Most common 2024 Ford Bronco Sport problems
Share of the 112 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Ford Bronco Sport complaints by model year
Best Bronco Sport years: 2025, 2023, 2024. Compare all years →
2024 Ford Bronco Sport recalls (8)
Suspension › Front › Control arm › Lower ball joint
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.
Remedy: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect and repair the front lower control arm ball joints as necessary, free of charge.Owner notification letters were mailed…
Equipment › Electrical › Engine block heater
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge.
Fuel system, gasoline › Fuel injection system
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Remedy: Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge.
Back over prevention › Software
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and…
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332.
Power train › Automatic transmission › Control module (TCM/PCM/tecm)
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332.
Electrical system › Body control module/BCM
Ford Motor Company (Ford) is recalling certain 2024 Bronco Sport vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Remedy: Dealers will update the body control module and powertrain control module software, free of charge. Owner notification letters were mailed October 23, 2024. Owners may contact Ford customer service at 1-866-436-7332.
Show 2 more recalls
Visibility › Windshield wiper/washer › Motor
Ford Motor Company (Ford) is recalling certain 2023-2024 Maverick, Ford Bronco Sport, and Mustang Mach-E vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.
Remedy: Dealers will inspect and replace the windshield wiper motor as necessary, free of charge. Owner notification letters were mailed on December 6, 2024. Owners may contact Ford customer service at 1-866-436-7332.
Electrical system › Body control module/BCM
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2024 Ford Bronco Sport:
Loss of Motive Power
On January 31, 2024, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24002) to investigate loss of motive power allegations in model year (MY) 2021 Ford Bronco Sport vehicles. Consumers reported a loss of engine power accompanied by complete electrical system failure either while driving or after stopping at a traffic light or stop sign.
What 2024 Ford Bronco Sport owners say
Fuel & propulsion system all 35 →
The contact owns a 2024 Ford Bronco Sport. The contact stated that while starting the vehicle, there was a ticking sound coming from the engine compartment. There was no warning light illuminated. Additionally, while driving at an undisclosed speed, the contact smelled a fuel odor. The Mobile App indicated that the VIN was associated with NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, parts were not yet available for the recall repair. The vehicle was taken to a dealer, and a software update was performed related to the recall, but the dealer confirmed that parts were still not yet available. The dealer also informed the contact that metal shavings were found in the engine and that the engine needed to be replaced. The contact was also informed that the muffler had failed and needed to be replaced. The engine and muffler were repaired. …
Our 2024 Bronco Sport Outer Banks, 1.5 liter engine, purchased new from a Ford dealer 11/2024, serviced at the dealership and driven less than 14k miles, was destroyed by a spontaneous fire 3/22/2026. After driving 12 miles, we parked in a parking lot. Upon exiting the car we noticed a burning smell and saw small plumes of steam or smoke coming from under the car hood. Within a minute a red/orange disc of heated metal became visible on the hood surface as flames came from under the hood. Seven minutes later the fire department arrived extinguishing the fire. The car was destroyed. There were no warnings of any kind. The events suggest a cracked fuel injector. Even though 15 foot flames engulfed the car it was parked and unoccupied, there were no injuries. The results of the investigation have not been reported to us. CCTV footage was obtained from the police.
Electrical system all 27 →
The contact owned a 2024 Ford Bronco Sport. The contact stated that while driving into the driveway and coming to a complete stop, the contact became aware of steam coming from underneath the hood and believed that the engine was overheating. No warning light was illuminated on the instrument panel prior to the vehicle catching on fire. The contact and his wife were inside the vehicle were in the vehicle during the failure. The driver and the passenger exited the vehicle safely. There was grey and white odorless smoke coming from the vehicle. The contact stated that the fire originated in the engine compartment. There was significant concrete damage to the driveway and a tree by the residence. The fire was extinguished by the local Fire Department. A fire report was filed but was unavailable. No police report was filed. The vehicle was destroyed. No injuries were sustained. …
The contact owns a 2024 Ford Bronco Sport. The contact stated that the engine knock sensor and the oil pressure sensor failure warning lights were illuminated; however, the vehicle had not displayed any failures. The vehicle was taken to the dealer who diagnosed the vehicle and determined that the wires underneath the vehicle were defective due to bite marks. The contact stated that after the wires were repaired, the contact attempted to start the vehicle, but the vehicle failed to start. The vehicle was towed back to the dealer who determined that there were bite marks on the wires again. The contact was informed that the insulation on the wires were soy-based, and squirrels were chewing on the insulation. The wires were replaced again. The manufacturer was not informed of the failure. The failure mileage was approximately 6,031.
Engine & cooling all 26 →
The contact owns a 2024 Ford Bronco Sport. The contact stated that while starting the vehicle, there was a ticking sound coming from the engine compartment. There was no warning light illuminated. Additionally, while driving at an undisclosed speed, the contact smelled a fuel odor. The Mobile App indicated that the VIN was associated with NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, parts were not yet available for the recall repair. The vehicle was taken to a dealer, and a software update was performed related to the recall, but the dealer confirmed that parts were still not yet available. The dealer also informed the contact that metal shavings were found in the engine and that the engine needed to be replaced. The contact was also informed that the muffler had failed and needed to be replaced. The engine and muffler were repaired. …
On [redacted], my 2024 Ford Bronco Sport spontaneously burst into flames while driven by my [redacted] son. Per a local bystander, there was smoke and fire observed around the undercarriage as he drove down the road. Multiple vehicles began honking while stopped at a red light. A driver alerted my son of the fire. He was able to evacuate along with his [redacted] sister. As they were fleeing to the median of an active highway, the vehicle burst into flames. After several explosions the vehicle continued to burn and melt until the fire dept extinguished the flames. Prior to spontaneous combustion, there were no symptoms of gas leaks or error messages. Nor were there any fluid leaks. There were no error messages or signs of vehicle distress even while my children were driving & engulfed in flames. …
2024 Ford Bronco Sport engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 1.5L 3-cyl turbo | 8-speed automatic | AWD | 25 / 29 / 26 |
| 2.0L 4-cyl turbo | 8-speed automatic | 4WD | 21 / 26 / 23 |
EPA ratings. Class: Small SUV.
Frequently asked questions
Is the 2024 Ford Bronco Sport a good car?
Based on 112 owner complaints filed with NHTSA, the 2024 Bronco Sport rates average: 30% fewer complaints than a typical year of the Bronco Sport at the same age. It is one of the best Bronco Sport years by this measure. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2024 Ford Bronco Sport?
The fuel & propulsion system — 35 complaints, 31% of all complaints for this model year. Next are the electrical system (27) and engine & cooling (26).
How many recalls does the 2024 Ford Bronco Sport have?
There are 8 recalls for the 2024 Ford Bronco Sport, the most recent from May 27, 2026 (lower ball joint). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Ford Bronco Sport?
The best years by complaints, compared at the same age, are 2025, 2023 and 2024. See the full Ford Bronco Sport years comparison.
At what mileage do 2024 Ford Bronco Sport problems happen?
The median mileage reported in complaints is about 15,000 miles; 88% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.