Which parts fail
Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2022 Ford Bronco owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 26V468000 (Engine, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while his wife was driving 70 MPH uphill, the vehicle lost drive power. Several unknown warning lights were illuminated. The driver was able to pull over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed and determined that the main wiring harness had dislodged, sat across the exhaust, and was burned. The dealer determined that the main wiring harness needed to be replaced, which required the temporary removal of several components. The contact was provided a repair estimate and was advised that the failure was not covered under the recall and that the vehicle was out of warranty. The vehicle was not repaired. …
The contact owns a 2022 Ford Bronco. The contact stated that while driving at undisclosed speeds, the "Powertrain Malfunction - Reduced Power Fault" message was displayed and flickered on and off. The contact that the battery was losing the charge. The contact stated that the battery was at 70% charge. The contact related the failure to NHTSA Campaign Number: 24V683000 (Power Train, Electrical System). The vehicle was taken to the local dealer, where it was diagnosed and determined that the battery needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 36,000.
The contact owns a 2022 Ford Bronco. The contact stated that while shifted into reverse(R), and occasionally while driving on several occasions at various speeds, the cross-traffic alert icon illuminated, and the message "Cross Traffic Alert Function Not Available" was displayed. The vehicle was not diagnosed or repaired. The contact believed that the failures were associated with an unknown recall. The manufacturer was notified of the failure. The failure mileage was approximately 34,000.
The contact owns a 2023 Ford Bronco. The contact stated while attempting to start the vehicle, there were several unknown warning lights illuminated. The contact exited the vehicle, raised the hood of the vehicle and became aware that rodents had chewed through the electrical wiring. The vehicle was not taken to the dealer or an independent mechanic to be inspected. The vehicle was not repaired. The manufacturer was notified not of the failure. The approximate failure mileage was 13,000.
Not exactly sure how it started to happen. Meaning there was a powertrain malfunction so my Ford computer tells me, which caused the vehicle to not restart and in addition to it not restarting, the vehicle also didn't have brakes, so it simply rolled backwards without any control until I hit a tree to stop me. On the way down, I also hit the bumper and damaged it and also hit the driver's side mirror on a rock on the way down.
On 03/31/25 at approx. 12:45 AM our 2022 Ford Wild Trak was engulfed in fire while parked on our driveway. There were no occupants, and it had last been operated on 3/30/25 at approximately 1030 PM. During its last operation there was nothing abnormal to indicate the potential of a engine fire (no warning lights, messages, unusual smell or odors, performance issues, smoke, or fire). Upon observing the Ford Bronco Wild Trak for the first time the engine compartment was fully engulfed, and it was clear the fire had started in the engine compartment. The flames from the Ford Bronco Wild Trak eventually spread to a second vehicle destroying it down to the frame and causing enough damage to a third vehicle rendering it a total loss. All three vehicles were within 4 feet of our residence and the flames were hot enough it melted the garage door window frames. …
What component or system failed or malfunctioned, and is it available for inspection upon request? - Display for backup camera freezes after putting vehicle in reverse. Yes, it is available for inspection. How was your safety or the safety of others put at risk? - The display freezes when putting the vehicle in revers and the initial image on display of what was behind the vehicle stays the same while moving. If something or someone moves behind the vehicle while moving the image does not update to show that something or someone is now behind the vehicle. Previously recall 23S48 was completed related to the issue but it did not resolve the issue. Vehicle was taken back to the dealer and the dealer informed me that it is a faulty APIM and not the backup camera and is therefore not covered by the recall. …
Safety Defect - Inadequate Warning and Insufficient Time to Respond to Alternator/Charging System Failure I am submitting this safety complaint regarding a dangerous condition in my 2022 Ford Bronco involving the charging system and alternator protection behavior. While driving, a warning related to the charging system/battery appeared. The message lacked sufficient clarity and urgency. The time from the warning until the 12-volt battery was fully depleted was extremely short-too brief to safely identify a location and pull completely out of traffic. Once the battery died: The vehicle could not be placed in neutral, preventing it from being moved out of the travel lane. There was insufficient power to operate the hazard lights. This occurred on a busy highway, leaving the vehicle disabled in traffic and creating a significant safety risk. I was fortunate it happened in daylight. …
Bronco base had no option for tow package but for $195 option 66C is a factory install auxiliary switches. Switch 1 is wired to 30 amps or 360 watts @12 v. This option has 2 parts. The second parts are not attached. Ford states the installer is liable, even though the factory supplies low wattage 16amp (1.5mm2) wires in various parts of the Bronco. When fasten to switch one at 360 watts (30 amps) the low wattage 16 AGW will heat and can cause a fire in the vehicle. The smell of the low wattage burning can be detected. Ford uses an old accessory wiring harness with a power module to supply wattage to a trailer for lights and braking. It was reported that when the trailer brake control module not installed by factory since option on certain model Broncos, the emergency braking module would be activate correctly and the sway controls had to disabled. …
The 2022 Bronco is listed as being able to be flat towed behind a motorhome and the software allows it to be put into flat tow mode. 49 states require that flat towed vehicles over a certain weight have supplemental braking. When the supplemental brake system is installed in a Bronco with the 2.7 liter engine it stops working correctly after 45 minutes because the electronic brake booster shuts off. This results in the supplemental braking system not having enough power to activate the brakes and can cause a serious accident because the motorhome cannot stop soon enough. Ford issued TSB 22-2210 to temporarily correct this issue but it simply disables the electronic brake booster (must remove fuses) and again leaves the towed vehicle with insufficient braking. Ford claims they are working a software update due out in September 2022, it is now mid October and no recall has been issued.
Electrical complaints in other Bronco years
Frequently asked questions
How common are electrical problems on the 2022 Ford Bronco?
NHTSA has 39 complaints about the electrical system of the 2022 Ford Bronco, 10% of the model year's 383 complaints. The component named most often is adas (1 mentions).
Is there a recall for 2022 Ford Bronco electrical problems?
No. NHTSA lists no electrical system recall for the 2022 Ford Bronco, though it has 23 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2022 Ford Bronco electrical problems start?
Half of the complaints with a recorded mileage happened before about 36,000 miles, and 25% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 1 fire and 0 injuries to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.