Most common 2023 Chevrolet Suburban problems
Share of the 131 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Chevrolet Suburban complaints by model year
Best Suburban years: 2014, 2009, 2020. Years to avoid: 2015, 2021, 2023, 2022, 2024. Compare all years →
2023 Chevrolet Suburban recalls (3)
Engine and engine cooling › Engine › Hard parts internal/mechanical
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the…
Suspension › Rear
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023.
Exterior lighting › Lighting control module › Software
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023.
NHTSA defect investigations
Federal safety investigators have looked into 4 possible defects involving the 2023 Chevrolet Suburban:
Loss of motive power due to engine failure post recall remedy
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement.
Loss of motive power due to engine failure
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM's full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine.
Loss of motive power due to engine failure post recall remedy
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement.
Loss of motive power due to engine failure
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274.
What 2023 Chevrolet Suburban owners say
Engine & cooling all 77 →
The contact owns a 2023 Chevrolet Suburban. The contact stated that the vehicle had experienced excessive oil consumption. The contact stated that while driving at various speeds, the vehicle chugged, jerked, and lunged forward. The vehicle was taken to the dealer; however, the failure could not be duplicated. The contact stated that the failure reoccurred. The vehicle was taken back to the dealer, where the spark plugs were replaced; however, the failure persisted. The dealer was notified of the failure and advised the contact that the spark plugs might need to be replaced. The contact stated that while driving and coming to a stop, the vehicle chugged, lunged forward, made an abnormal clicking sound, and almost struck another vehicle. The check engine warning light illuminated. …
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving approximately 65 MPH, the transmission erroneously shifted to neutral(N), and the vehicle decelerated unexpectedly. The vehicle was pulled off the freeway and parked on the shoulder of the road, and the police were contacted and arrived at the scene and assisted with removing the small children from the vehicle. The vehicle was later towed to a nearby towing lot. The contact later received messages on the App for transmission and engine failures. The cause of the failures was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The contact stated that the vehicle was previously serviced under the NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); even though the vehicle had experienced the failure listed in the recall. …
Transmission & drivetrain
The contact owns a 2023 Chevrolet Suburban. While the contact's husband was driving 70-75 MPH and depressing the accelerator pedal, the vehicle failed to respond, but the RPMs became elevated. The driver shifted transmission into neutral(N), coasted to the side of the road, and the vehicle stalled. A message to "Start Vehicle" was displayed; however, while on the side of the road, the vehicle failed to turn off. The driver was able to shift into park(P) and had the vehicle towed to the dealer, where the transmission failed to shift out of park(P). The dealer determined that a spark plug was burned. The spark plug was replaced; however, before returning the vehicle, the new spark plug was also burned. The dealer then diagnosed the vehicle with engine failur. The dealer informed the manufacturer of the safety issue. The failure mileage was approximately 42,600.
The contact owns a 2023 Chevrolet Suburban. The contact stated that while entering a parking lot at a low speed, the engine shut off without warning. The vehicle was towed to a dealer, where it was diagnosed with engine failure, which was associated with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The vehicle remained at the dealer for approximately three months before the engine was repaired. The contact stated that while driving recently, the vehicle hesitated upon depressing the accelerator pedal. No warning light illuminated. The dealer and the manufacturer were not notified of the recent failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 50,000.
Electrical system
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the vehicle lost electrical power, failing to display any information on the instrument panel; however, the vehicle still had motive power. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that the instrument panel control module needed to be reset. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 2,000.
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop immediately. The vehicle was taken to the dealer and was repaired. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed again; however, the vehicle accelerated and failed to stop. The contact also stated that the radio display screen failed to function. The manufacturer was made aware of the failure. The failure mileage was approximately 3,000.
2023 Chevrolet Suburban engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 3.0L 6-cyl turbo diesel | 10-speed automatic | RWD | 21 / 27 / 23 |
| 3.0L 6-cyl turbo diesel | 10-speed automatic | 4WD | 20 / 26 / 22 |
| 5.3L 8-cyl | 10-speed automatic | RWD | 15 / 20 / 17 |
| 6.2L 8-cyl | 10-speed automatic | RWD | 14 / 20 / 16 |
| 6.2L 8-cyl | 10-speed automatic | 4WD | 14 / 18 / 16 |
| 5.3L 8-cyl | 10-speed automatic | 4WD | 15 / 19 / 16 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2023 Chevrolet Suburban a good car?
Based on 131 owner complaints filed with NHTSA, the 2023 Suburban rates avoid: 2.2× as many complaints as a typical year of the Suburban at the same age. It is one of the Suburban years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2023 Chevrolet Suburban?
The engine & cooling — 77 complaints, 59% of all complaints for this model year. Next are the transmission & drivetrain (19) and electrical system (14).
How many recalls does the 2023 Chevrolet Suburban have?
There are 3 recalls for the 2023 Chevrolet Suburban, the most recent from April 24, 2025 (hard parts internal/mechanical). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Chevrolet Suburban?
The best years by complaints, compared at the same age, are 2014, 2009 and 2020. Years to avoid or approach with caution: 2015, 2021, 2023, 2022 and 2024. See the full Chevrolet Suburban years comparison.
At what mileage do 2023 Chevrolet Suburban problems happen?
The median mileage reported in complaints is about 50,000 miles; 50% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.