Which parts fail
Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2019 Ford Ranger owners, lightly cleaned up (personal details are redacted by NHTSA).
I have a 2019 Ford ranger that was built June 24th 2019 the internet states that any Ford ranger 2019 XLT built before July 30th 2019 has a recall for the HVAC system in the blower motor well my truck did not make the recall list but yet it has every single issue that they recall every time I call all they say is my vehicle VIN number is not on the recall but what is the chances that my blower motor and my blend door actuator does not work. When I bought the truck in 2021 I heard a ticking noise but the air still worked me being a female never thought much of it I thought it was my radio or something so this problem has existed since the day I bought it with 20,000 miles on it from the dealership. …
The contact owns a 2019 Ford Ranger. The contact stated while driving approximately 10-15 MPH into the driveway at the residence, the vehicle lost electrical power and the vehicle shutoff as if there was no fuel going to the engine. The contact stated that there also a message that the rearview camera was inoperable, along with messages that features inside the cabin of the vehicle was inoperable. The contact restarted the vehicle and the vehicle shutoff immediately. The contact stated that the engine was not receiving fuel because the fuel pump was on the wiring harness that was not operating as needed. The contact stated that the messages "Cross Traffic Sensor Disconnected", "Rear Parking Sensor Disconnected" and "Rearview Camera Disconnected" were displayed on the instrument panel. …
On Jan 04,2022 while flat towing my truck behind my motorhome it caught fire and burned to the ground. It was too badly burned for the insurance to make a determination of the cause. However, it started in the engine compartment. I know it was not a bad tire because all tires were inflated until the fire popped them. I was able to get the truck disconnected from the RV and know that it remain in Neutral with nothing seized up like the transmission or brakes because the truck rolled on its own once it was disconnected and had to be chocked. I had followed all the proper procedures and my key was in acc position. I had towed this truck many hundred miles prior. That day I had towed it 5-6 hours prior to the fire. This incident took place in Alachua County Florida. …
The contact owns a 2019 Ford Ranger. The contact stated while driving 35 MPH, the air bag warning light illuminated. The contact also stated that the windshield wipers, the defroster, headlights low and high beams failed to work. The contact veered to the side of the road for a short while and then drove the vehicle to the dealer to be diagnosed. The contact was informed that the rodents had damaged the soy-based insulated wiring harnesses at the front of the vehicle. The contact stated that the vehicle was repaired however, the rear lights would fail to turn off. The vehicle was taken to the dealer who diagnosed that the soy-based insulated wiring harnesses at the rear of the vehicle had sustained rodent damage. The manufacturer was made aware of the failure and a case was opened. The vehicle was not repaired. The approximate failure mileage was 31,000.
The contact owns a 2019 Ford Ranger. The contact stated while driving at an undisclosed speed, the air conditioner was activated. The air conditioner made a ticking sound. In addition, the A/C started blowing out hot air. The contact stated that the failure occurred when the temperature was 100 degrees. The contact stated that because of health issues, the air conditioner was required during the heated temperatures. The vehicle was taken to an independent mechanic where it was diagnosed with a failed A/C blower motor. The contact was informed that the A/C blower motor needed to be replaced. The vehicle was not repaired. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000.
The contact owns a 2019 Ford Ranger. The contact stated that while driving approximately 30-40 MPH, there was an abnormal burning odor detected. The contact stated that the front driver's side heated seat had burned a two-inch hole into the seat, the upper back rest, and heating pad. The contact also noticed that the heated seat was inoperable. There were no warning lights illuminated. There were no blown fuses. The vehicle was taken to the dealer however, a service date was not available. The vehicle was not diagnosed or repaired. The contact repaired the seat himself. The manufacturer was notified of the failure and referred him to the local dealer for assistance. The failure mileage was approximately 54,000.
The contact owns a 2019 Ford Ranger. The contact stated that while driving at various speeds, the lights on the instrument panel became inoperable, causing the vehicle to lose power. The contact stated that the messages "Unsafe Driving" and "Head-on Collision" were displayed. The contact waited until the engine cooled down before restarting and driving the vehicle. The contact stated that the vehicle also experienced a failure with A/C unit, and the failures became more persistent. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 42,000.
The contact owns a 2019 Ford Ranger. The contact stated that the transmission was shifting roughly. While approaching a stop, there was an abnormal squealing sound detected from the tires, with the vehicle vibrating. The vehicle was randomly changing lanes while driving. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic who test drove the vehicle and confirmed that the vehicle had abruptly downshifted, and the tires were squealing. The contact called the local dealer, but the vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was approximately 50,000.
The contact owns a 2019 Ford Ranger. The contact stated while driving 50 MPH, the vehicle failed to accelerate properly. There was no warning light illuminated. The contact was able to pull over on the side of the road. The vehicle was taken to the dealer and the contact was informed that the spark plugs were blown out with the coil. The contact was informed that the spark plugs, and coil needed to be replaced. The vehicle was repaired. The manufacturer was contacted and stated that the vehicle was out of warranty. No further assistance was offered. The failure mileage was 17,000.
The contact owns a 2019 Ford Ranger. The contact stated that the temperature failed to adjust as needed. The contact stated that the damper was stuck. The heater was continuously blowing out hot air on the driver's side. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 19V726000 (Visibility). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and opened a case, and referred the contact to the NHTSA Hotline. The failure mileage was approximately 25,152.
Electrical complaints in other Ranger years
Frequently asked questions
How common are electrical problems on the 2019 Ford Ranger?
NHTSA has 41 complaints about the electrical system of the 2019 Ford Ranger, 15% of the model year's 270 complaints. The component named most often is instrument cluster/panel (2 mentions).
Is there a recall for 2019 Ford Ranger electrical problems?
No. NHTSA lists no electrical system recall for the 2019 Ford Ranger, though it has 11 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2019 Ford Ranger electrical problems start?
Half of the complaints with a recorded mileage happened before about 19,000 miles, and 55% before 25,000 miles.
Is it dangerous?
Owners linked 2 crashes, 1 fire and 0 injuries to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.