the rear access cover was hanging down but it was dark. The following morning a closer look revealed the rear subframe where the engine mounts had broken and a large piece of the frame was missing from the inside down. Mounting tab and hardware were still in place but pulled from the structure itself. The car was not handling correctly as if it had a low tire but tire pressure was correct. …

On hard acceleration (in motion), the car vibrates and rattles from the front end. Tesla said they do not have a fix. Lots of people are complaining about it. I frerl something major is wrong with the car and Tesla is doing nothing to fix the problem.