Most common 2005 Honda Pilot problems
Share of the 679 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Honda Pilot complaints by model year
Best Pilot years: 2015, 2014, 2012. Years to avoid: 2016, 2017, 2019, 2025, 2021. Compare all years →
2005 Honda Pilot recalls (13)
Air bags › Frontal › Passenger side › Inflator module
Honda (American Honda Motor Co.) is recalling certain 2003-2006 Acura MDX, 2005-2012 RL, 2003-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2007-2008 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles.
Remedy: Honda will notify owners, and dealers will replace the passenger frontal airbag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138.
Air bags › Frontal › Driver side › Inflator module
Honda (American Honda Motor Co.) is recalling certain 2003 Acura 3.2CL, 2002-2003 3.2TL, 2003-2006 MDX, 2001-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot and 2006 Ridgeline vehicles.
Remedy: Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138.
Air bags › Frontal › Driver side › Inflator module
Honda (American Honda Motor Co.) is recalling specific 2003 Acura 3.2CL, 2013-2016 ILX, 2013-2014 ILX Hybrid, 2003-2006 MDX, 2007-2016 RDX, 2002-2003 3.2TL, 2004-2006, and 2009-2014 TL, 2010-2013 ZDX and 2001-2007 and 2009 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2007 and 2010-2011…
Remedy: Honda will notify owners, and dealers will replace the driver's air bag inflator with an alternate inflator, free of charge. The recall began April 10, 2019. Honda owners may contact customer service at 1-888-234-2138.
Air bags › Frontal › Passenger side › Inflator module
Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles.
Remedy: Honda will notify owners, and dealers will inspect and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began June 22, 2018.
Air bags › Frontal › Passenger side › Inflator module
Honda (American Honda Motor Co.) is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2011 Honda Element vehicles, 2005-2012 Acura RL vehicles, 2006-2012 Honda Ridgeline vehicles, 2007-2008 Honda Fit vehicles and 2005-2008 Honda Pilot vehicles originally sold, or ever registered, in Alabama, California,…
Remedy: Honda will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall bagan March 2017. Owners may contact Honda customer service at 1-888-234-2138.
Air bags › Frontal › Passenger side › Inflator module
Honda (American Honda Motor Co.) is recalling certain model year 2003-2006 Acura MDX, 2005-2011 Acura RL, 2005-2006 Honda CR-V, 2003-2011 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2011 Ridgeline vehicles originally sold, or that have ever been registered, in Alabama, California, Florida, Georgia,…
Remedy: Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began June 27, 2016. Owners may contact Honda customer service at 1-888-234-2138.
Show 7 more recalls
Air bags › Frontal › Driver side › Inflator module
Honda (American Honda Motor Co.) is recalling certain model year 2001-2007 Accord, 2001-2005 Civic, 2001-2004 Honda Civic GX, 2003-2005 Honda Civic Hybrid, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot, 2006 Ridgeline, 2003 Acura 3.2CL, 2003-2006 Acura MDX, and 2002-2003 Acura 3.2TL vehicles.
Remedy: Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began on July 1, 2015. Owners may contact Honda customer service at 1-888-234-2138.
Air bags
American Honda Motor Co. (Honda) is recalling certain model year 2001-2005 Honda Civic, 2003-2004 Civic CNG and Element, 2002-2005 CR-V, 2002-2004 Odyssey, 2003-2005 Accord, Pilot, Civic Hybrid, and Acura MDX, 2005 Acura RL and 2006 Honda Ridgeline vehicles originally sold, or ever registered, in geographic locations associated…
Remedy: Honda will notify owners, and dealers will replace the passenger side air bag inflator, free of charge. The recall began January 26, 2015. Owners may contact Honda customer service at 1-800-999-1009.
Air bags
American Honda Motor Company, Inc.'s (Honda) is conducting a limited regional recall for certain model year 2003-2005 Accord, Civic, CR-V, Pilot and Acura MDX, model year 2003-2004 Odyssey and Element, and model year 2005 Acura RL, and 2006 Honda Ridgeline vehicles originally sold, or ever registered in California, and equipped…
Remedy: Honda will notify owners, and dealers will replace the inflators in all affected vehicles, free of charge. The recall is expected to begin during August 2014. Owners may contact Honda customer service at 1-800-999-1009.
