Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2018 Mazda CX-5 owners, lightly cleaned up (personal details are redacted by NHTSA).
While driving, my car has stopped two times. first time I crashed on the side of road causing all of my tires and rim busted and had to replace all of them. I had no idea what was going on. second time I was taking kids to school where can just stopped in the middle of road and restarted. Recently it was smelling so I took it to dealer where they said its one of the cylinder and its not safe to drive so they replaced it as its under warranty. While my car is been with Mazda dealer I have been using their loaner car. but then received this letter of Safety recall on similar issue i had in the past and i have been trying to contact Mazda but no success. no email, chat or phone call response. I do not feel safe to drive this car which i bought in 2018, its been having lot of engine related issues. and i do not feel safe to drive this car with my kids in it. …
My 2018 CX5 just hit 50,000 miles recently and I smelled something burning and saw smoke coming from the hood while I was stopped for a school bus. I immediately stopped driving due to fire concerns. The vehicle has a cracked cylinder which is a known issue for this vehicle. Mazda has no plans to correct this issue other than issuing a technical bulletin. I feel that Mazda should repair this at their cost because it is a defect and the vehicle only has 50,000 miles. Instead I have to pay nearly $5,000. This is hard to believe! Transcript from dealer: The technician reported an oil leak from the cylinder head, specifically indicating a crack in the number four lifter valley that is causing fluid to leak down the engine block. This issue is recognized as a known problem, and the technician will check if it is covered under warranty. …
2018 Mazda CX-5, 58,182 miles. Report date is 3/7/2026, low mileage for it's age. Vehicle has been exclusively purchased and serviced at the same authorized Mazda dealership for the lifetime of the vehicle, with all maintenance records on file. I began experiencing a strong burning oil smell inside the passenger cabin while driving. The fumes were noticeable to both the driver and passengers, creating a potential carbon monoxide/combustion fume exposure hazard that posed a safety risk to all occupants. Upon bringing the vehicle to the dealership, the technician diagnosed a cracked cylinder head requiring full replacement. This is a significant structural engine defect. Despite the vehicle being dealer-serviced its entire life, the repair cost was initially placed entirely on the owner. …
2018 Mazda CX-5, 2.5L NA Has been diagnosed with leak in the cylinder head cover, which has resulted in engine oil leaking directly onto the exhaust manifold. This leak produces significant smoke and a strong burning oil smell while the vehicle is running. There are numerous reports on Mazda owner forums describing the same issue occurring in Mazda CX-5 models. Some owners even reported instances of minor fires or active burning under the hood due to oil contacting hot components. Mazda released Technical Service Bulletin TSB #SA-031-21, which includes a redesigned cylinder head for the 2018-2019 CX-5 models. This bulletin demonstrates Mazda's awareness of the design flaw. The TSB only covers turbo 2.5L engines and not normally aspirated engines. There is substantial evidence that this is a widespread defect in these model years, unrelated to owner misuse or vehicle mileage. …
I purchased my CX-5 from Mazda dealership when new. The vehicle has been having coolant issues where the Electronically controlled thermostatic valve (ECTV) will open prematurely at 120 F instead of at higher temperatures. This all leads to higher fuel consumption, premature wear and tear on the engine, higher water condensation in the engine oil, poor engine and cabin air performance. I had it diagnosed at the Mazda dealership where I bought it from (Previously it was Sussman Mazda of Abington, now Fred Beans Mazda of Abington in PA) and they said the values are admissible by Mazda and not indicative of a problem. However, my vehicle cannot reach normal operating temperature of 198 F when driven for 50 miles at ambient 28 F for over an hour due to premature opening of the ECTV at lower temperatures. …
I find I have to put my foot down on the gas pedal to the floor to make it literally go at times. Ive heard this cloaking noise several times like its getting ready to conk out. The brakes seems to me don't stop as they should at times I have to go in hard on the brake pedal. The air conditioner does not blow cold an see where previous owner had same issue 2 yrs straight from looking the the service invoices that was left in the truck. The sensor detection does not always work to let me know car/person is around. Coleman Taylor Transmission informed me that this thing does have a issue, the rpm are not as they should be. When I took it back to Kia Gossett about the brakes the used mgr drove it made it seems there were no issues as well as Norcross Mazda. Previous owner invoice show brakes were a concern as well. …
Noticed an oil smell when driving the vehicle, slightly premature to when it was due for an oil change. Engine was emitting light blue smoke when parked after driving for more than 20 minutes. Took the car to a Mazda dealership to get serviced two days after noticing the issue and was told that the cylinder head was cracked and needed to be replaced. There was oil leaking from the vehicle, which I had not noticed, and it had soaked a lot of the front undercarriage of the car. Research into the effects of an oil leak indicate that it can cause a serious malfunction of the engine and other components of the car, but I did not experience that in the time of noticing the problem and taking the vehicle to get serviced. The problem was diagnosed by the service department at a Mazda dealership and is being repaired there. The oil indicator came on a day after noticing the smell.
