Most common 2019 Hyundai Tucson problems
Share of the 385 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Hyundai Tucson complaints by model year
Best Tucson years: 2011. Years to avoid: 2025, 2016, 2017, 2022, 2023. Compare all years →
2019 Hyundai Tucson recalls (1)
Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module
Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles.
Remedy: Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge.
NHTSA defect investigations
Federal safety investigators have looked into 2 possible defects involving the 2019 Hyundai Tucson:
Loss of Motive Power
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021.
Hyundai and Kia ABS Module Fires
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando.
What 2019 Hyundai Tucson owners say
Engine & cooling all 204 →
The contact owns a 2019 Hyundai Tucson. The contact stated that while driving at 5 MPH, the vehicle slowed down. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the knock sensor needed to be replaced. The vehicle was repaired, but the failure recurred. While driving, a month later, the vehicle slowed down. The vehicle was taken back to the local dealer, where it was diagnosed that the knock sensor needed to be replaced. The vehicle was repaired, but the failure persisted. The vehicle was taken back to the local dealer, where it was diagnosed that the engine needed to be replaced. The engine was replaced. Additionally, while driving, an unknown vehicle crashed into the rear of the vehicle, and it continued to move forward. The steering wheel became stuck and was uncontrollable. …
The contact owned a 2019 Hyundai Tucson. The contact stated while driving approximately 55 MPH the vehicle started smoking and overheating. The contact was able to pull over safely. There were no warning lights on the instrument panel. Once the vehicle stopped the doors were automatically locked. The nearby drivers notified the contact of the fire under the vehicle. Once the contact exited the vehicle, the engine was destroyed by the fire. The inside of the vehicle was still functional. The state police arrived on the scene; however, a police report has not been obtained. The fire department also arrived and extinguished the fire. The vehicle was towed to a wrecking yard. The manufacturer was not notified of the failure. There were no injuries or medical reports. The approximate failure mileage was 40,000.
Brakes all 118 →
The contact owns a 2019 Hyundai Tucson. The contact stated that while his wife was driving at low speeds, pulling into a parking spot on an incline, the vehicle accelerated and failed to stop. Then the vehicle traveled through several 15-gallon pots with trees, a patio, elliptical machines, and a wooden fence. The driver veered to the left, went down a mountain approximately 30 feet, continued down the hill, and crashed into a pine tree where it came to a halt. The occupant in the front passenger seat sustained a concussion. The driver sustained injuries to her lip and medical attention was provided. There were no warning lights illuminated. The vehicle was towed to the police station. A police report was filed. There was no reported fire. The driver's side front and passenger side front air bags were deployed. The local dealer was not contacted. …
The contact owned a 2019 Hyundai Tucson. The contact stated that while the contact's wife was driving and parking the vehicle, the contact's wife depressed the brake pedal and the service brakes were inoperable. In addition, the contact stated that the anti collision braking system was inoperable and did not function as intended. The contact stated that due to the failure, the vehicle crashed into several oversize planters in the parking lot. In addition, the vehicle crashed into a wooden fence and then crashed into a tree. The contact's seventeen-year-old granddaughter was seated in the front passenger seat of the vehicle. The fire department and the police arrived on the scene. A police report and fire report were filed. The vehicle was towed to a local tow yard. The contact's granddaughter sustained a concussion and currently suffers from headaches. …
Electrical system all 47 →
I was driving on the highway. The engine began making a ticking noise that momentarily went away and then quickly got louder. I saw white smoke out of the back, pulled over, and then saw black smoke from the front. The check engine light only momentarily came out AFTER the white smoke was visible and I was actively pulling over. I ran out of the car, and turned to look only to see a fire under the engine bay. I did not have a collision nor hit anything on the road. Engine had full synthetic oil in it, and the oil was changed less than 10,000 miles precious. (Also checked oil level/condition the week before). The car went from driving fine, to entirely engulfed in flames within 2-4 minutes. Maine state police: case# 245000657 The vehicle has not been inspected by the insurance company yet. The report will be sent to me, and it is currently available for inspection upon request. …
I was driving approx 55mph on [redacted] in my 2019 hyundai tucson when the check engine light came on and the engine started to stall. I felt the acceleration dying down in the middle of busy highway traffic. Gray smoke started coming from the hood cracks. I luckily was in the right lane already, so when I could I veered off to the shoulder and the car quit. The smoke was increasing badly. Ppl from the highway were yelling its going to blow up get away from it! I was so scared. I grabbed my phone and keys and ran as far as I could while dialing 911. Within a couple minutes flames were swallowing the entire engine and front of the car. I am furious. I researched online and hyundai has had many similar incidents with this car and other with this engine ! These need to be banned and taken off the road before they kill anyone else. …
2019 Hyundai Tucson engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.0L 4-cyl | 6-speed automatic | FWD | 23 / 30 / 26 |
| 2.4L 4-cyl | 6-speed automatic | FWD | 22 / 28 / 25 |
| 2.0L 4-cyl | 6-speed automatic | AWD | 22 / 25 / 23 |
| 2.4L 4-cyl | 6-speed automatic | AWD | 21 / 26 / 23 |
EPA ratings. Class: Small SUV.
Frequently asked questions
Is the 2019 Hyundai Tucson a good car?
Based on 385 owner complaints filed with NHTSA, the 2019 Tucson rates avoid: 4.2× as many complaints as a typical year of the Tucson at the same age. It is one of the Tucson years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2019 Hyundai Tucson?
The engine & cooling — 204 complaints, 53% of all complaints for this model year, most often about exhaust system › emission control › catalytic convertor. Next are the brakes (118) and electrical system (47).
How many recalls does the 2019 Hyundai Tucson have?
There is 1 recall for the 2019 Hyundai Tucson, the most recent from September 4, 2020 (control unit/module). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Hyundai Tucson?
The best years by complaints, compared at the same age, are 2011. Years to avoid or approach with caution: 2025, 2016, 2017, 2022 and 2023. See the full Hyundai Tucson years comparison.
At what mileage do 2019 Hyundai Tucson problems happen?
The median mileage reported in complaints is about 21,000 miles; 69% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.