Which parts fail
Components named in complaints (power windows, windshield, wipers, mirrors, sunroof).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2019 Toyota RAV4 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact's daughter owns a 2019 Toyota Rav4. The contact stated that the driver's and passenger's side front windows became inoperable. There were no warning lights illuminated. The vehicle was taken to the local dealer, who diagnosed that the window regulators on the driver's side and passenger's side front windows needed to be replaced. The vehicle was not repaired. The contact who is a mechanic stated that the steel cable in the plastic had deteriorated, and water and moisture had entered the vehicle, causing corrosion. The contact replaced both window regulators. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 63,000.
The contact owns a 2019 Toyota Rav4. The contact stated that while driving at an undisclosed speed, an abnormal glass-cracking sound was heard. The contact pulled over and noticed that the sunroof glass had shattered; however, the sunroof visor prevented the glass shards from entering the cabin of the vehicle. There was no impact on the sunroof that could have caused it to shatter. The contact did not sustain any injuries. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.
The contact owns a 2019 Toyota Rav4. The contact stated while driving at 55 MPH, he heard a loud banging sound. The contact veered to the side of the road. The contact noticed that the sunroof glass panel had exploded with 40 percent of the shattered glass remaining. The contact stated that the shade guard was closed at the time of the failure. The contact was able to continue driving. The dealer was notified of the failure but did not provide any assistance. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 25,300.
The contact owns a 2019 Toyota Rav4. The contact stated that she initially noticed that the headliner was stained and later realized that rainwater had leaked into the driver's and passenger's side front cabins from the roof rail. The vehicle was taken to the dealer, where it was diagnosed that the failure was caused by a previous windshield replacement. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 15,000.
On February 2, 2026, while driving approximately 65 mph on the freeway in Wisconsin, the panoramic sunroof glass on my 2019 Toyota RAV4 XLE Premium (VIN: [redacted] ) spontaneously exploded. The ambient temperature was approximately 20 F. Crucially, the glass buckled outward, indicating the failure was caused by internal pressure or a structural defect, rather than an external impact (such as a rock). There were no other vehicles immediately ahead of me that could have kicked up debris. Safety Risk: The explosion created a loud, gunshot-like noise that caused severe driver distraction at highway speeds. While no crash occurred and no injuries were sustained this time, the sudden structural failure posed a significant risk of loss of vehicle control. Status: No warning lights or messages appeared prior to the failure. The vehicle had no prior damage to the roof area. …
The Panoramic Sunroof spontaneously exploded while driving on the freeway. There was no impact point and the glass is bowed outward. When it exploded it was a very load pop and pressure feeling that made everyone's ears ring. About 2 seconds later small glass particles and glass dust fell down on the driver and passenger. This was reported to insurance company and taken to independent service center for estimate and repair. There were no warning lights or prior issues. The sun roof was in perfect working order and the vehicle has less than 25,000 miles on it. Driving context - 10:30 PM, light rain, outside temp was 38degrees, inside car temp set at 72 with heater on, sunshade was back, radio off, very little traffic on freeway with no road disturbances.
Toyota service bulletin: T-SB-0079-20 (August 14, 2020) Outer Rear View Mirror Image Vibration While Driving (Causes distraction and could lead to and accident because image in side mirrors are unusable due to vibration) Dealer refuses to do this repair because it was only covered under a 36mo or 36,000 mile warranty. My car currently has 23,500 and this repair should be covered...or be a recall! Some 2019 - 2020 model year RAV4 and RAV4 Hybrid vehicles may exhibit a vibration/shaking of the image shown in the outer rear view mirror(s) while driving. Mirror vibration can be observed at highway speeds of approximately 50 - 70 mph on typical concrete/asphalt road surfaces.
The wipers started acting up a few months ago, the low setting would cycle 7 times then stop randomly, the high setting would cycle 11 times then stop randomly. I could reset it by turning off, then on. On 9/22/2026 I was driving home when it started to down pour. The wipers at first did as previous. But at a critical moment they completely stopped and would not cycle again. I had to pull over to the side while in traffic and not being able to see. I have replaced the wiper motor and switch but to no avail.
The sunroof/moonroof in my 2019 Toyota RAV4 spontaneously exploded while parked overnight in my driveway. There was not any damage on or around that area of my car, nothing above my car. The following morning when I pulled out of my driveway, I noticed a strange sound , retracted my visor and noticed the roof glass was completely shattered in a volcanic like shape. Pieces began to fall as I began to pull back into the driveway.
Wipers would not turn on when activated. I checked all fuses were good and still not working. I drove home with no wipers in rain. Then next day I went to recheck fuses and relays, but the wipers came on.
Window & Wiper complaints in other RAV4 years
Frequently asked questions
How common are window & wiper problems on the 2019 Toyota RAV4?
NHTSA has 22 complaints about the windows, wipers & sunroof of the 2019 Toyota RAV4, 2% of the model year's 882 complaints. The component named most often is sun/moon roof assembly (4 mentions).
Is there a recall for 2019 Toyota RAV4 window & wiper problems?
No. NHTSA lists no windows, wipers & sunroof recall for the 2019 Toyota RAV4, though it has 7 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2019 Toyota RAV4 window & wiper problems start?
Half of the complaints with a recorded mileage happened before about 2,000 miles, and 73% before 25,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.