Which parts fail
Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2019 Hyundai Tucson owners, lightly cleaned up (personal details are redacted by NHTSA).
I was driving on the highway. The engine began making a ticking noise that momentarily went away and then quickly got louder. I saw white smoke out of the back, pulled over, and then saw black smoke from the front. The check engine light only momentarily came out AFTER the white smoke was visible and I was actively pulling over. I ran out of the car, and turned to look only to see a fire under the engine bay. I did not have a collision nor hit anything on the road. Engine had full synthetic oil in it, and the oil was changed less than 10,000 miles precious. (Also checked oil level/condition the week before). The car went from driving fine, to entirely engulfed in flames within 2-4 minutes. Maine state police: case# 245000657 The vehicle has not been inspected by the insurance company yet. The report will be sent to me, and it is currently available for inspection upon request. …
I was driving approx 55mph on [redacted] in my 2019 hyundai tucson when the check engine light came on and the engine started to stall. I felt the acceleration dying down in the middle of busy highway traffic. Gray smoke started coming from the hood cracks. I luckily was in the right lane already, so when I could I veered off to the shoulder and the car quit. The smoke was increasing badly. Ppl from the highway were yelling its going to blow up get away from it! I was so scared. I grabbed my phone and keys and ran as far as I could while dialing 911. Within a couple minutes flames were swallowing the entire engine and front of the car. I am furious. I researched online and hyundai has had many similar incidents with this car and other with this engine ! These need to be banned and taken off the road before they kill anyone else. …
The contact owns a 2019 Hyundai Tucson. The contact stated that while at a red light, the missing key warning light illuminated. The check engine warning light illuminated. The hazard lights were independently deactivated. The contact became aware of an abnormal odor and smoke on the interior of the vehicle and the exterior of the vehicle. The contact stated that all the door latches were independently locked, and the engine seized. The contact stated that her minor child was also an occupant of the vehicle at the time of the failure. The contact stated that a nearby Police Officer and other bystanders assisted with removing the contact and the minor child from the vehicle. The contact stated that it was a very traumatic experience, and the contact was very fearful for the lives of her minor child and herself. …
On March 21st, while driving my Hyundai vehicle, I noticed the vehicle began making a ticking sound. After stopping the vehicle, it slowly began catching on fire. The fire ultimately spread and resulted in the vehicle becoming a total loss. This created a serious safety concern and placed me at risk. I later learned there was a recall associated with the vehicle. However, I never received any recall notices because Hyundai reportedly had the wrong address on file. Had I been properly notified of the recall and potential safety risks, I would have done everything in my power to ensure the vehicle was inspected, repaired, and safe to drive. Because I was unaware of the recall issue, the vehicle continued to be operated without my knowledge of the potential danger. …
The contact owns a 2019 Hyundai Tucson. The contact stated while the contact's husband was driving, the contact noticed an abnormal loud sound. In addition, the contact noticed smoke coming from the front of the vehicle. No warning lights were illuminated. The contact noticed an unusual odor in the interior of the vehicle. The contact's husband drove the vehicle to the shoulder of the road. The contact stated that the engine seized. In addition, the contact stated that the smoke and the unusual odor subsided. The vehicle was towed to the contact's residence. In addition, the contact stated that when the failure occurred, the contact's minor children were occupants of the vehicle. The contact stated that the minor children were frightened. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure. …
The contact owns a 2019 Hyundai Tucson. The contact stated that upon entering the vehicle, there was water overflowing from the front passenger's side floormat. The vehicle was taken to the dealer, but the water entry point could not be determined. Additionally, the contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer, where a brake sensor was replaced; however, the failure recurred. The vehicle was taken back to the dealer, where another brake sensor was replaced; however, the failure persisted. The vehicle was taken to the dealer, who diagnosed that the wiring harness had sustained water damage and corrosion due to a clogged sunroof drain. The dealer determined that the wiring harness needed to be replaced. The vehicle was not repaired due to the cost. …
The contact owns a 2019 Hyundai Tucson. The contact stated that while driving 50 MPH, there was a burning odor coming from the vents, with the battery warning light illuminated. The vehicle was taken to the service center, where it was diagnosed with alternator failure. The contact was informed that the alternator needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that the alternator had been replaced three times with aftermarket parts and a fourth time with an OEM part. After inspecting the alternators, the contact noticed that the copper wires inside each alternator were black due to the failure. The contact was concerned that a previous recall associated with the failure did not properly fix the vehicle. The manufacturer was made aware of the failure by telephone, and a case was opened. …
The contact owns a 2019 Hyundai Tucson. The contact stated while in her daughter's possession, the engine had failed to start after multiple attempts. Several warning lights illuminated the instrument panel during the failure. The vehicle was jumpstarted and the horn began to blare once the engine restarted. The vehicle was taken to a dealer where they were unable to determine the failure. The contact also stated that the vehicle would rattle while both idle and upon activation of the AC. The manufacturer was notified of the failure and the contact was given to a case manager; she was later instructed by the case manager to take the vehicle back to the dealer for assistance. The vehicle had yet to be repaired. The failure mileage was approximately 23,000.
The contact owns a 2019 Hyundai Tucson. The contact stated while driving approximately 30 MPH, the vehicle stalled. The contact stated that the vehicle lost power steering and brake functionality. The contact stated that the instrument panel went blank. The contact was able to restart the vehicle. The contact stated that the failure recurred. Additionally, the vehicle was hesitating and jerking while driving at various speeds. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the engine knock sensor software needed to be updated. The vehicle had been repaired. The contact stated that the failure had reoccurred. The manufacturer had not been informed of the failure. The failure mileage was approximately 62,000.
I believe that this car is a lemon. Ever since we bought it we have problems with the engine not performing right. I have got the engine system cleaned multiple times one at the dealership and one at Valvoline Oil Change facility. The engine still didn't run smooth. I would always get the oil changed on time and the vehicle has never been in a accident. Now just yesterday the vehicle while driving on the highway just stalled and wouldn't accelerate past 60mph. Now the check engine light is blinking and all of the lights on the dash are on. Also lately sometimes the forward collision lights will come on and other warning lights and sometimes they wont. Another light that intermittently comes on are the auto hold and epb light and this has been happening since we bought the vehicle. I have taken into Hyundai and they basically were like yea sometimes that happens. …
Electrical complaints in other Tucson years
Frequently asked questions
How common are electrical problems on the 2019 Hyundai Tucson?
NHTSA has 47 complaints about the electrical system of the 2019 Hyundai Tucson, 12% of the model year's 385 complaints. The component named most often is instrument cluster/panel (1 mentions).
Is there a recall for 2019 Hyundai Tucson electrical problems?
No. NHTSA lists no electrical system recall for the 2019 Hyundai Tucson, though it has 1 recall for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2019 Hyundai Tucson electrical problems start?
Half of the complaints with a recorded mileage happened before about 12,000 miles, and 71% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 3 fires and 0 injuries to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.