Traction control system
Honda is recalling certain model year 2005 Pilot vehicles manufactured July 29, 2004, through August 29, 2005; model year 2005-2006 Acura MDX vehicles manufactured September 16, 2004, through September 22, 2005; and model year 2005 Acura RL vehicles manufactured March 1, 2004, through June 29, 2005.
Remedy: Owners will be notified and instructed to take their vehicles to a dealer of their respective brand. The dealer will install a partial wiring harness containing a capacitor for the VSA modulator, free of charge.
Exterior lighting › Headlights › Switch
Honda is recalling certain model year 2002 through 2004 cr-v; model year 2003 through 2005 pilot; and model year 2002 and 2003 civic vehicles. In March 2012, Honda filed a defect report to recall certain model year 2002 through 2004 cr-v and certain model year 2003 pilot vehicles.
Remedy: Honda will notify owners, and dealers will repair the low beam terminal harness or replace the lighting switch as necessary, free of charge. The original recall began in April 2012.
Steering › Column
On certain minivans and sport utility vehicles, the steering column May be incorrectly assembled, which could result in a loss of steering control.
Remedy: Owners were notified by telephone on January 25, 2005, and arrangements were made to have their vehicles towed to their dealers and have the repairs performed. The recall began on January 25, 2005.
Fuel system, gasoline › Storage › Tank assembly
On certain sport utility vehicles, some fuel tanks were improperly manufactured.
Remedy: Dealers replaced the fuel tank. All owners were notified by telephone on November 10, 2004.
NHTSA defect investigations
Federal safety investigators have looked into 7 possible defects involving the 2005 Honda Pilot:
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag…
Vehicle Stability Assist Malfunction
The Vehicle Stability Assist (VSA) system in the model year (MY) 2005 Honda Pilot vehicles integrates braking control strategies for anti-lock braking, traction control, electronic stability control and brake assist functions. The system consists of a VSA modulator (an electronic control unit and electronic/hydraulic actuator) that receives data from an integral brake pressure sensor and from wheel speed sensors…
Desiccated Air Bag Inflator Rupture
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited.
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag…
Vehicle Stability Assist Malfunction
On March 14, 2013, American Honda Motor Co., Inc. (Honda) submitted a Defect Information Report to NHTSA identifying a defect in the Vehicle Stability Assist (VSA) system in approximately 183,576 model year (MY) 2005 Honda Pilot, Acura RL and MY 2005-2006 Acura MDX vehicles (NHTSA Recall No 13V-092).The population and failure counts provided pertain only to the MY 2005 Honda Pilots that were the subject of this…
Low Beam Headlights Stop Illuminating
This investigation was prompted by Preliminary Evaluation (PE) 11-017, and was based on reports from consumers alleging that both low beam headlights stopped illuminating simultaneously.Some complainants also reported that the combination switch (switch) that controls the headlights and turn signals, and/or its electrical wiring harness connector were damaged by overheating.ODI's PE information request letter asked…
Vehicle Stability Assist Malfunction
In a letter dated April 9, 2012, a consumer petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged stability control failures in model year (MY) 2005 Honda Pilot vehicles. The petitioner alleged that, in the malfunctioning of these systems, steering failures occur and the brakes apply involuntarily.
What 2005 Honda Pilot owners say
Transmission & drivetrain all 176 →
The contact owns a 2005 Honda Pilot. The contact stated while driving at various speeds on several occasions, there was a cranking sound coming from underneath the vehicle. No warning lights were illuminated. The contact stated that the vehicle was taken to an independent mechanic, where it was diagnosed that several unknown components needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that the vehicle was towed to another independent mechanic, where it was diagnosed that the shocks, control arms, drive train and other unknown components needed to be replaced. The contact referenced the failure to NHTSA Campaign Number: 23V228000 (Structure); however, neither the VIN nor the year, make, or model was included. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 149,000.