We purchased our vehicle from Riley Mazda in September 2018. Shortly after reaching approximately 50,000 miles, we began to notice that the gauges would fluctuate, and there was a slight burning odor in the car cabin. We replaced the air filters for both the engine and cabin, as well as performed an engine oil change. In October, we had a brake flush done when we inquired about the burning smell coming from under the hood. Despite our concerns, the dealership was unable to identify any problems at that time. On a subsequent visit, we paid a diagnostic fee of $220.00. It was during this visit that the dealership discovered an issue with the engine. The newly identified problems will significantly impair the vehicle's performance and decrease its value. Additionally, we anticipate needing future repairs, which could pose serious safety hazards.
Like many other complaints. My 2018 Mazda cx5 GT is having the same issue with the cracked cylinder head. I only have about 36-38k mileage on it ( I forgot the exact). Mazda dealership will not cover the cost. NEVER had an accident to the front and only one accident to the back when I got rear ended in 2019. If this is a wide spread issue, why is this not a recall? and why is it only the turbo engine gets extended warranty? The repair cost right now approximately $9,500. I never do any maintenance at Mazda so I doubt they will give me the good will assistance but I am still waiting for an answer. I hope NHSTA will do something because this issue will continue with all other owners that have the same year model.
Noticed a burning oil smell coming from the car along with leaking oil in the driveway. Vehicle has 53000 miles on it and was 3 months out of powertrain warranty but still under the 60000 mileage cap. Local Mazda dealership came back saying that it was a "SA-037/23 Oil leak at cylinder head, cylinder head replacement with parts kit" and quoted $5100 to repair. Dealership stated that the vehicle was unsafe to operate. There were no dash indicator lights or symptoms of overheating to indicate that there was a problem outside of the smell. After the diagnosis was made, we researched and found that this was a commonly reported problem for this model year
Related recalls
Power train › Automatic transmission › Control module (TCM/PCM/tecm)
Mazda North American Operations (Mazda) is recalling certain 2018-2019 CX-5, Mazda6, and 2019 Mazda3 vehicles. A software error in the powertrain control module (PCM) may cause the engine to stall.
Remedy: Mazda will notify owners, and dealers will reprogram the PCM software, free of charge. The recall began August 20, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4.
Transmission complaints in other CX-5 years
Frequently asked questions
How common are transmission problems on the 2018 Mazda CX-5?
NHTSA has 42 complaints about the transmission & drivetrain of the 2018 Mazda CX-5, 12% of the model year's 351 complaints.
Is there a recall for 2018 Mazda CX-5 transmission problems?
Yes — NHTSA recall 19V-497 (control module (tcm/pcm/tecm), Jun 27, 2019). Recall repairs are free at authorized dealers.
At what mileage do 2018 Mazda CX-5 transmission problems start?
Half of the complaints with a recorded mileage happened before about 2,000 miles, and 100% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 0 injuries to transmission & drivetrain problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.