Which parts fail
Components named in complaints (struts, shocks, control arms, ball joints, springs).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2007 Hyundai Santa Fe owners, lightly cleaned up (personal details are redacted by NHTSA).
I am writing to formally report an incident involving the service department at Lakeland Hyundai (1500 W Memorial Blvd, Lakeland, FL 33815). My 2007 Hyundai Santa Fe was brought in on 12/31/25 for an active engine recall involving the Cylinder Head Cover Oil Leak Repair (Recall Code 976 / Campaign 24-01-026H). The vehicle was driven into the dealership in proper working condition. I was later informed that allegedly stripped bolts for the cover would require an out-of-pocket cost of $483.36, despite this being a recall repair. There was also a required Upper Timing Chain Guide repair quoted at $58.38 to complete the recall work. When I was called in on 01/12/26 to pick up the vehicle for completed work, I was charged $29.99 for a Multi-Point Inspection related to the recall, yet no documentation or billing was provided for the timing chain guide repair I was told was completed. …
There was a problem with the steering, so thought may be my wife hit a pothole found out the sub frame was severely corroded rusted and falling apart. My family could seriously got hurt. There was no accident, But there very well could have if she continued to drive ,there has to some form of responsibility of Hyundai add vehicle since it was brand new only 67,000 miles
Owned vehicle since new and have had all services performed. Currently 72,000 miles. Car has been plagued with clunky, noisy suspension problems since about 35,000 miles. Noises and ride at all speeds are so bad that this has to impact potential safety. Dealers have replaced power steering rack; pinion; p/s sway bar; link assembly; lower control arm (2x); p/s front stabilizer link; l/f control arm, bolt and nut. None of the "fixes" have lasted more than a few thousand miles, and we were right back to where we were. We are "easy drivers" who do no offroad or rough road driving. Were it not for these issues, this would be a "decent" SUV.
I have had to replace the control arm 3 times, (2/2013, 4/2014, 3/2015) and about to do it a 4th time (2019). It goes bad after about 20,000 miles and affects the alignment which causes the tires to wear incorrectly. Brand new tires are get worn down on the inside edge and is not visible. This causes a safety issue. My relatively new tire blew out on the highway and nearly caused a crash. I've spent $3000 in repairs and estimate another $1000 in tires that had to be replaced prematurely. I will fill one of these out for each of the incidents described above.
I have had to replace the control arm 3 times, (2/2013, 4/2014, 3/2015) and about to do it a 4th time (2019). It goes bad after about 20,000 miles and affects the alignment which causes the tires to wear incorrectly. Brand new tires are get worn down on the inside edge and is not visible. This causes a safety issue. My relatively new tire blew out on the highway and nearly caused a crash. I've spent $3000 in repairs and estimate another $1000 in tires that had to be replaced prematurely. I will fill one of these out for each of the incidents described above.
I have had to replace the control arm 3 times, (2/2013, 4/2014, 3/2015) and about to do it a 4th time (2019). It goes bad after about 20,000 miles and affects the alignment which causes the tires to wear incorrectly. Brand new tires are get worn down on the inside edge and is not visible. This causes a safety issue. My relatively new tire blew out on the highway and nearly caused a crash. I've spent $3000 in repairs and estimate another $1000 in tires that had to be replaced prematurely. I will fill one of these out for each of the incidents described above.
Exiting from a parking lot onto 7th st in phoenix az, vehicle suddenly accelerated and, despite brake application, entered the roadway, hitting a Mercury grand marquis in the side. Nobody was injured and airbags did not inflate. Once stopped, it was impossible to move the gear shift from neutral into park to release the key. Vehicle towed and, as frame was damaged as well as front end and radiator, insurance are writing the vehicle off.
Tl* the contact owns a 2007 Hyundai Santa Fe. While driving at 15 MPH, the contact noticed a loud clicking sound from the front driver side of the vehicle. The failure also occurred while in reverse. The vehicle was taken to a dealer where it was diagnosed that the front lower control arm bushings needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 116,595.
Tl* the contact owns a 2007 Hyundai Santa Fe. While driving at any speed, the vehicle jerked left and right and leaned on one side without warning. The failure caused the driver to almost lose control of the vehicle. The failure recurred a number of times. The dealer was unable to diagnose or replicate the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.
Steering & suspension :front shock absorber leaking,the vehicle bounces too much, too difficult to control the vehicle. Front struts need to be changed. Ball joints had worn out very fast because front struts are not good. All lower arms and all tie rod end worn out.that change the wheel alignment, unable to control or steer the vehicle .
Suspension complaints in other Santa Fe years
Frequently asked questions
How common are suspension problems on the 2007 Hyundai Santa Fe?
NHTSA has 30 complaints about the suspension of the 2007 Hyundai Santa Fe, 4% of the model year's 684 complaints. The component named most often is front (1 mentions).
Is there a recall for 2007 Hyundai Santa Fe suspension problems?
No. NHTSA lists no suspension recall for the 2007 Hyundai Santa Fe, though it has 7 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2007 Hyundai Santa Fe suspension problems start?
Half of the complaints with a recorded mileage happened before about 79,000 miles, and 17% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 0 injuries to suspension problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.