Which parts fail
Components named in complaints (engine, cooling system, oil leaks, timing chain, exhaust).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2021 Chevrolet Colorado owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving at an undisclosed speed, the vehicle shuddered and failed to decelerate as intended while the brake pedal was depressed. An unknown message was displayed. In addition, the contact stated the vehicle failed to respond properly while the accelerator pedal was depressed. Upon inspection, the contact noticed an abnormal engine oil leak. The vehicle was towed to the residence. The vehicle was later towed to a local dealer, where it was diagnosed with an exploded brake booster and metal shavings inside the engine. The vehicle remained at the local dealer unrepaired due to the cost. The local dealer could not guarantee that the repairs would correct the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000.
The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving at unknown speeds, the check engine warning light illuminated. Additionally, the navigational system and radio continued to reboot, and volume increased to high levels without driver interaction. The contact replaced bank two and valve two and stated that the cam shaft exhaust was faulty. The vehicle was repaired, but the failure recurred. The vehicle was taken to an independent mechanic, who informed the contact that the failure was due to bank two, the cam shaft, and that the vehicle was idling roughly. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the local dealer. The failure mileage was approximately 46,000.
The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving approximately 75 MPH, the engine revved without the accelerator pedal being depressed. The contact stated that while turning onto an exit ramp, the brake pedal was depressed to slow the vehicle; however, there was resistance to the brake pedal, and an excessive amount of pressure was needed to depress brake pedal to stop the vehicle. There were no warning lights illuminated. The vehicle was not taken to be diagnosed or repaired. The dealer was informed of the failure. The dealer informed the contact that failure might cause the complete engine failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000.
The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving 40 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the brake pedal was depressed to the floorboard and the engine seized. The contact stood on the brake pedal. The vehicle was towed to the dealer, where it was diagnosed with a fractured camshaft. The contact was informed that the brake vacuum pump fractured the camshaft, and the camshaft was fractured in half. The contact was informed that the camshaft needed to be replaced. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 65,500.
The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving at 30 MPH, the check engine warning light illuminated. A dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed, and it was determined that the camshaft actuator valve needed to be replaced. The vehicle was not repaired. The contact associated the failure with Special Coverage Program: N232430470 (Camshaft Position Actuator Valve Solenoid - Bank 2 (Left Side) Exhaust ); however, the VIN was not included in the program. The manufacturer was notified of the failure and informed the contact to call the NHTSA Hotline for assistance. The failure mileage was 43,500.
The contact owns a 2021 Chevrolet Colorado. The contact stated while towing a 2020 Forest River ePro 20BHS, the service DEF system malfunctioned, not allowing the contact to view the temperature and the towing controller. The contact stated the check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with the DEF system needing to be regenerated. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 29,000.
While driving on the parkway, the engine revved, and then the brakes became hard as a brick. The truck was unable to be stopped. There were no warning lamps or indications there was a problem, it happened suddenly and immediately. Other drivers' and my own safety was at risk because I could not stop the truck. Here is the diagnosis from the GM service center where it was towed to: "After the removal of the valve cover, the tech found the pump in pieces, and the end of the exhaust camshaft was damaged, as presented in the photos. The quote attached depicts all that is being replaced with this repair." The is a know and acknowledged GM defect that has affected well over 3 million vehicles to date. There was a recall issued for some models, but not the Chevrolet Colorado. …
The engine coolant temperature gauge is stuck at approximately 160 F. Cooling fans are running at high speed constantly. The thermostat is stuck in the open position. The vehicle is less than 100,000 miles. There is a "Special Coverage Bulletin N242484760" that has indicated the issue is occurring regularly with my type of vehicle but my specific VIN is excluded due to misplaced parameters. The part is readily available at the dealership in which we are getting the part fixed because so many vehicles of my make and model are having this issue. The cost of the repair will be $1,200 and will be out of pocket because my VIN is excluded but clearly affected by the same faulty system for the coolant. This is a mistake as my vehicle is have the exact same issue as all of the others "covered" in the special coverage. …
In December 2024, at under 50,000 miles, my 2021 Chevrolet Colorado suffered complete brake failure caused by vacuum pump failure. The vacuum pump failure led to irreparable internal engine damage, requiring complete engine replacement under warranty. Sudden, complete brake failure in traffic could have led to a serious accident causing injuries or death to myself and/or others. The component was inspected by the manufacturer and the service advisor at the dealership stated this was "kind of a known issue on Colorados". There were no warning lamps, messages, or symptoms of the problem prior to the failure. This vacuum pump failure is documented in GM Technical Service Bulletin #21-NA-268, which addresses vacuum pump failures on other GM vehicles. The identical failure mode in my 2021 Colorado demonstrates this is a systemic manufacturing defect, not an isolated incident.
Complete engine failure due to defective crankshaft malfunction, truck taken to certified repair shop and then dealer, deal not responding for 24 days. Engine failed traveling on the highway was fortunately able to pull over, stranded. Engine light came on and the engine failed completely 5-10 min after on a 2 hour return trip home. Certified repair shop informed me this is the exact same reason of the recall just that my vehicle wasn't currently under the recall. Vehicle component has been recalled on other Chevrolet vehicles manufactured during the same time just not this one yet.
Engine complaints in other Colorado years
Frequently asked questions
How common are engine problems on the 2021 Chevrolet Colorado?
NHTSA has 20 complaints about the engine & cooling of the 2021 Chevrolet Colorado, 25% of the model year's 79 complaints. The component named most often is engine › crank/camshaft position sensor (1 mentions).
Is there a recall for 2021 Chevrolet Colorado engine problems?
No. NHTSA lists no engine & cooling recall for the 2021 Chevrolet Colorado, though it has 1 recall for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2021 Chevrolet Colorado engine problems start?
Half of the complaints with a recorded mileage happened before about 66,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.