2024 Ford Bronco Sport Electrical Problems

Mileage when the problem started

• Under 25k
  3100%
• 25k–50k
  00%
• 50k–75k
  00%
• 75k–100k
  00%
• 100k–150k
  00%
• 150k+
  00%

Owner reports

Selected complaints filed with NHTSA by 2024 Ford Bronco Sport owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owned a 2024 Ford Bronco Sport. The contact stated that while driving into the driveway and coming to a complete stop, the contact became aware of steam coming from underneath the hood and believed that the engine was overheating. No warning light was illuminated on the instrument panel prior to the vehicle catching on fire. The contact and his wife were inside the vehicle were in the vehicle during the failure. The driver and the passenger exited the vehicle safely. There was grey and white odorless smoke coming from the vehicle. The contact stated that the fire originated in the engine compartment. There was significant concrete damage to the driveway and a tree by the residence. The fire was extinguished by the local Fire Department. A fire report was filed but was unavailable. No police report was filed. The vehicle was destroyed. No injuries were sustained. …

The contact owns a 2024 Ford Bronco Sport. The contact stated that the engine knock sensor and the oil pressure sensor failure warning lights were illuminated; however, the vehicle had not displayed any failures. The vehicle was taken to the dealer who diagnosed the vehicle and determined that the wires underneath the vehicle were defective due to bite marks. The contact stated that after the wires were repaired, the contact attempted to start the vehicle, but the vehicle failed to start. The vehicle was towed back to the dealer who determined that there were bite marks on the wires again. The contact was informed that the insulation on the wires were soy-based, and squirrels were chewing on the insulation. The wires were replaced again. The manufacturer was not informed of the failure. The failure mileage was approximately 6,031.

Driving on [redacted] . I smelled gasoline. My entire car smelled of it. Next I got a notification to service my vehicle soon. I immediately pulled over and called two Ford dealerships. Downers Grove and Naperville. Neither helped. I located I was close to a dealership. I went there. This is where I learned that underneath my car, wires had caught fire.

My backup camera one two separate occasions has not operated properly. First time it never showed a vehicle had come up behind me. Didn't go off with any notice. I backed into a car. Second time a man with a cart walk behind as I was backing out no notice. There is a recall on review camera but not on my vin.

On [redacted], my 2024 Ford Bronco Sport spontaneously burst into flames while driven by my [redacted] son. Per a local bystander, there was smoke and fire observed around the undercarriage as he drove down the road. Multiple vehicles began honking while stopped at a red light. A driver alerted my son of the fire. He was able to evacuate along with his [redacted] sister. As they were fleeing to the median of an active highway, the vehicle burst into flames. After several explosions the vehicle continued to burn and melt until the fire dept extinguished the flames. Prior to spontaneous combustion, there were no symptoms of gas leaks or error messages. Nor were there any fluid leaks. There were no error messages or signs of vehicle distress even while my children were driving & engulfed in flames. …

The contact owns a 2024 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the vehicle vibrated, and the contact stated that there was an abnormal white noise coming from the rear of the vehicle. No warning lights were illuminated. The contact stated that on another occasion, while driving 60 MPH, there was smoke coming from under the hood. The contact pulled over to the side of the road and shifted in park(P). The contact opened the hood and noticed that the engine had overheated. No warning lights were illuminated. The contact waited for the engine temperature to lower. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that the failure persisted. On another occasion, while driving 65 MPH in the rain, the steering wheel pulled to the right. …

My car was parked in my driveway and I parked it up by the driveway door when I came out the next day my car was at the end of the driveway nobody broke in it it was still locked but that was strange then it seemed like every time I'm driving this car it doesn't want to give me power to drive the car I just took it out of town and red lights start popping on inside the dashboard stating something about transmission fluid cooling something I have been to the dealership quite a few times in reference to the car not getting enough power They keep saying nothing wrong with this car but it's something is wrong with this car I've had this car 2 years I've only put $21,000 mi on it each time I put those kind of miles put miles on the car I was driving out of town and each time was scary because the car act like it don't want to go I just came back from Tulsa Oklahoma on the way back home the …

My 2024 Ford Bronco Sport has had an open unrepaired safety recall (Ford 25S76 / NHTSA 25V467) for about 10 months. The recall states that a fuel injector may crack and create an under-hood fire risk. There is still no repair remedy available. Ford and the dealership have stated that they are trying to develop a solution until June 2026. This effectively means I am being told to continue driving a vehicle with a known fire risk for an unknown extended period of time. For the past 10 months, I have been driving this vehicle in fear. I use it every day to take my children to school, transport my family, and handle family responsibilities. I cannot afford to purchase another vehicle because I invested most of my money into this one. The dealership has not provided me with a clear solution or completed any repair related to this recall. …

I purchased a new 2024 Ford Bronco Sport on [redacted] from Sayville Ford in [redacted]. They failed to disclose an unremedied safety recall (24V-267) on the vehicle that was issued on [redacted] and still sold me the vehicle. When I went back to them after seeing that there was a recall on the car, they denied the existence of the recall despite me showing them the recall notice on both the NHTSA and Ford websites. Last year there was another safety recall for leaking fuel injectors (25V-467) that I brought my car in for service, and they claimed to have done a software fix. Upon checking the recall checked on the NHTSA website (6 months after service) it lists that the safety recall work was never performed, despite the dealership keeping my car for the entire day and telling me the work was performed. …

January 10, 2026. My battery abruptly stalled. It was charged drove a few feet in the car just stopped. The car was towed, and the battery was deemed faulty and needed replacement. May 10. The engine coolant light came on. The car would turn on and then abruptly stalled. Mid traffic. The car again was towed and it was deemed had a faulty coolant pump. I asked for the fuel injection system to be looked at and they said my card does not have a Vin recall. These two prior issues established the fact that something is wrong with my vehicle and should have been included in the main Ford recall. I would like my VIN number added for the safety of my car and to be able to get the updates necessary for the fuel injection cracks that occur in this year bronco. The dealership is refusing to do this.

Related recalls

NHTSA investigations

Electrical complaints in other Bronco Sport years