Most common 2005 Ford Escape problems
Share of the 1,394 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Ford Escape complaints by model year
Best Escape years: 2025, 2012, 2023. Years to avoid: 2017, 2020, 2013, 2018, 2014. Compare all years →
2005 Ford Escape recalls (4)
Power train › Automatic transmission › Lever and linkage › Floor shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June…
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge.
Hybrid propulsion system
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014.
Seats › Front assembly › Head restraint
Certain sport utility vehicles equipped without side air curtains or moonroofs fail to comply with the requirements of federal motor vehicle safety standard no. 201, "occupant protection in interior impact." during testing, the free motion head form registered a measurement above the permitted limit at the left hand a-pillar…
Remedy: Dealers will make modifications to the energy absorbing material located above the headliner in the affected area free of charge. The recall began on May 19, 2006. Owners May contact Ford at 1-800-392-3673.
Latches/locks/linkages › Doors › Latch
Certain 2004-2005 sport utility vehicles and certain 2001-2003 sport utiity vehicle having rear liftgate components serviced with 2004 equivalent components fail to comply with the requirements of federal motor vehicle safety standard no.
Remedy: Dealers will replace the rear liftgate latch release rod, the release rod attachment clip and the door handle return spring. The recall began on March 31, 2005. Owners should contact Ford at 1-800-392-3673.
NHTSA defect investigations
Federal safety investigators have looked into 2 possible defects involving the 2005 Ford Escape:
Electronic Throttle Body Malfunction
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles.
Fleet Vehicle Recall Completion Audit
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three…
What 2005 Ford Escape owners say
Suspension all 459 →
Hello, The engine cradle subframe on my 2005 Ford Escape has completely rusted through on the right hand side where it attaches to the steering control arm. As I was driving the subframe broke which made it impossible to steer the car. This pulled my car off the road to the passenger side. Fortunately I was not injured. Having now researched this issue, it is a common problem with 2005 Ford Escapes. This is very dangerous, and it should be addressed as it creates a life threatening situation.
Front left tower rod is going thru the wheel well from rust. This can cause major damage to myself, occupants, and the lives of others outside of the vehicle. The front left seatbelt light continuously alarms as if it is not connected. Is it? The back lights are always out not sure to replacement repeatedly. I'd the seatbelt good enough in an accident, I am not trying to find that it either. The lights are a ticket every time and are another hazard to other motorist. The main wheel rust was told to me upon a failed inspection. It is not fixed at this point just found out and looking for recalls but found many with the same exact hazard. The warning lights go off every minute and a half while driving in the dashboard. This has been since I purchased the vehicle last year. The same goes for replacing the back running light. …
Body & structure all 434 →
The contact owns a 2005 Ford Escape. The contact stated that after her father inspected the vehicle, he made her aware that there was damage to the rear subframe. The vehicle was taken to an independent mechanic, where it was diagnosed that the rear subframe needed to be replaced. The contact became aware of NHTSA Campaign Number: 14V165000 (Structure); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 100,000. The VIN was not available.
Hello, The engine cradle subframe on my 2005 Ford Escape has completely rusted through on the right hand side where it attaches to the steering control arm. As I was driving the subframe broke which made it impossible to steer the car. This pulled my car off the road to the passenger side. Fortunately I was not injured. Having now researched this issue, it is a common problem with 2005 Ford Escapes. This is very dangerous, and it should be addressed as it creates a life threatening situation.
Engine & cooling all 220 →
The contact owns a 2005 Ford Escape. The contact stated while his son was driving 30 MPH, the vehicle turned off inadvertently. There was no warning light illuminated. The contact's son shifted into neutral(N) and veered to the side of the road. The contact's son was able to restart the vehicle after several attempts. The contact's son then drove to his residence. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 90,000.
I was heading back to Louisville Ky from bowling green Ky when my suv started to slow down and started running rough and check engine light flashed then stayed on I pulled off the road called aaa to have the suv towed back to bowling green to where I could have it checked the next day when I went to start it it was knocking and smoking and wouldn't take gas. Talked to a local shop and was informed that my motor was blown after he came and looked at it.
2005 Ford Escape engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.3L 4-cyl hybrid | CVT | FWD | 30 / 28 / 29 |
| 2.3L 4-cyl hybrid | CVT | 4WD/AWD | 28 / 26 / 27 |
| 2.3L 4-cyl | 5-speed manual | FWD | 21 / 27 / 24 |
| 2.3L 4-cyl | 4-speed automatic | FWD | 19 / 23 / 21 |
| 2.3L 4-cyl | 5-speed manual | 4WD/AWD | 19 / 24 / 21 |
| 3.0L 6-cyl | 4-speed automatic | FWD | 17 / 23 / 19 |
| 2.3L 4-cyl | 4-speed automatic | 4WD/AWD | 17 / 20 / 18 |
| 3.0L 6-cyl | 4-speed automatic | 4WD/AWD | 16 / 20 / 17 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2005 Ford Escape a good car?
Based on 1,394 owner complaints filed with NHTSA, the 2005 Escape rates average: about as many complaints as a typical year of the Escape at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2005 Ford Escape?
The suspension — 459 complaints, 33% of all complaints for this model year, most often about rear. Next are the body & structure (434) and engine & cooling (220).
How many recalls does the 2005 Ford Escape have?
There are 4 recalls for the 2005 Ford Escape, the most recent from September 29, 2015 (floor shift). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Ford Escape?
The best years by complaints, compared at the same age, are 2025, 2012 and 2023. Years to avoid or approach with caution: 2017, 2020, 2013, 2018 and 2014. See the full Ford Escape years comparison.
At what mileage do 2005 Ford Escape problems happen?
The median mileage reported in complaints is about 105,000 miles; 13% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.