Wheel & Tire complaints by model year
Which parts fail
Components named in complaints (wheels, lug nuts, original-equipment tires, TPMS).
Mileage when the problem started
What owners report
My vehicle is operated in minnesota where road salts are in constant winter use. On August 21, 2019 my mechanic hoisted my SUV and we watched with surprise as some flat rust slabs fell to his shop floor. He looked above the fall location: the spare tire is attached just below a well, and within the spare-tire wheel-gaps were additional loose rust slabs that had not yet fallen. They were removed. The mechanic then pondered a likely cause: he reasoned the metal plate (and/or the areas alongside it) that helps secure the spare tire might be excessively rusty. To see it he had to insert his head up into the well, but which did not give him enough of clear view to assess the matter adequately (nor could I manage to get much of a look). …
While driving 2004 Isuzu Rodeo vehicle vibrates, rear seat make noise and cd players is not working. The consumer was told the tires were feathering, even though the previous mechanic stated they only needed to be rotated.
The accident was caused by tire tread separation on the back passenger end. I was going 75 MPH (the speed limit) on interstate 10 when the tread separated. I lost control of my SUV (2001 Isuzu Rodeo) and nearly rolled it a few times, ended up spinning around and going backwards through the dirt median heading into oncoming traffic. I hit a tree, which saved my life. This event could have been very catastrophic. The tire was a Bridgestone dueler 684. It was purchased 1/4/05, but it was technically 4 years old when I bought it new. The tire was actually manufactured in 2001. The rear end damage was repaired by a collision center and for fear of tire safety, I replaced all other Bridgestone tires with Michelin.
Tl* the contact owns a 2001 Isuzu Rodeo. The contact stated that there was a noise coming from the vehicle. The vehicle was taken to a repair shop, where they stated that the front and rear tie rods and wheel bearings were defective. The mechanic also discovered that the underbody of the frame was corroded, especially on the driver's side. The mechanic refused to make any repairs. The failure was related to the recall associated with NHTSA campaign id number: 10V436000 (suspension: rear); however the manufacturer stated that the VIN was not included. The approximate failure and current mileages were 117,000. Updated 8/23/12 the consumer stated there was a slow leak on the front passenger side tire. There was also a slow leak on the rear driver's side tire since the purchase of the vehicle. Updated 09/06/2012
I took the dealer Isuzu to lemon law and I was told it works as designed. The jury was so stupid it was un believable, they all came up to my wife and I and said make sure you take the car to the dealers to get it fixed. Ahhhhhhhhhhhhh isn't that why I am here in court? Good luck people are stupid and we are stuck driving an unsafe care because consumer reports will not get involved. Lemon cars for sale any Isuzu cheap (related vehicle information: model year=2000, make=Isuzu, model=Rodeo).
I think the time has come for the NHTSA to seriously consider getting the remaining Isuzu Rodeo's off the road - they are not safe. I like a majority of other Isuzu owners suffer from excessive corrosion all over the frame - I had the recall repair done and this was supposed to be treated but it has progressively gotten worse and now I am at the point where I have a reliable everyday car that starts up right away, runs well and cuts through the snow (4x4) but due to manufacturing errors now has a flaky, brittle hole ridden wheel well frame on both sides that will cause an accident after the wheel goes flipping off the car and causing it to flip over. Isuzu has turned a blind eye and won't take any calls (once you find them). A recall must be issued and make the manufacturer take responsibility for whatever shady processes they used on the assembly line. …
Repeated occurrences of antilock braking system taking over control of brakes while braking at low speed. Problem is most pronounced when roads are wet or when traveling over bumpy surface with moderate brake pressure applied. First occurrence was two months after vehicle was purchased while driving on wet roads. Vehicle approached intersection with railroad crossing. Moderate braking pressure caused antilock brakes to take over just as vehicle was bumping over railroad tracks. Vehicle was unable to stop. Luckily, no other vehicle was at intersection at the time. Vehicle ended up completely inside intersection. Driver backed up to behind painted lines and was very startled as to action of braking system. Problem occurred again on wet road at smooth intersection. …
I have had this truck for just over a year now. I have had issues from day one. There has been a constant shimmy in the front end. Tires balanced, rebalanced and balanced again. This did not solve the problem. The tire manufacture recommends 30 psi in the tires. The Isuzu people ask for 26 psi...at this pressure the vibration get worse...the tires squeal and the truck feels out of control if on a rough road. The truck is under sprung and if the tires are inflated to 30 psi is is almost undrivable. Makes me think of the Ford/Firestone issue. Might be a problem. The tires wear too quickly...balanced,aligned no help. Dealer tells me this is how the truck is. The other major issue is the oil use...this truck will use, lose somewhere, 1 qt per 500 miles or so. Dealer tells me to check the oil level at every fuel-up....I feel this is bull. …
Frequently asked questions
Which Isuzu Rodeo years have wheel & tire problems?
By NHTSA complaints, the 1995 (35), 1996 (24), 1997 (19), 1999 (19) and 1998 (18) model years. Wheel & Tire complaints make up 20% of all complaints for the 1995.
Is there a recall for Isuzu Rodeo wheel & tire problems?
No. NHTSA lists no wheels & tires recall for any Isuzu Rodeo model year. A widespread problem may still be covered by an extended warranty or a manufacturer service bulletin, so ask a dealer.
At what mileage do Isuzu Rodeo wheel & tire problems start?
Across all years, half of the complaints with a recorded mileage happened before about 77,000 miles; 21% happened before 50,000 miles.
What part fails most often?
Owners most often name the lugs/nuts/bolts/studs (73 mentions), followed by the tread/belt (15).
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.