Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2019 Ram 2500 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2019 Ram 2500. The contact stated that while driving at an undisclosed speed, there was an abnormal burning odor inside the vehicle. The contact assumed that the odor was coming from the AC and turned off the AC. No warning light was illuminated. The contact parked and turned off the vehicle at the residence. Later that night, the contact heard a loud bang coming from the vehicle. The next morning, the contact and her friend looked under the hood and discovered that the fuse box, harness, and cables were all melted. The contact used electrical tape to separate the cables. Upon investigation, the contact discovered on the NHTSA.GOV website that the VIN was included in NHTSA Campaign Number: 25V720000 (Engine and Engine Cooling). The manufacturer was made aware of the failure, and a case was filed. …
March 10,2023 2019 Ram 2500 Cummins 6.7L Diesel I picked up my truck from the dealership this morning, after they did the outstanding CP4 fuel pump recall. I drove the vehicle home (approx 20) miles. Parked the car in the driveway for about 3 hours. Then took a short trip to the store. After the store, when leaving the parking lot I noticed an electrical/plastic smell. Within in seconds smoke started to come through the air vents. I pulled the truck over, turned off the truck, open the hood when fire exspelled from the engine compartment. Immediately call the fire department. They arrived in minutes to put out the fire, but at that point the whole front end of the truck was on fire and smoking (dense white/gray smoke). Then there was a loud burst of flame that came from the engine compartment. The fire worked its way into the cab compartment, burned it completely. The truck is totaled.
Initially I witnessed a large volume of smoke coming from the exhaust pipe when pulling up to fuel pump. A passer-by informed me that there were flames underneath the truck on the passenger side. I then got out of truck, stooped down to look underneath, and observed a hose leading from the exhaust system on fire and multiple exhaust components glowing red hot. After getting my passenger out of the truck I got back in, put it in drive and pulled forward away from the fuel pumps and made it about forty feet before truck engine stalled. I then proceeded to get a fire extinguisher from the fuel pump lanes and extinguish the fire and directed the remaining agent at the hotspots to cool them. After the fire department ensured the vehicle was safe to move it was towed to the local RAM dealership where it is now awaiting service technicians to inspect the damage after the weekend.
The contact owns a 2019 Ram 2500. The contact stated that while driving at 50 MPH, there was blue and white smoke coming from the engine compartment. The vehicle was taken back to the residence. The contact saw a cloud of smoke coming from the engine compartment. The contact waited to see where the smoke was coming from and attempted to start however, the vehicle failed to start. The vehicle was then towed to an independent mechanic, where it was diagnosed, and it was determined that the high-pressure fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and filed a complaint. The failure mileage was 110,000.
Smoke emanated from the engine bay shortly after starting the vehicle first thing in the morning. The temperature outside was less 40*. Shortly after seeing smoke, the engine bay was engulfed in flames, centered on the hood, near the windshield. Newer vehicles have fire risk recalls regarding the intake-grid heater shorting out, but not the 2019 model. The grid heater would have been on due to the temperature. Please see the reports from the Police and Fire Department attached. The truck was totaled.
The contact owns a 2019 Ram 2500. The contact stated that while driving approximately 25 MPH, the engine started to knock. The contact took the vehicle to the dealer who diagnosed that the fuel injector pump had blown out and caused other damage to the engine. The engine needed to be replaced. The vehicle had not been repaired. The manufacturer was aware of the issue and opened a case. The approximate failure mileage was 48,000.
In August 2020, while I was driving my vehicle at approximately 15 mph, with approximately 13,500 miles on the odometer, I noticed that the vehicle's transmission gauge was about 230-240 degrees. I pulled over and smelled smoke. Luckily, my passengers and I were able to get out of the vehicle. The vehicle was completely destroyed. I have video showing flames coming out of the passenger side engine compartment. I had previously taken my vehicle in for repair for recall W03 to have the transmission valve body replaced so the transmission wouldn't cause an engine fire. FCA had an expert inspect the vehicle and he found that "fire progression appears to be from engine compartment thru entire vehicle terminating at rear truck bed," that "possible source of ignition is hot surface of turbocharger/exhaust components. …
On June 26, 2024 during a long road trip, the vehicle lost power repeatedly in the middle of an area with no road service. It put my safety and that of my passenger at risk on the highway as losing power suddenly causes danger in fast-moving traffic causing the risk of potential collisions with other vehicles. There was no warning lamp indicating the failure would occur. To this date, the dealer has not fixed the issue. After approximately three weeks, I picked up the vehicle after it as allegedly repaired (at that time the dealer stated it was an electrical issue). The vehicle failed again not more than one-half mile from the Omak Dodge service center placing my safety at risk yet again. I managed to get the vehicle back to the service center at which time, the dealer stated after consultation with RAM technical support, that the issue was a failure in the fuel system. …
I was driving home from the market and the truck slowed down to 16 mph. I could not go any faster. I pulled over to the middle of the street and turned the truck off for a minute. I then restarted it and attempted to drive it somewhere safe. The truck finally came to a stop right before an intersection. I had to get out because cars were coming fast. I was afraid someone was going to hit me. I called AAA right away. They told me the tow truck was on the way and that they would send the police. The police never showed up. The tow truck got there in about 15 minutes. The only information i have is the fuel system has a error code of P0087 and reads Fuelrail system pressure-too low. Check engine light is on, It did say something about the fuel system and the truck will not start. No one has looked at the truck yet. …
I have been having issues starting my truck when I took it in they said it was an ecu reflags needed. I believe it is an open recall y78 for over a year and they do not have the part. But my truck all of a sudden loss power on the freeway doing 65 my wife and daughter started crying I barely made it to the edge of the freeway with being hit within inches of a semi truck. We sat on the side of the freeway with trucks passing us shaking our truck from the wind. Finally I had to call Chp to have cars slow down when it became night time I fears for the safety of my wife and daughter. Yes the issue now is it won't start at all but they are telling me go somewhere else it could take 2-3 months to fix the issue. No one inspected it yet just that it wouldn't start. It was continuously having power surges but too light. …
Engine complaints in other 2500 years
Frequently asked questions
How common are engine problems on the 2019 Ram 2500?
NHTSA has 34 complaints about the engine & cooling of the 2019 Ram 2500, 18% of the model year's 193 complaints.
Is there a recall for 2019 Ram 2500 engine problems?
No. NHTSA lists no engine & cooling recall for the 2019 Ram 2500, though it has 12 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2019 Ram 2500 engine problems start?
Half of the complaints with a recorded mileage happened before about 7,000 miles, and 79% before 25,000 miles.
Is it dangerous?
Owners linked 0 crashes, 6 fires and 2 injuries to engine & cooling problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.