2022 Toyota Highlander Airbag Problems

Mileage when the problem started

Owner reports

Selected complaints filed with NHTSA by 2022 Toyota Highlander owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2022 Toyota Highlander. The contact stated that while driving at an undisclosed speed, the contact's vehicle was involved in a crash. The contact stated that the other vehicle that crashed into the contact stated the vehicle's speed was about 75 MPH. The contact stated that when the contact's vehicle was impacted, the contact's vehicle air bags failed to deploy. The contact stated that after the crash, the ABS warning light illuminated. The contact's vehicle was occupied by the contact's husband, who was seated in the front passenger's seat. The contact's two children, ages [redacted] and [redacted] old, were seated in the rear seat. The Police and Fire departments arrived on the scene. The contact stated that medical attention was provided at the scene. The contact sustained injuries included a concussion, a sprained left ankle, and a sprained right wrist. …

The contact owns a 2022 Toyota Highlander. The contact stated that while her husband was driving approximately 25-30 MPH with the contact seated in the front passenger's side seat, another vehicle crashed into the passenger's side of the vehicle. The contact stated that the driver's and passenger's side front air bags and curtain air bags failed to deploy as expected. The driver and the passenger sustained injuries and were transported to the hospital by ambulance. The driver's chest struck the steering wheel, causing a mark and swelling. The contact sustained cuts to the right arm, excruciating pain on the left side of the body, bruises, pain between the shoulder blades, a concussion, a hard hit to the left rib cage, and deep tissue trauma to the front of the neck that activated temporomandibular joint (TMJ) dysfunction. …

My mother was involved in a motor vehicle collision while properly restrained by her seat belt. During the collision, the vehicle sustained a significant impact; however, the airbags did not deploy. Following the accident, my mother went to the ER with significant bruising and injuries consistent with the force of the collision and seat-belt restraint. She has a fractured sternum, cardiac contusion and bad bruising. We are concerned that the airbags did not deploy and would like the airbag/restraint system investigated to determine whether it functioned as designed during the crash. We are reporting this incident to NHTSA so that the airbag non-deployment can be documented and reviewed as a potential vehicle safety issue.

My father in law drove my highlander car and got into an accident on 8/27/2024. Front of the car was damaged but did not deploy the airbags. And as far I know it is equipped with automatic braking system but the damaged looks really bad.

Accident where Toyota Highlander was struck on the front driver's side and airbags did not deploy. Driver and passenger were injured. Driver was hospitalized. Need to have car inspected before destruction.

The component that failed is the roof rail clips that hold the roof rack to the vehicle (Toyota Service Bulletin T-SB-0040-24). The clips under the rail fail and cause water to leak into the headliner and down the A-pillars on both sides of the vehicle. It presents itself by causing water staining where the headliner meets the A-pillar cover. This issue presented itself in January of 2023, a few months after we bought the vehicle. Toyota Bountiful (Utah) tried to tell us that it is the sunroof drain lines that are clogged and required a $100 service to clear them which is an annual service. After some push back they found the problem with the roof rack clips. However, they only replaced the passenger side and neglected to repair both sides. April of 2025 the driverside failed and Toyota Bountiful once again confirmed that the driverside clips failed. …

On our 22' Highlander I observed water lines on the passenger side A pillar, one of which was colored pinkish this led me to believe it was dyed from car wash soap. I found that whenever you go through a car wash water leaks into the headliner and down the passenger side A-pillar where the air bag module is. Toyota Bountiful claims that the drainage channels are likely clogged and it failed to drain properly. I ran the test as recommended by pouring water into the corner drainage hole identified by the service advisor. I found the water to exit the drainage port behind the front tire in two different spots at a very quick rate, yet the headliner and A-pillar covering got wet again. Toyota claims this is supposed to cleaned annually by the vehicle owner and is likely not covered by warranty. …

On or about 9/22/24 I was driving on a parkway and was alerted by a high pitched alarm in the vehicle's dashboard that the airbag had a malfunction and that the seatbelt was not engaged. I removed my seatbelt and clipped it back in but that did not stop the alarm. The vehicle continued to beep and say the airbag was malfunctioning. I made an appointment with Toyota service for 9/26/24 and when I arrived I was told they do not do diagnostic tests on Thursdays. They proceeded to give me a new appointment for today 9/28/24, and when I arrived they once again turned me away explaining that today was not a good day for a diagnostic. They mockingly told me that my vehicle warranty was about to expire. Furthermore, the Toyota has refused to fix the recall issue, and now is refusing to even run a diagnostic test to see what the problem is with the airbags. …

1. The SRS airbag malfunction alert message has been displayed for more than a month. The vehicle was brought to the Toyota dealer where it was purchased for being diagnosed and repaired TWICE, but the problem still exists now. [The alert message is always displayed and keeps the driver from seeing any other information on the instrument panel. This is annoying and very dangerous.] 2. The engine sometimes automatically turned off while the vehicle stopped and was waiting for green lights at intersections or yielding to other vehicles at stop signs. The driver had to start the engine again before continuing driving. The vehicle was also brought to the dealer where it was purchase for repair, but the technicians were unable to find the problem.

The airbag malfunction alert message has been displayed for more than two months. The vehicle was taken to Toyota of Newnan (GA) dealership four times for repair; they kept my vehicle for an entire week at their facility the latest time (fourth). The problem still exists! It seems they have not taken this problem seriously because they have not called me regarding the problem. I called them so many times ... I need help from the your office because I have to use this vehicle for my three kids to go to and from schools every day. Please please please help me! Thank you.

Airbag complaints in other Highlander years