Most common 2012 Ford Expedition problems
Share of the 118 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Ford Expedition complaints by model year
Best Expedition years: 2014, 2013, 2012. Years to avoid: 2019, 2020, 2024, 2017, 2018. Compare all years →
2012 Ford Expedition recalls (3)
Power train › Automatic transmission
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford F-150 trucks, 2012 Ford Expedition, Lincoln Navigator, and Ford Mustang vehicles. The affected vehicles are equipped with an automatic transmission that may unexpectedly downshift to first gear, regardless of vehicle speed.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module with updated software, free of charge. The recall began on September 19, 2016.
Exterior lighting › Back up lights
Ford is recalling certain model year 2011-2012 Ford f-150, 2012 expedition and Lincoln navigator, and 2012-2013 mustang vehicles, for failing to comply with the requirements of federal motor vehicle safety standard nos.
Remedy: Ford will notify owners, and dealers will inspect and replace the trs as necessary, free of charge. The safety recall began on June 11, 2012.
Seats › Mid/rear assembly
Ford is recalling certain model year 2012 expedition and Lincoln navigator vehicles, manufactured from November 19, 2011, through December 2, 2011, for failing to comply with the requirements of federal motor vehicle safety standard no.
Remedy: Ford will notify owners, and dealers will replace the head restraints as necessary, free of charge. The safety recall began on February 21, 2012.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2012 Ford Expedition:
Unexpected Transmission Downshift
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles.
What 2012 Ford Expedition owners say
Transmission & drivetrain all 64 →
The contact owns a 2012 Ford Expedition. The contact stated that upon his wife depressing the accelerator pedal, the RPM raised abruptly however, the vehicle failed to respond. The contact stated that the vehicle lost motive power and seemed as if the transmission was in neutral(N). After restarting the vehicle and shifting to drive(D), the vehicle returned to normal functionality. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that a failure had occurred with the transmission molded lead frame. The vehicle was not repaired due to parts not being available. Upon investigation, the contact related the failure to Customer Satisfaction Program: 19N01-Supplement #1 (Power Train) However, the vehicle was out of warranty. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. …
The contact owns a 2012 Ford Expedition. The contact stated that while his wife was driving 30 MPH, the transmission unexpectedly downshifted, causing the occupants to lunge forward. The tires squealed and the wheels locked up. The vehicle was turned off but failed to restart. No warning light was illuminated. The contact stated the failure was associated with NHTSA Campaign Number: 16V248000 (Power Train). A tow truck company was contacted, and was able to restart the vehicle, but the failure persisted. The local dealer was contacted and confirmed that there was no recall coverage associated with the VIN. The vehicle was not diagnosed or repaired. An attempt was made to contact the manufacturer, but there was no response. The failure mileage was approximately 166,000.
Electrical system all 20 →
I was driving regularly down the road when I noticed the smell of electrical fire. Smoke started coming from the undercarriage of the truck. I pulled into a gas station, and the engine died, and I got out to look at what's causing the smoke. I observed what looked to be engine or transmission oil on fire dripping from the undercarriage, so I moved a safe distance from the vehicle, and within about 30 seconds, the entire vehicle was engulfed in flames. The fire department came, and extinguished the fire. The vehicle is 100% casualty, along with everything inside of it.
I just purchased (2 months ago) a 2012 Ford Expedition EL 5.4l v8 from a private party. I wish I would have done more research as I am ALREADY EXPERIENCING TRANSMISSION ISSUES THAT I BELIEVE ARE DIRECTLY RELATED TO THE VEHICLES LEAD FRAME RECALL. IT THREW A P0742 CODE ON ME Torque Converter Clutch Circuit stuck on and decided that it would only drive in limp mode unless I cleared the code, pulled over, cycles the key, and restarted the vehicle. Even as dangerous as this UNEXPECTED SHIFTING INTO 1ST GEAR AT HIGHWAY SPEEDS IS, IT IS EQUALLY AS DANGEROUS TO BE GETTING OUT OF YOUR VEHICLE IN MOVING TRAFFIC DUE TO FORD'S TERRIBLE DESIGN ON THIS VEHICLES POWER TRAIN/TRANSMISSION SYSTEM. I HAVE SCHEDULED AN APPOINTMENT WITH THE LOCAL Ford DEALER AND AL CERTAIN I'LL GET THE RUNAROUND/BLAME GAME FOR THIS ONE. …
Speed control & acceleration
The transmission jumps in and out of gear, the engine revs on its on. I was on the highway the first time and I going between 60 and 65 mph and it sounded like the whole bottom of the truck was just ripped out, the truck went from drive to either park or first gear it locked up the back tires and there was a truck behind me he tried to miss me but he hit the back passenger side of the truck. He was very very upset he threatening and cussing me because he thought I just slammed on my brakes for no reason. I explained to him what was happening and calmed down think God. It could have killed him or me or even several other people. When it locked up the tires then it jumped back in drive and tried tot take off, I threw it in neutral and cut the key off. That scared the sh.. out of me!! …
I just purchased (2 months ago) a 2012 Ford Expedition EL 5.4l v8 from a private party. I wish I would have done more research as I am ALREADY EXPERIENCING TRANSMISSION ISSUES THAT I BELIEVE ARE DIRECTLY RELATED TO THE VEHICLES LEAD FRAME RECALL. IT THREW A P0742 CODE ON ME Torque Converter Clutch Circuit stuck on and decided that it would only drive in limp mode unless I cleared the code, pulled over, cycles the key, and restarted the vehicle. Even as dangerous as this UNEXPECTED SHIFTING INTO 1ST GEAR AT HIGHWAY SPEEDS IS, IT IS EQUALLY AS DANGEROUS TO BE GETTING OUT OF YOUR VEHICLE IN MOVING TRAFFIC DUE TO FORD'S TERRIBLE DESIGN ON THIS VEHICLES POWER TRAIN/TRANSMISSION SYSTEM. I HAVE SCHEDULED AN APPOINTMENT WITH THE LOCAL Ford DEALER AND AL CERTAIN I'LL GET THE RUNAROUND/BLAME GAME FOR THIS ONE. …
2012 Ford Expedition engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 5.4L 8-cyl | 6-speed automatic | RWD | 14 / 20 / 16 |
| 5.4L 8-cyl | 6-speed automatic | 4WD | 13 / 18 / 15 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2012 Ford Expedition a good car?
Based on 118 owner complaints filed with NHTSA, the 2012 Expedition rates better than average: 59% fewer complaints than a typical year of the Expedition at the same age. It is one of the best Expedition years by this measure. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2012 Ford Expedition?
The transmission & drivetrain — 64 complaints, 54% of all complaints for this model year, most often about automatic transmission. Next are the electrical system (20) and speed control & acceleration (18).
How many recalls does the 2012 Ford Expedition have?
There are 3 recalls for the 2012 Ford Expedition, the most recent from April 27, 2016 (automatic transmission). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Ford Expedition?
The best years by complaints, compared at the same age, are 2014, 2013 and 2012. Years to avoid or approach with caution: 2019, 2020, 2024, 2017 and 2018. See the full Ford Expedition years comparison.
At what mileage do 2012 Ford Expedition problems happen?
The median mileage reported in complaints is about 82,000 miles; 24% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.