2023 Chevrolet Colorado Engine Problems

Mileage when the problem started

Owner reports

Selected complaints filed with NHTSA by 2023 Chevrolet Colorado owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2023 Chevrolet Colorado. The contact stated while driving at an undisclosed speed, the heater did not function as intended. The vehicle was driven to the residence. The contact checked the fluids and noticed that the oil dipstick was completely dry. In addition, the contact investigated and noticed that the oil had leaked all over the surface of the oil pan. The contact stated that the oil change warning light was later illuminated. In addition, the contact stated that the failure had occurred after leaving the dealer and an unknown recall repair was performed. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact referenced a Customer Satisfaction Program; however, the vehicle was not included. …

The contact owns a 2023 Chevrolet Colorado. The contact stated that while driving, the vehicle decelerated from 70 MPH to 30 MPH. During the failure the check engine and traction control warning lights were illuminated. The vehicle was towed to the local dealer who diagnosed an engine cylinder misfire. No further information was available. The contact stated that the vehicle was serviced by the dealer on several occasions for the failure however, the failure persisted. The contact stated that the vehicle was unsafe to drive. The manufacturer was notified of the failure. The failure mileage was 3,000.

Since Friday, February 23rd 2026 when my 2023 Chevy Colorado first start blowing oil out of the oil pan. almost 5 qts total was lost when it arrived at the dealership. Truck was out of service from Friday until the following Wednesday, January 28th. The truck was picked up and taken on a drive out to (January 29th, 2026) Waverly, KS from my hometown of Prairie Village, KS about 70 miles. On the way back home the truck went into safe mode at highway speeds. Lost all acceleration and barely made it off the side of the road before getting hit. Truck went back to dealership after being towed 70 miles. Where it was kept until Friday, February 6th. During this time at the dealership, they thought the problem was fixed, where again blew out all the oil while driving. Finally received the truck back. Check engine lights were still on but truck was holding oil and driving decent. …

My 2023 Chevrolet Colorado (2.7L, approx. 49,000 miles) experiences sudden, intermittent loss of motive power involving the 8-speed automatic transmission. The transmission sets codes and the vehicle drops into limp mode, capped at roughly 45 mph, without warning. The most dangerous symptom is a total loss of acceleration from a stop, especially on inclines - pressing the accelerator produces no response. On one occasion, stopped on a slight incline, the vehicle rolled backward toward the car behind me when it failed to move forward on accelerator input. I narrowly avoided a collision. On a separate occasion, after pressing the accelerator with no response, the vehicle then suddenly lurched forward into cross traffic; repeated presses produced inconsistent, delayed engagement, nearly causing a collision. …

2 incidents. 1. The blind spot indication (driver side) gives false readings sometimes. Will light up at various times in clear weather with no vehicle next to me. Sensors checked and were clean. 2. The vehicle had a dead battery. It was jumped by roadside assistance. When started, the vehicle had a check engine light. I called Onstar (hands free function built in) to diagnose the problem while driving to charge the battery. Onstar told me what it said and indicated I should take it to the dealer. When I attempted to merge onto OK-51 the vehicle suddenly stopped accelerating without warning causing me to nearly miss another vehicle while merging. When I looked down at the IP, a message came up saying vehicle limited to 62 mph. …

The upper radiator hose on some huge percentage of these trucks fail (mine has failed at just over 20K miles). You can check the Colorado Chevy forum, youtube, etc., et al, and find plenty of instances where this has failed. As this is the cooling system, it can cause the engine to overheat and potentially ruin the engine. The flaw seems to be an engineering issue with the rubber seal they use (instead of a high quality o-ring) to seal the upper hose to the radiator. Additionally, since this can cause engine failure it should be addressed immediately. Instead, my local Chevy dealer, since its not a recall item, said they could schedule a time next week for me to LEAVE the truck and then they would get to it in 7-10 days. This is extremely unfair to the consumer who depends on these vehicles. This should absolutely be a recall item. …

What component or system failed or malfunctioned, and is it available for inspection upon request? To my knowledge, which is limited on vehicle diagnosis, the engine valve body is having an issue finding a gear when starting from a stop. How was your safety or the safety of others put at risk? The vehicle engine will sputter and jolt forward and attempt to go to a higher or lower gear when approaching the stop . Has the problem been reproduced or confirmed by a dealer or independent service center?The problem is reproducible, but the dealership is stating i would need a check engine light to have it serviced or seen. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? …

Vehicle: 2023 Chevrolet Colorado Crew Cab 4WD, VIN: [redacted] , mileage: 52,877. Recurrent failure in the cooling system and engine/transmission, affecting safety and use. Check Engine Light comes on and off intermittently, code P30C5 (Coolant Flow Low). The coolant pump was replaced under warranty on March 20, 2025, at Leson Chevrolet (Harvey, LA) with 26,621 miles (attached invoice), but the same issue persists 9 months later with "Engine and Transmission System" alert in myChevrolet app. This is the 5th failed repair for the same defect since purchase (August 2023). Previous repairs include transmission wiring/sensor (January 2024) and Traction Control/ABS (December 2023). The vehicle is unsafe for daily 100-mile commute. Request investigation for potential recall.

Engine light came on. Fan ran high. Had it towed to the dealership. Has 39,000 miles on it. Needs a new upper radiator hose due to a defective hose. Apparently, after reading online, GM is aware of this issue. Now we have to pay the diagnostic fee and $850 for a new hose and a flush, as well as the tow bill! Now can't get the part for a week or 8 days and then have to wait on the repair. This is unsatisfactory that there is a known problem and isn't covered or hasn't been a recall.

Faulty Radiator Inlet Hose, upper radiator hose failure, outlined in PIT6494A. This is the third time that the light on the dashboard has come on for failure, the first time they "Fixed it" the second time they said it was the Battery, it was NOT!! This time they are saying what it really is, The Radiator Hose FAILURE, since the vehicle is only 3 years old but over the 36k mile WARRANTY, they will NOT fix! failure on their part.

Engine complaints in other Colorado years