Most common 2021 Chevrolet Silverado 3500 problems
Share of the 41 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Chevrolet Silverado 3500 complaints by model year
Best Silverado 3500 years: 2014, 2017, 2012. Years to avoid: 2024, 2025, 2021, 2020, 2022. Compare all years →
2021 Chevrolet Silverado 3500 recalls (5)
Power train › Automatic transmission › Fluid/lubricant › Valves/valve body
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a…
Latches/locks/linkages › Tailgate › Latch
General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle…
Remedy: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024.
Service brakes, hydraulic › Power assist › Electric › Control module
General Motors, LLC (GM) is recalling certain 2021-2022 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 vehicles with electronic brake control modules (EBCM) replaced during vehicle assembly.
Remedy: Owners are advised to park outside and away from other structures until the recall repair is completed. Dealers will replace the BPMV assembly, free of charge. Owner notification letters were mailed on October 20, 2021.
Seat belts › Critical fasteners
General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado, Equinox, Silverado 1500, 2500 and 3500, Suburban and Tahoe vehicles.
Remedy: GM will notify owners, and dealers will replace the suspect bolts, free of charge. The recall began January 29, 2021. Owners may contact GMC customer service at 1-800-462-8785, Cadillac customer service at…
Seat belts › Critical fasteners
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2021 Chevrolet Silverado 3500:
Air Bag Malfunction
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM).
What 2021 Chevrolet Silverado 3500 owners say
Electrical system
Driving home from work 7/1/2024 approx 5:15PM Smelled burning smell, no noise or dash lights, thought it was another car. 1 minute later, heard a thump from under hood and "Charging System Failure" came on dash. Decided to take to Chevy dealer, which was 5 minutes away. Within next 2 minutes steering failed. As I came to next intersection, brakes failed, went thorough red light, luckily not hit by another vehicle. Coasted to stop and called tow service.Engine was still running until I turned it off. Had towed to local Chevy dealer. AC compressor had locked up, broken belt. Steering and brakes failed. Dealer agreed both failed, but would not list the brake failure on the invoice. I was originally invoiced 2900.00 to repair, even though truck had only 29244 miles. That was reduced to 1160.00. Was told it was 2 months past 36 month warranty. …
Water entered tailgate through drainage hole in tailgate cap. The water then dripped on the tailgate switch causing it to short out. This short circuit caused my tailgate to open and close randomly without pressing any switches or buttons or key fobs. May tailgate has a small ding it it now from where it kept hitting the wall while parked in the garage. I took the truck to the dealership to get repairs done and was charged 308.88 for the tailgate switch and diagnosis that should have been under a recall for this truck. Safety Recall N232426400 Tailgate May Open Unexpectedly issued May 2024. I called the customer service number [redacted] to try and get reimbursed for the repairs and they told me there is no recall on my truck. I had this problem and it clearly states the year, make and model of my truck in the recall, but because my vin wasn't included I'm out of luck? …
Transmission & drivetrain
The contact owns a 2021 Chevrolet Silverado 3500. The contact stated that while driving approximately 65 MPH, the vehicle unexpectedly went into Low Power Mode, with the check engine and low power mode warning lights illuminated. The contact was able to restart the vehicle. The vehicle was taken to an independent mechanic, where DTC: P2706 and P2732 were retrieved, and the contact was informed that the valve body and certain components of the transmission required reprogramming. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 24V797000 (Power Train). The dealer was contacted but the vehicle was not diagnosed or repaired by the dealer. The manufacturer was not made aware of the failure. The approximate failure mileage was 146,000.
The contact owns a 2021 Chevrolet Silverado 3500. The contact stated while driving at approximately 45 MPH, the brake pedal was depressed and extended to the floorboard, and the vehicle almost crashed into the rear of another vehicle. The contact later discovered that the rear driver's side brake pad had been ejected from the vehicle. The vehicle was taken to the local mechanic who was unable to determine the cause of the failure. Additionally, the contact stated that the transmission erroneously shifted out of 4-WD while driving. The contact stated that the failure had occurred on several occasions. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 49,000. The VIN was not available.
Body & structure
The tailgate opened and closes on its own while trailering causing sever binds and damage to the trailer and allowing loads to become unsecured. There is a recall already from GM on this issue, but for some reason our VIN is not included. This is a well documented issue. We have video of this occurrence if necessary. The dealer said it's water in the tailgate switch.
#N232426400-04: Safety Recall - Tailgate May Open Unexpectedly lists RPO code QT5 as the only applicable RPO code for the issue of tailgate opening unexpectedly. QT5 is for manual gate function with EZ lift, power lock release. The recall blames water intrusion into these vehicles' tailgates that can come into contact with the electronic gate-release switch, potentially causing a short circuit, which may inadvertently unlatch and open the tailgate when in park. The correction is to replace the exterior touchpad switch assembly with part number 85734717. My vehicle has RPO code QT6, which is for power up/down gate function with power lock and release. That option uses the same exterior touchpad switch assembly with part number 85734717. My vehicle did exhibit the same problem of opening unexpectedly while in park. …
Frequently asked questions
Is the 2021 Chevrolet Silverado 3500 a good car?
Based on 41 owner complaints filed with NHTSA, the 2021 Silverado 3500 rates avoid: 2.5× as many complaints as a typical year of the Silverado 3500 at the same age. It is one of the Silverado 3500 years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2021 Chevrolet Silverado 3500?
The electrical system — 13 complaints, 32% of all complaints for this model year. Next are the transmission & drivetrain (7) and body & structure (6).
How many recalls does the 2021 Chevrolet Silverado 3500 have?
There are 5 recalls for the 2021 Chevrolet Silverado 3500, the most recent from October 24, 2024 (valves/valve body). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Chevrolet Silverado 3500?
The best years by complaints, compared at the same age, are 2014, 2017 and 2012. Years to avoid or approach with caution: 2024, 2025, 2021, 2020 and 2022. See the full Chevrolet Silverado 3500 years comparison.
At what mileage do 2021 Chevrolet Silverado 3500 problems happen?
The median mileage reported in complaints is about 35,000 miles; 75% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.