Tl* the contact owns a 2005 Honda Pilot. While the vehicle was in park and the key was not near the vehicle, the gear shifted independently. As a result, the vehicle crashed into the neighbor's yard. The contact was in the vehicle cleaning it out at the time of the failure. The contact sustained a concussion to the head and injuries to the neck, back, and left leg that required medical attention. The vehicle was taken to union park Honda (1704 pennsylvania ave, wilmington, de 19806), but the cause of the failure was undetermined. The body damages were repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 144,000.
Brakes all 134 →
The contact owns a 2005 Honda Pilot. The contact stated that shortly after refueling, the vehicle suddenly experienced unintended acceleration, causing the speed to increase to approximately 45 MPH while approaching stopped traffic. While pressing the brake pedal to avoid a collision, the vehicle continued to accelerate and crashed into the rear of a second vehicle. During the air bag deployment, the air was deflated, causing the driver's head to contact the steering wheel. Also, the contact indicated that metal fragments were present during the air bag deployment. The contact sustained a lacerated left wrist and lacerations to the chest area. The driver also sustained contusions and bruised to the head, ankles, and legs, along with neck and back stiffness, which will all require medical treatment. No other injuries were known regarding the second vehicle occupants. …
The contact owns a 2005 Honda Pilot. The contact stated that while driving 25-35 MPH, the vehicle slowed down unexpectedly, and the brake pedal was hard and slow to respond when depressed. The contact stated that the steering wheel was pulling to the left, and it was difficult to correct the steering wheel. The vehicle was difficult to control. The VSA light was illuminated. There was a triangle with an exclamation mark symbol displayed on the instrument cluster. The vehicle was taken to the local dealer, where it was diagnosed and determined that the VSA module had failed and needed to be replaced. The vehicle was not repaired because the parts were on backorder. The manufacturer was not notified of the failure. The approximate failure mileage was 173,273.
Air bags all 120 →
The contact owns a 2005 Honda Pilot. The contact stated that shortly after refueling, the vehicle suddenly experienced unintended acceleration, causing the speed to increase to approximately 45 MPH while approaching stopped traffic. While pressing the brake pedal to avoid a collision, the vehicle continued to accelerate and crashed into the rear of a second vehicle. During the air bag deployment, the air was deflated, causing the driver's head to contact the steering wheel. Also, the contact indicated that metal fragments were present during the air bag deployment. The contact sustained a lacerated left wrist and lacerations to the chest area. The driver also sustained contusions and bruised to the head, ankles, and legs, along with neck and back stiffness, which will all require medical treatment. No other injuries were known regarding the second vehicle occupants. …
The contact owns a 2005 Honda Pilot. The contact stated that after starting the vehicle, the passenger's side airbag light illuminated continuously. The vehicle was taken to an independent mechanic where it was diagnosed that the front passenger's impact sensor needed to be replaced. The dealer was not contacted. The vehicle was repaired. The contact mentioned that a year later the failure recurred. The manufacturer was not notified of the failure. The approximate failure mileage was 100,000.
2005 Honda Pilot engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 3.5L 6-cyl | 5-speed automatic | 4WD/AWD | 15 / 20 / 17 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2005 Honda Pilot a good car?
Based on 679 owner complaints filed with NHTSA, the 2005 Pilot rates avoid: 3.0× as many complaints as a typical year of the Pilot at the same age. It is one of the Pilot years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2005 Honda Pilot?
The transmission & drivetrain — 176 complaints, 26% of all complaints for this model year, most often about automatic transmission. Next are the brakes (134) and air bags (120).
How many recalls does the 2005 Honda Pilot have?
There are 13 recalls for the 2005 Honda Pilot, the most recent from June 27, 2019 (inflator module). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Honda Pilot?
The best years by complaints, compared at the same age, are 2015, 2014 and 2012. Years to avoid or approach with caution: 2016, 2017, 2019, 2025 and 2021. See the full Honda Pilot years comparison.
At what mileage do 2005 Honda Pilot problems happen?
The median mileage reported in complaints is about 102,000 miles; 12% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.