Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2021 Chevrolet Colorado owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving at an undisclosed speed, the vehicle shuddered and failed to decelerate as intended while the brake pedal was depressed. An unknown message was displayed. In addition, the contact stated the vehicle failed to respond properly while the accelerator pedal was depressed. Upon inspection, the contact noticed an abnormal engine oil leak. The vehicle was towed to the residence. The vehicle was later towed to a local dealer, where it was diagnosed with an exploded brake booster and metal shavings inside the engine. The vehicle remained at the local dealer unrepaired due to the cost. The local dealer could not guarantee that the repairs would correct the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000.
The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving approximately 75 MPH, the engine revved without the accelerator pedal being depressed. The contact stated that while turning onto an exit ramp, the brake pedal was depressed to slow the vehicle; however, there was resistance to the brake pedal, and an excessive amount of pressure was needed to depress brake pedal to stop the vehicle. There were no warning lights illuminated. The vehicle was not taken to be diagnosed or repaired. The dealer was informed of the failure. The dealer informed the contact that failure might cause the complete engine failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000.
The contact owns a 2021 Chevrolet Colorado. The contact stated that while driving 40 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the brake pedal was depressed to the floorboard and the engine seized. The contact stood on the brake pedal. The vehicle was towed to the dealer, where it was diagnosed with a fractured camshaft. The contact was informed that the brake vacuum pump fractured the camshaft, and the camshaft was fractured in half. The contact was informed that the camshaft needed to be replaced. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 65,500.
I am reporting a serious safety defect involving my 2021 Chevrolet vehicle. While driving, multiple warnings appeared including "Service Power Steering," "Steering Assist is Reduced," "Service ESC," and "Service Battery Charging System." The vehicle then lost steering assist, braking performance became unreliable, and it created a serious risk of crash. The vehicle later shut down completely and has remained inoperable. The failure appears electrical and affected multiple critical systems at once, suggesting a cascading system malfunction. Since the incident, the vehicle has not restarted or operated normally. I have replaced the battery, alternator, starter, ignition switch, brake vacuum pump, ECM, spark plugs, fuses, and relays, but the issue persists. The vehicle still shows charging system faults and severe battery drain, indicating an unresolved underlying electrical defect. …
While driving downhill nearing a stop sign my wife went to apply the brakes to stop and all she had was an extremely hard brake pedal. She panicked that she "no brakes." She was only going about 20 MPH, and was able to stop the vehicle but it took an extraordinary amount of effort to do so. Had she had to make a sudden stop for a child, another person, or something else, she would not have been able to stop without negative consequences including possible death. There were no warning signs, vehicle pulled out of driveway and brakes were normal. Less than 10 seconds later no more power brakes. The vehicle had the vacuum pump seize which eliminated the power boost and the pump is operated by the exhaust camshaft which also got damaged and needs replaced. Chevy dealership estimated the repair at $2,600. …
While driving on the parkway, the engine revved, and then the brakes became hard as a brick. The truck was unable to be stopped. There were no warning lamps or indications there was a problem, it happened suddenly and immediately. Other drivers' and my own safety was at risk because I could not stop the truck. Here is the diagnosis from the GM service center where it was towed to: "After the removal of the valve cover, the tech found the pump in pieces, and the end of the exhaust camshaft was damaged, as presented in the photos. The quote attached depicts all that is being replaced with this repair." The is a know and acknowledged GM defect that has affected well over 3 million vehicles to date. There was a recall issued for some models, but not the Chevrolet Colorado. …
While driving a 2021 Chevrolet Colorado on Interstate 95 in Florida, the vehicle suddenly experienced a loss of brake assist. The brake pedal became extremely hard and very difficult to press. The driver had difficulty slowing the vehicle and had to use the emergency brake to help bring the vehicle to a stop. This occurred on Interstate 95, which is a very busy highway with high-speed traffic. The sudden loss of braking assistance created a serious safety hazard and could have resulted in a crash. The vehicle was taken to a repair shop where the mechanic diagnosed the problem as a failed vacuum pump that broke and damaged the exhaust camshaft and related components. The repair required replacement of the vacuum pump, exhaust camshaft assembly, camshaft actuator and solenoid, and valve cover gasket. The total repair cost was approximately $2,329. …
In December 2024, at under 50,000 miles, my 2021 Chevrolet Colorado suffered complete brake failure caused by vacuum pump failure. The vacuum pump failure led to irreparable internal engine damage, requiring complete engine replacement under warranty. Sudden, complete brake failure in traffic could have led to a serious accident causing injuries or death to myself and/or others. The component was inspected by the manufacturer and the service advisor at the dealership stated this was "kind of a known issue on Colorados". There were no warning lamps, messages, or symptoms of the problem prior to the failure. This vacuum pump failure is documented in GM Technical Service Bulletin #21-NA-268, which addresses vacuum pump failures on other GM vehicles. The identical failure mode in my 2021 Colorado demonstrates this is a systemic manufacturing defect, not an isolated incident.
Today while driving my brakes got super hard. Had to use my entire weight to get it to stop and still was moving forward. Had to use the emergency brakes and a prayer. Luckily I wasn't on the highway or it would've been a deadly accident. When I opened the hood the camshaft sensor was broken loose. Mind you I had taken the truck to the dealer a while back for a rattling noise at 1500 RPM and they couldn't figure out the issue. They replace the catalytic converter under warranty. But kept making the same noise around the same RPM. Obviously it wasn't the converter. My truck has 43,136 miles only. 2021 Colorado 2.5 Luckily I'm alive today but this must be taken care of as soon as possible. I read a lot of Colorado's seem to have the same issues. Needs a recall.
I was on my way home from work and I was on Highway 16 in Washington state near Port Orchard and I was driving 64mph and all vehicles in front of me were all breaking slowing down pretty fast and when I pressed down on my brakes the brakes were totally stiff I could not stop and had to drive on the side of the road and passed 20 plus cars and was finally able to come to a stop. If I had no where to go I would've hit the car in front of me at a high rate of speed potentially causing a major or deadly accident. They were working fine 5 minutes before that. I think it is a major issue that will cause fatalities in the future if this problem isn't taken care of. I've never had a vehicle do this and I've been driving for 38 years.
Brake complaints in other Colorado years
Frequently asked questions
How common are brake problems on the 2021 Chevrolet Colorado?
NHTSA has 20 complaints about the brakes of the 2021 Chevrolet Colorado, 25% of the model year's 79 complaints.
Is there a recall for 2021 Chevrolet Colorado brake problems?
No. NHTSA lists no brakes recall for the 2021 Chevrolet Colorado, though it has 1 recall for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2021 Chevrolet Colorado brake problems start?
Half of the complaints with a recorded mileage happened before about 70,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.