2017 Ram 2500 Engine Problems

Which parts fail

• Cooling system
  1
• Engine › Gasoline › Turbo/supercharger
  1
• Exhaust system › Emission control › Gas recirculation valve (EGR valve)
  1

Components named in complaints (engine, cooling system, oil leaks, timing chain, exhaust).

Mileage when the problem started

• Under 25k
  624%
• 25k–50k
  416%
• 50k–75k
  312%
• 75k–100k
  520%
• 100k–150k
  416%
• 150k+
  312%

Owner reports

Selected complaints filed with NHTSA by 2017 Ram 2500 owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact's husband owned a 2017 Ram 2500. The contact stated that prior to the failure, the dealer replaced the crankcase filter and performed other unknown maintenance services. The contact stated that after her husband remotely started the vehicle, there was smoke coming from underneath the hood and smoke entered the cabin of the vehicle. The contact's husband opened the hood and noticed there were flames coming from the engine compartment. The contact's husband extinguished the fire with a hose. No injuries were sustained, and no medical attention was received. No police or fire department reports were filed. The contact related the failure to a faulty solid-state intake heater grid relay located in the engine compartment; however, the vehicle was not diagnosed nor repaired. The vehicle remained in the driveway and was not yet deemed totaled by the insurance company. …

The contact owns a 2017 Ram 2500. The contact received notification of NHTSA Campaign Number: 24V896000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not available. The contact stated that while driving at various speeds, the ABS and check engine warning lights illuminated. The vehicle was initially taken to the dealer to be diagnosed. The diagnostic test determined that there was a failure with the ECM. The ECM was replaced; however, soon after the repair, the warning lights returned with the vehicle going into LIMP Mode. The vehicle was taken back to dealer, where the vehicle remained for months while attempting to determine the cause of the failure. The contact was then informed that the transmission needed to be replaced. …

The contact owns a 2017 Ram 2500. The contact stated that while driving at highway speeds, the check engine, traction, and ABS warning lights illuminated. Once the warning lights had appeared, the speedometer, odometer, and cruise control functions failed to operate as needed. The contact also stated that the transmission failed to shift out park(P). The vehicle was taken to an independent mechanic, where a code reader determined that the failure was linked to the ABS control module. The contact then received notification of NHTSA Campaign Number: 24V896000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. …

The contact owns a 2017 Ram 2500. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the failure occurred intermittently. The vehicle was taken to the dealer where it was diagnosed with a failed turbocharger and that the turbocharger needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the dealer where it was diagnosed with a failed transmission and cooling lines, and it was determined that the transmission and the cooling lines needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to report the failure to the NHTSA Hotline. The failure mileage was approximately 135,800.

The contact owns a 2017 Ram 2500. The contact stated that while driving at various speeds, the vehicle hesitated to accelerate as intended while the accelerator pedal was depressed. The "Low Coolant" warning light was illuminated. The contact was able to pull over to the shoulder of the roadway. While inspecting the vehicle, the contact became aware that the vehicle was experiencing excessive coolant consumption. The vehicle was taken to a local dealer, where it was diagnosed that the EGR system had failed and needed to be replaced. The vehicle was not repaired due to the cost. The vehicle remained at the local dealer for further tests. The manufacturer was made aware of the failure. The failure mileage was approximately 93,000.

The contact's son owns a 2017 Ram 2500. The contact stated that while her son was driving at an undisclosed speed, the vehicle loss motive power without warning. The vehicle was taken to the dealer, but the dealer could not replicate the failure after test driving the vehicle for 75 miles. The failure recurred after the contact's son received the vehicle back from the dealer. The vehicle was not repaired and was waiting for an unknown part to arrive in December for the dealer to replace. The manufacturer was made aware of the failure and a case was opened and the manufacturer provided a rental vehicle for the contact's son. The failure mileage was approximately 35,000.

The contact owns a 2017 Ram 2500. The contact stated that while driving 25 MPH, there was an abnormal sound coming from the vehicle. The contact stated that upon inspecting the vehicle, there was a squeaking sound coming from the coolant pump. The dealer was contacted by phone and made aware of the failure. The contact referenced an unknown recall; however, the VIN was not associated with a recall associated with the failure. The manufacturer was contacted by phone and made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 120,000.

The contact owns a 2017 Ram 2500. The contact stated that after starting the vehicle, the check engine warning light remained illuminated. The contact stated that a diagnostic scanner was used to retrieve DTC: P2609; which indicated a failure in the intake air heater system. The vehicle was not yet repaired. The local dealers were contacted and indicated that the part was not available to order. No further information was available. The manufacturer was not yet contacted regarding the failure or parts availability. The failure mileage was 123,200.

The contact owns a 2017 Ram 2500. The contact stated while jump starting another vehicle, the contact noticed that the oil dip stick was not secured. The contact pushed the dip stick back into place. On another occasion, the contact was having the battery changed and the oil dip stick was not secured again. The vehicle was not taken to the dealer. The manufacturer was contacted. The failure mileage was 95,000.

We bought our truck in August 2023. At the end of January 2024 a light came on saying we had 150 miles before the engine shut down to 5 mph. A week later we get a recall letter, and take it to a dealership, they fix the recall they said, but before we got home, the light came on again. They told us to drive it a few days and it might go off. It stayed on we took it back to dealership. The recall apparently says to reprogram the def system. That is not the problem. The dealership said they did their part. Carmax said they don't cover anything. We did buy an extended warranty. They came in an inspector looked at the truck and approved to only replace the def injector, one nut and a sensor. The problem that we face is that when they go to replace the deaf injector it possibly is going to damage the STR or SCR pipe no one will cover that. …

Related recalls

Engine complaints in other 2500 years