Most common 2003 Ford Ranger problems
Share of the 243 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Ford Ranger complaints by model year
Best Ranger years: 2023, 2022, 2020. Years to avoid: 2019, 1999, 2000, 1998, 1996. Compare all years →
2003 Ford Ranger recalls (1)
Vehicle speed control
Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 Mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control…
Remedy: Ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the ABS control module connector and repair…
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2003 Ford Ranger:
Brake lights inoperative
This pe was opened based on technical service bulletin (TSB) #05-6-19 issued by Ford motor company and service bulletin #09-008/5 issued by Mazda motor corporation to address concerns of the center high mounted stop light (chmsl) wiring harness chaffing.
What 2003 Ford Ranger owners say
Body & structure all 43 →
The contact owns a 2003 Ford Ranger. The contact stated that while driving at 65 MPH, an abnormal, rattling noise began to emit from the rear of the vehicle without warning. Upon inspection, the contact discovered that the rear cross members had rotted out due to severe corrosion. The contact also stated that the fuel tank was no longer being supported due to the failure. An independent mechanic inspected the vehicle and deemed the vehicle unsafe to drive. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 79,000.
Truck has no spare tire, totally missing the assembly and bracket originally used to hold the tire (have a junk one in the bed). The crossmember under the truck is about 50% intact is getting ready to fall off. Brake lines and rocker panals rotted out as well. Holes in the frame starting and a patch was already needed on the frame (drivers side rear). As well as a loose bed. The truck is very clean on top but underneath is rotting away like it has 200000 miles on it(truck is at 77,000). I want to remove the rust and coat it but im scared of punching through cause spots are brittle.
Speed control & acceleration all 40 →
2003 Ford Ranger suddenly accelerated upon attempting to park. I was pulling into my parking spot while apply the brakes when my vehicle suddenly accelerated, jumped a snow bank and hit a light pole. Independent witness reported the vehicle just took off, rear wheels rapidly started turning. I contacted Ford motor co. Who did not seem too concerned about the incident and had no interest to inspect the vehicle.
I have owned my 2003 Ford Ranger xlt since it was new, and have had all scheduled maintenance. I have had 4 incidents since March 2010 where the vehicle has accelerated when I was braking to stop, with 3 of those incidents within the past week. The first incident caused my truck to push thru a gate, damaging the gate and the front of the vehicle. In this case, the engine did finally drop to an idle. I thought the behavior must be a fluke, so didn't report the incident. The 2nd thru 4th incidents have occurred on a limited access road in omaha (Dodge street) at stop signs and at a gas station outside omaha, and as I was nearing a stop the engine started accelerating and pulling the vehicle forward. Maximum pressure on the brakes allowed me to stay stationary so no vehicles or pedestrians were hit, but caused my rear wheels to burn rubber. I turned off the engine to stop the acceleration. …
Brakes all 35 →
Truck has no spare tire, totally missing the assembly and bracket originally used to hold the tire (have a junk one in the bed). The crossmember under the truck is about 50% intact is getting ready to fall off. Brake lines and rocker panals rotted out as well. Holes in the frame starting and a patch was already needed on the frame (drivers side rear). As well as a loose bed. The truck is very clean on top but underneath is rotting away like it has 200000 miles on it(truck is at 77,000). I want to remove the rust and coat it but im scared of punching through cause spots are brittle.
I own a 2003 Ford Ranger I bought new. On November 26 2010 I pulled into the parking lot @ work and my clutch and brake pedals fell to the floor causing a minor crash. The pivot bracket that holds the steel pedals is made from cast aluminum. I have been a aluminum welder for over 10 years and in my opinion this bracket is very substandard. I searched the web and found that other people had the same thing happen on rangers and other trucks and Ford cars. If I was on the road this could have been much worse. I sent pictures and a piece of the bracket to a recall investigator. He said its not a common failure since he cant find any complaints.
2003 Ford Ranger engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.3L 4-cyl | 5-speed manual | RWD | 21 / 26 / 23 |
| 2.3L 4-cyl | 5-speed automatic | RWD | 20 / 24 / 22 |
| 3.0L 6-cyl | 5-speed manual | RWD | 17 / 21 / 18 |
| 3.0L 6-cyl | 5-speed automatic | RWD | 16 / 20 / 17 |
| 4.0L 6-cyl | 5-speed manual | RWD | 15 / 20 / 17 |
| 3.0L 6-cyl | 5-speed manual | 4WD/AWD | 16 / 19 / 17 |
| 4.0L 6-cyl | 5-speed automatic | RWD | 15 / 19 / 16 |
| 3.0L 6-cyl | 5-speed automatic | 4WD/AWD | 15 / 18 / 16 |
| 4.0L 6-cyl | 5-speed automatic | 4WD/AWD | 14 / 17 / 15 |
| 4.0L 6-cyl | 5-speed manual | 4WD/AWD | 14 / 17 / 15 |
EPA ratings. Class: Full-size pickup.
Frequently asked questions
Is the 2003 Ford Ranger a good car?
Based on 243 owner complaints filed with NHTSA, the 2003 Ranger rates average: 31% fewer complaints than a typical year of the Ranger at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2003 Ford Ranger?
The body & structure — 43 complaints, 18% of all complaints for this model year, most often about body. Next are the speed control & acceleration (40) and brakes (35).
How many recalls does the 2003 Ford Ranger have?
There is 1 recall for the 2003 Ford Ranger, the most recent from October 13, 2009 (vehicle speed control). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Ford Ranger?
The best years by complaints, compared at the same age, are 2023, 2022 and 2020. Years to avoid or approach with caution: 2019, 1999, 2000, 1998 and 1996. See the full Ford Ranger years comparison.
At what mileage do 2003 Ford Ranger problems happen?
The median mileage reported in complaints is about 56,000 miles; 46% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.