Most common 2015 Hyundai Santa Fe problems
Share of the 255 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Hyundai Santa Fe complaints by model year
Best Santa Fe years: 2018, 2011. Years to avoid: 2017, 2025, 2023, 2013, 2024. Compare all years →
2015 Hyundai Santa Fe recalls (2)
Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge.
Latches/locks/linkages › Hood › Latch
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Remedy: Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059.
NHTSA defect investigations
Federal safety investigators have looked into 3 possible defects involving the 2015 Hyundai Santa Fe:
Loss of Motive Power
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021.
Throttle control system vulnerabilities
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003.
Hyundai and Kia ABS Module Fires
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando.
What 2015 Hyundai Santa Fe owners say
Engine & cooling all 161 →
While I was driving on the highway in the left lane, smoke came from the engine, then it started coming from underneath the car. The car turned off. I was forced to stop on the left lane of the highway and exit the vehicle and walk as far away as possible. I called 911, then I noticed fire coming from the engine. This was unsafe for myself as well as other riders on the highway. Firefighters came and put out the fire. Once they left, I was left by myself waiting for the tow truck to arrive. No police officers helped to keep myself safe while waiting on the left shoulder once the highway re-opened. When asked if I needed a police report, the police officer said no because it wasn't a crash. The vehicle was inspected by my insurance company and it was deemed a total loss. There were no warning signs or messages or symptoms prior to the failure at all.
On August 2, 2023 I was driving my truck and it completely shut off on me on the highway. I push the start button to turn the engine and it just keep turning like it wanted to start, but it didn't. Called the tow truck to take it to the shop, to then get a call after two days saying that they couldn't find out what was going on, because when they ran the test it didn't come back with any code. The clerk informed me that when he started my truck that next day, it cranked as if nothing was wrong. He drove it around about 15-20 minutes ,and it didn't do anything like what it had done the previous day before. I am very concerned because this could have been a bad outcome because I was in the highway on Wednesday. I need someone to further look into this matter.
Brakes all 29 →
The contact owned a 2015 Hyundai Santa Fe. The contact stated while driving 25 mph, when he lost control of the vehicle and multiple warning lights were illuminated. The contact stated while attempting to park on the side of the road, he saw smoke entering the AC vents. The contact and his son (front passenger) were able to exit the vehicle before it exploded. The contact stated the fire was located in the front of the vehicle. The contact stated no one was injured nor sought medical attention. The fire department was able to extinguish the fire, but was unaware if a fire report was filed. The police report was filed. The vehicle was not drivable. The insurance company deemed the vehicle total loss. The vehicle was towed to a towing yard. The contact called the local dealer and made them aware of the failure. The manufacturer had been informed of the failure. …
The contact owns a 2015 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, he observed smoke emanating from the engine compartment, prompting him to pull to the shoulder of the roadway. After a visual inspection of the engine compartment, the contact observed flames originating near the firewall. The contact was able to extinguish the flames himself with a fire extinguisher. No warning lights were illuminated. A fire report was filed. A police report was not filed, and no injuries were reported. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V303000 (Service Brakes, Hydraulic), and the VIN was included. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 126,000.
Transmission & drivetrain all 22 →
Recent cold weather starts in the morning (40-50 degrees fahrenheit) have caused my car to have poor or stalled acceleration. It will occasionally not go past 20 or 40 mph while the RPMs rev high. The DTC error code would read P2565 as a pending code. An independent mechanic changed out my transmission fluid and switched out my boost pressure sensor but the problem is still there. Hyundai says that they need to replicate the problem but it does not occur when I take it to them so it's very hard to have this intermittent issue diagnosed by them. This is a very dangerous issue in my opinion if your cars engine revs high without accelerating and can potentially cause serious accidents and injury. I know I'm not the only person experiencing this issue as I've read on online forums of other car owners describing the same issue. …
I drove approximately 40 miles to a gas station and went to park in a parking spot and my passenger exited the vehicle and yelled my car was in reverse even though I thought it was in park, upon trying to again put it in park it would not go in the park position. I was stuck in reverse and the vehicle would not park without using the emergency brake. No warning lights or any other message from my vehicle regarding this issue. I then put it in drive and drove home and again was not able to put the vehicle in park, after attempting numerous times and using the interlock system I was able to put it in park. This is a huge safety concern as there could have been someone behind me when parking and not even realizing the car was not in park as it was snowy out and the car was still for a moment before reversing. Upon looking on google it looks as if others may have had this issue as well.
2015 Hyundai Santa Fe engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.4L 4-cyl | 6-speed automatic | FWD | 20 / 27 / 23 |
| 2.0L 4-cyl turbo | 6-speed automatic | FWD | 19 / 26 / 22 |
| 3.3L 6-cyl | 6-speed automatic | FWD | 18 / 25 / 21 |
| 2.4L 4-cyl | 6-speed automatic | AWD | 19 / 25 / 21 |
| 3.3L 6-cyl | 6-speed automatic | AWD | 18 / 24 / 20 |
| 2.0L 4-cyl turbo | 6-speed automatic | AWD | 18 / 24 / 20 |
EPA ratings. Class: Small SUV.
Frequently asked questions
Is the 2015 Hyundai Santa Fe a good car?
Based on 255 owner complaints filed with NHTSA, the 2015 Santa Fe rates average: about as many complaints as a typical year of the Santa Fe at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2015 Hyundai Santa Fe?
The engine & cooling — 161 complaints, 63% of all complaints for this model year, most often about exhaust system › emission control › catalytic convertor. Next are the brakes (29) and transmission & drivetrain (22).
How many recalls does the 2015 Hyundai Santa Fe have?
There are 2 recalls for the 2015 Hyundai Santa Fe, the most recent from September 22, 2023 (control unit/module). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Hyundai Santa Fe?
The best years by complaints, compared at the same age, are 2018 and 2011. Years to avoid or approach with caution: 2017, 2025, 2023, 2013 and 2024. See the full Hyundai Santa Fe years comparison.
At what mileage do 2015 Hyundai Santa Fe problems happen?
The median mileage reported in complaints is about 66,000 miles; 38% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.