Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2018 Toyota Corolla owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2018 Toyota Corolla. The contact stated that while driving at various speeds, the brake warning and the master warning lights illuminated intermittently. The vehicle was taken to an independent mechanic where a diagnostic reader was used, however, the mechanic was unable to locate a failure code. The vehicle was not repaired. Additionally, the contact stated that after restarting and refueling, the vehicle was stalling and although she depressed the accelerator pedal, the vehicle delayed accelerating. The contact referenced failure to NHTSA Campaign Number: 20V012000 (Fuel System, Gasoline) however, VIN was not included in the recall. The contact then stated that after the vehicle was refueled and she came to a left turn to make a U-turn, the vehicle was stalling and then jerked forward independently, causing her to crash into the back of an attached trailer. …
The contact owns a 2018 Toyota Corolla. The contact stated while driving 40-60 MPH, the vehicle started jerking. The warning messages "Charge System Malfunction - See Owner's Manual", "Oil Pressure Low Stop in A Safe Place. See Owner's Manual" and "Traction Control Turned Off" were displayed and the vehicle stalled. The contact was unable to restart the vehicle. The vehicle was pushed to the side of the road. The contact was able to restart the vehicle after 30 minutes. The contact then drove to her residence. The failure reoccurred while driving. The vehicle was taken to the dealer where unknown codes were cleared. The dealer test drove the vehicle and diagnosed that no issues were found; however, the failure persisted. The vehicle was taken to the dealer where it was diagnosed that the fuel pump had failed and needed to be replaced. …
The contact owns a 2018 Toyota Corolla. The contact stated while attempting to start the vehicle, or upon approaching a stop, the engine sounded very weak, almost as if the vehicle would shut off. The contact stated that the vehicle had shut off previously while driving through a drive thru. The vehicle was restarted, and the check engine warning light illuminated while driving. The contact also stated that after refueling the vehicle, the accelerator pedal had to be pumped while starting the vehicle. The vehicle was taken to a local independent mechanic to be diagnosed and DTC: P0171 was retrieved. The contact was informed that the EVAP valves and system were faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The contact referenced NHTSA Campaign Number: 20V012000 (FUEL SYSTEM, GASOLINE) as possible cause for the failure. …
The contact owns a 2018 Toyota Corolla. The contact stated while coming out of a complete stop, the vehicle stalled. The vehicle was able to be restarted and functionality was regained. The contact stated that the check engine warning lights were illuminated. Upon investigation, the contact associated the failure with, NHTSA Campaign Number: 20V012000 (Fuel System, Gasoline). The vehicle was repaired but continued to experience failure. The vehicle was taken to a local dealer but was not diagnosed or repaired. The manufacturer was informed of the failure and the contact was awaiting a response. The failure mileage was approximately 76,000. Consumer stated engine light and "Traction Control Turned Off" warning while vehicle was still moving, then "Charging System Malfunction" and "Oil Pressure Low/Stop in a Safe Place" warning lights appeared at the same time the vehicle stalled.
The contact owns a 2018 Toyota Corolla. The contact stated while driving 60 MPH, the vehicle shut off unexpectedly on several occasions. The check engine warning light was illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 20V012000 (Fuel System, Gasoline) however, the VIN was not included. The vehicle was taken to an independent mechanic, who determined that the failure was due to the loss of power and a failing fuel pump. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted. The failure mileage was approximately 200,000.
My 2018 Toyota Corolla has ongoing fuel pump-related issues that mirror those in the official recall, yet my VIN is not included. Every time I refuel, my car shuts off and will not restart for 1-2 hours. I've brought the vehicle to five different mechanics, including two full inspections with electronic diagnostics-none could find a fault except one who identified the fuel pump as the likely cause. Even Toyota-certified dealerships could not determine the issue. Additionally, any time I drive over 70 mph, the car displays a message telling me to take a break, then it begins to jerk and drive erratically, clearly a safety hazard. This problem has occurred repeatedly and poses a serious risk of accident on the highway. This issue is widely reported among 2018 Corollas and matches symptoms from Toyota's known fuel pump recall. …
While driving at 55 mph, cruise control engaged, the vehicle suddenly lost power, the cruise control disengaged, the engine light came on and the traction control disengaged warning was displayed. The vehicle continued operating. After engine fault code stated there was a Mass Airflow Sensor fault. Owner replaced the sensor. Two weeks later, the situation repeated, this time the fault read as an oxygen sensor error. After a day or two, the fault would clear, only to repeat a week or two later. Then, on Dec. 31, the vehicle completely stalled at highway speeds. It would restart, but if the rpms exceeded 2,500 it would stall again. Trying to get an appointment with the dealership, but will have to wait until after the New Year for them to open again.
While driving the car started to sputter like it was going to die. When I stopped to gas the next day a gush of air came out of the gas tank when I took the cap off. I put gas in and then my car wouldn't start. For 3 hours I tried and finally it started. Now I can have in park and it revs clear to the 5 sometimes then it starts sputtering. Every time I put gas in I have to sit for 3 hours then it starts. The trac off light on the dash is on as well so nothing works the lane control, cruise control, the emergency brake system.
Had a recall on the fuel system causing the system to potentially stall the vehicle. Had the car service but still when doing cruise control its still doing the same thing by reving the engine to high on RPM to potentially stall the vehicle. Potential safety problem
While on the road but in a slow bumper to bumper traffic, the engine turned off. Scary situation. I had to pull over on the side and managed to restart the engine. Same incident happened and the engine suddenly turned off while at a gas station
Related recalls
Fuel system, gasoline › Delivery › Fuel pump
Toyota Motor Engineering & Manufacturing (Toyota) recalled certain 2018-2019 4Runner, Highlander, Camry, Land Cruiser, Sequoia, Sienna, Tacoma and Tundra, and Lexus RC 300, RC 350, GS 350, GX 460, IS 300, LC 500, LS 500, LX 570, RX 350L, and 2019 Toyota Avalon and Corolla, and certain Lexus NX 300, and ES 350 vehicles on…
Remedy: Toyota will notify owners, and dealers will replace the fuel pump, free of charge. The recall began May 4, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987.
Fuel System complaints in other Corolla years
Frequently asked questions
How common are fuel system problems on the 2018 Toyota Corolla?
NHTSA has 38 complaints about the fuel & propulsion system of the 2018 Toyota Corolla, 28% of the model year's 135 complaints.
Is there a recall for 2018 Toyota Corolla fuel system problems?
Yes — NHTSA recall 20V-012 (fuel pump, Jan 13, 2020). Recall repairs are free at authorized dealers.
At what mileage do 2018 Toyota Corolla fuel system problems start?
Half of the complaints with a recorded mileage happened before about 19,000 miles, and 60% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 2 fires and 1 injury to fuel & propulsion system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.