Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2019 Chevrolet Equinox owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2019 Chevrolet Equinox. The contact stated that while driving at 65 MPH, he observed flames emanating from underneath the vehicle, prompting him to pull to the shoulder of the roadway. After a visual inspection of the vehicle, the contact observed that the fire originated in the fuel tank. Local emergency fire services arrived and were able to extinguish the flames. A police and fire report was filed, with no injuries reported. The check engine warning light was illuminated. The vehicle was towed to a tow yard, awaiting investigation by the manufacturer. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V667000 (Fuel System, Gasoline), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 93,000.
The contact owns a 2019 Chevrolet Equinox. The contact stated that while driving at an undisclosed speed, the contact became aware of a fuel-like odor coming from the driver's side of the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the sealed seam had failed and the fuel tank needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 89,000.
The contact owns a 2019 Chevrolet Equinox. The contact stated the vehicle failed to start, with the check engine warning light illuminated. The contact was able to jumpstart the vehicle and drove to an independent mechanic however, the battery failed after turning off the vehicle. The mechanic associated the failure with NHTSA Campaign Number: 19V667000 (Fuel System, Gasoline) however, the VIN was not included. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was 46,568.
The contact owns a 2019 Chevrolet Equinox. The contact stated that upon inspecting the vehicle, there was fuel leaking onto the driveway near the fuel tank. No warning lights were illuminated. The contact stated that the dealer was contacted. The vehicle was not taken to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 19V667000 (FUEL SYSTEM, GASOLINE). The manufacturer was not notified of the failure. The failure mileage was 229,000.
The contact owns a 2019 Chevrolet Equinox. The contact stated while driving at various speeds, the vehicle stalled. The vehicle was able to be restarted. The contact stated the fuel system warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with a fuel system failure. The vehicle was not repaired. The manufacturer was made aware of the failure; however, no assistance was provided. The failure mileage was approximately 138,000. The VIN was not available.
Check engine lite want go off low acceleration and. reduce Engine power light came on today .Just got the car in March . Low engine power light came on was on eway and had to pull over . And someone almost hit my kids and I
This vehicle has started to lose power was taken to firsteam Norfolk Va where purchased took for oil change and tire rotation also loss of engine power at speeds of 20-32 mph and 50-62 mph. Dealership at Norfolk Va sent to firstteam Hampton VA Chevrolet for diagnosis and came back no engine light and small misfire 3/4 sparkplugs needed changed 177.00. After plugs were changed still had misfire then they felt it was number 4 injector 500.00 but never did work. I took it to national shop for recommended injector and when plugs were pulled mechanic found no new plugs. Injector was replaced with gm part and still misfiring. Norfolk firstteam towed vehicle back to Hampton Va firstteam and they are now giving me the run around. They want a blank check to replace parts till they find the problem. Unexceptable to even ask. …
Something is wrong with the brake assist system. The car was serviced literally towards the end of may and the brake assist service light keeps turning on. It is now causing the vehicle to have a check engine light that comes and goes as it pleases and the car now thinks that it is a bucking bronco at times with how hard it runs at times now. We have spoken and seen now multiple others complaining about the fueling system which does not alloe you to fill the gas tank up all the way. The tank holds 14.9 gallons and if the car is empty and on its last drop the car will only allow 12 gallons at best and that takes nearly 20 minutes of fighting with the car at the pump. The electrical in the vehicle is unstable. Multiple times while driving the radio and power to the car just turn off. I have also seen the recalls for the brake problems but when I enter my VIN it comes back all clear. …
This issue presents a serious safety concern. During the initial occurrence, the vehicle was unable to sustain highway speeds for extended periods (approximately 10 minutes or more). When coming to a stop, the vehicle would shake, rev unexpectedly, lose power, and shut off completely. During these events, the vehicle would not accelerate, creating a hazardous situation, especially in traffic. The condition has since worsened. The same symptoms now occur upon starting the vehicle and during the warm-up period, increasing the risk of sudden engine shutdown without warning. Additionally, a distinct "gulping" sound is coming from the rear of the vehicle, raising concern that the fuel system may be compromised. No diagnostic or pending fault codes are present, and the local dealership has been unable to identify the cause. The vehicle has fewer than 100,000 miles. …
Gas gauge will not go all the way to full. It stops just over 3/4 of a tank, no matter how much fuel you put in the tank. There is no way to accurately determine how much fuel is in the vehicle at any point and time. This is a safety hazard because we could be stranded on the side of the road, not knowing the vehicle would run out of fuel. Also, occasionally when you crank the vehicle, you get a strong odor of fuel in the cabin, when running the A/C. There is nothing specific that is being done differently, and it does not happen every time. We bought this vehicle on 9/18/22 with 27,602 miles on it and as of today, it has 28,594 miles on it. After purchasing it, we noticed the fuel gauge issue and I researched it online, finding out it is a common issue and GM claims to have no idea how to fix it.
Related recalls
Fuel system, gasoline › Storage › Tank assembly
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Equinox all-wheel drive vehicles. The fuel tanks may have been manufactured with an improperly sealed seam, possibly allowing fuel to leak along the seam near the fuel inlet.
Remedy: GM will notify owners, and dealers will replace the fuel tank, free of charge. The recall began October 24, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N192271870.
Fuel System complaints in other Equinox years
Frequently asked questions
How common are fuel system problems on the 2019 Chevrolet Equinox?
NHTSA has 47 complaints about the fuel & propulsion system of the 2019 Chevrolet Equinox, 15% of the model year's 306 complaints.
Is there a recall for 2019 Chevrolet Equinox fuel system problems?
Yes — NHTSA recall 19V-667 (tank assembly, Sep 19, 2019). Recall repairs are free at authorized dealers.
At what mileage do 2019 Chevrolet Equinox fuel system problems start?
Half of the complaints with a recorded mileage happened before about 15,000 miles, and 53% before 25,000 miles.
Is it dangerous?
Owners linked 3 crashes, 2 fires and 0 injuries to fuel & propulsion system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.