2022 Ford Bronco Engine Problems

Mileage when the problem started

• Under 25k
  538%
• 25k–50k
  323%
• 50k–75k
  215%
• 75k–100k
  215%
• 100k–150k
  18%
• 150k+
  00%

Owner reports

Selected complaints filed with NHTSA by 2022 Ford Bronco owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 26V468000 (Engine, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while his wife was driving 70 MPH uphill, the vehicle lost drive power. Several unknown warning lights were illuminated. The driver was able to pull over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed and determined that the main wiring harness had dislodged, sat across the exhaust, and was burned. The dealer determined that the main wiring harness needed to be replaced, which required the temporary removal of several components. The contact was provided a repair estimate and was advised that the failure was not covered under the recall and that the vehicle was out of warranty. The vehicle was not repaired. …

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that upon starting the vehicle, the vehicle sputtered and nearly stalled. The contact turned off and restarted the vehicle; however, the failure persisted. Additionally, the fuel gauge was constantly inaccurate while starting the vehicle and while driving. The contact stated that the fuel gauge read 0 miles or 0 percent while there was fuel in the tank. The check engine warning light was illuminated. The dealer was contacted to schedule an appointment; however, the dealer informed the contact that the part for the recall repair was not yet available. The vehicle was not diagnosed or repaired. The contact stopped driving the vehicle due to safety concerns. …

my vehicle lost power on the GW bridge in NYC. It has less than 1000 miles and the power, driving at 60 mph just died. To add insult to injury Ford (24hr roadside assistance told me that there were no tow truck available at this time). When my car was finally towed, vis a vie a 3rd party, to the nearest dealership, I was told that because I didnt buy my car there, there was nothing I could do but wait a "few weeks". Ford 24 hr road side assistance really left me out to dry. I wish and am looking for ways to sue them. Luckily, my responsible dealer at Lester Glenn Ford on Rt 35 was able to assist and is making every accommodation to help. Thank goodness for them and their restless souls for helping with this. I literally have less than 1000 miles on the Badlands 2.7 V6, and when this happened, I didnt know what to do. Disappointing. But Lester Glenn is so far amazing at the response.

The contact owns a 2022 Ford Bronco. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that the spark plugs had failed to remain connected. The spark plugs were reconnected. The next day the check engine warning light illuminated. The vehicle was returned to the dealer where it was diagnosed with the same failure. The spark plugs were replaced. The failure reoccurred and the engine sounded as if the engine was sputtering while starting the vehicle for several minutes. The vehicle was returned to the dealer where it was diagnosed as spark plug failure and that the engine was misfiring. There were no DTC codes retrieved. The vehicle was not repaired. The manufacturer had not been made aware of the failure. The failure mileage was approximately 35,000.

The contact owns a 2022 Ford Bronco. The contact stated that while her husband was driving 65 MPH, the vehicle unintendedly decelerated and jerked abnormally. The driver pulled over to the shoulder of the road and inspected the vehicle. The driver then drove to the dealer, where the vehicle was diagnosed as having a contained fire inside the exhaust pipe. The vehicle remained at the dealer for further diagnostic tests with the assistance of the engineers. The dealer informed the contact that the manufacturer had denied the contact vehicle rental assistance. The vehicle was not yet repaired. The contact stated that with the three recalls, it was unsafe to continue driving the vehicle. The manufacturer was notified of the failure. The failure mileage was approximately 80,000.

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle was driving roughly, and it stalled several times. The vehicle was taken to the local dealer, and the low-pressure fuel pump was replaced, but the failure persisted. The manufacturer was made aware of the issue. The failure mileage was 5,000.

The contact owns a 2022 Ford Bronco. The contact stated that while leaving the residence, the vehicle stalled on the highway. The driver was able to avoid a crash with a tractor-trailer. The check engine warning light illuminated intermittently, and a "Service Vehicle Soon" message was displayed. Additionally, there was a tool symbol displayed on the instrument panel. The vehicle was towed to a local dealer, and the contact was informed that the part needed to perform the recall repair of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); was not yet available. The manufacturer was not contacted. The failure mileage was approximately 75,000.

We were returning home from a trip. We pulled into a gas station to get gas. As we pulled up to the gas pump, we smelled smoke and then saw smoke and fire. We immediately turned the Bronco off and jumped out. Shortly after, the whole engine compartment area was on fire. Luckily, there was a tow truck in the parking lot and was able to drag it away from the gas pumps. I had gotten an oil change prior to our trip. There were no warning signals, lights, or indication of temperature or oil problems. I had intermittently smelled gas while driving during our trip, but my wife said she did not smell gas on the passenger side.

The contact owns a 2022 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle made abnormally loud knocking sounds. The vehicle was towed to the dealer where it was diagnosed with metal shavings in the engine oil and filter. The dealer performed an oil change and informed the contact that the two transmission pumps and the engine needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 60.

The contact owns a 2022 Ford Bronco. The contact stated while starting the vehicle he heard a rattling nosing coming from the vehicle. There was no warning light illuminated. The contact stated that after the vehicle warmed up, the sound went away. The vehicle was taken to the dealer and the mechanic confirmed the abnormal sound coming from the vehicle, but no failure was found. The manufacturer was contacted and advised the contact to reach out to the NHTSA Hotline and file a complaint. The failure mileage was 12.

Related recalls

NHTSA investigations

Engine complaints in other Bronco years