Which parts fail
Components named in complaints (fuel pump, injectors, fuel tank, hybrid and EV propulsion).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2007 Suzuki XL7 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2007 Suzuki XL7. The contact stated that the vehicle was taken to the dealer after she discovered that the VIN was included in NHTSA Campaign Number: 12V597000 (Fuel System, Gasoline). The contact stated that after the vehicle was retrieved from the dealer and the recall was presumably completed, the vehicle was driven to the residence and parked. The contact then stated on the same day while driving at an undisclosed speed, there was an abnormal fuel odor throughout the cabin of the vehicle before the vehicle stalled. The vehicle was towed back to the residence. The contact then notified the dealer of the failure, but the contact was denied service. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the crank shaft position sensor was faulty. …
The contact owns a 2007 Suzuki XL7. The contact stated while approaching the vehicle, the contact became aware of gasoline fumes outside of the vehicle. Additionally, while attempting to start the vehicle, several attempts were needed to start the vehicle. The contact took the vehicle to an independent mechanic to be diagnosed. The contact stated that the failure was with the pressure line attached to the fuel pump which leaked and cracked. The mechanic installed a seal into the crack of the fuel pump to temporarily repair the failure. The mechanic recommended that the fuel pump be replaced. The vehicle was not yet repaired. The manufacture was not made aware of the failure. The approximate failure mileage was 194,000.
On my Suzuki XL-7, I have 2 recalls: 1. Fuel pump 2. Windshield clamp. I'm trying to find a dealer to repair the recalls? Can you provide to me any Phoenix area dealer that can fix these two recalls? Thanks.
This vehicle should be recalled. It is a lemon!! I bought my Suzuki 2 years ago used and have had nothing but problems. I have had the timing chain replaced. After I get gas it sputters and struggles starting. The traction control light comes on and the engine power is reduced. Eventually it just stops running. I could not drive my Suzuki most of the winter because of that and no one knows how to fix it. The sunroof and windshield leak. I have had a mechanic look at it a couple of times and it is still leaking. The passenger air bag light doesn't work. The turn signal doesn't work. Now my speedometer stopped working. It is stuck at 80 when it is parked and then goes up from there when I am driving it. Who knows what else is going to stop working. I am so frustrated, there are too many problems with this vehicle. It is unsafe!
Tl* the contact owns a 2007 Suzuki XL7. The contact stated that the vehicle would not hold any fuel and her husband noticed that the fuel pump had melted. The contact stated that the vehicle exhibited the same symptoms as listed in NHTSA campaign number: 12V597000 (fuel system, gasoline). The vehicle was taken to bob tyler Toyota (7201 pensacola blvd, pensacola, fl 32505, [phone]) where it was diagnosed that the fuel pump was fractured. The vehicle was not repaired. The manufacturer was notified and stated that they would not be held accountable. The failure mileage was unknown.
Tl* the contact owns a 2007 Suzuki XL7. While driving various speeds, the vehicle shook and a strong fuel odor emitted in and around the vehicle. In addition, after fueling the vehicle, it failed to start and the engine made a loud noise and failed to accelerate over 15 MPH. The vehicle was taken to an independent mechanic, but was not diagnosed or repaired. The vehicle was previously repaired a recall for the fuel system, gasoline. The manufacturer was made aware of the failure. The NHTSA campaign number was unknown. The approximate failure mileage was 170,000.
Tl* the contact owns a 2007 Suzuki XL7. The contact stated that he became aware that the fuel pump was leaking fuel nearby the rear passenger's side tire. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic and he was informed that the fuel pump needed to be replaced. The vehicle was not yet diagnosed nor repaired. A dealer was not contacted. The manufacturer was informed of the failure. The failure mileage was approximately 223,000.
Tl* the contact owns a 2007 Suzuki XL7. After refueling the vehicle, it would not immediately restart. The accelerator pedal had to be depressed several times before the engine would start. The vehicle was taken to an independent mechanic who diagnosed that the fuel pressure regulator was faulty. The vehicle was not repaired. The manufacturer and local dealer were not notified of the failure. The failure mileage was 151,000.
Tl* the contact owns a 2007 Suzuki XL7. While the vehicle was having the tires rotated by an independent mechanic, a crack in the fuel tank and a slow leak were discovered. The mechanic stated that the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 80,000.
Tl* the contact owns a 2007 Suzuki XL7. While driving at various speeds, there was an odor of fuel present inside the cabin of the vehicle. The contact stated that the failure was intermittent. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 95,000.
Related recalls
Fuel system, gasoline › Delivery › Fuel pump
American Suzuki is recalling certain model year 2007 XL-7 vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; and manufactured June 13, 2006, through December 22, 2006.
Remedy: American Suzuki will notify owners, and dealers will replace the fuel pump module, free of charge. An interim letter was mailed on March 7, 2013. Owners may contact American Suzuki Customer Relations at 1-800-934-0934.
Fuel System complaints in other XL7 years
Frequently asked questions
How common are fuel system problems on the 2007 Suzuki XL7?
NHTSA has 31 complaints about the fuel & propulsion system of the 2007 Suzuki XL7, 22% of the model year's 138 complaints. The component named most often is delivery › fuel pump (1 mentions).
Is there a recall for 2007 Suzuki XL7 fuel system problems?
Yes — NHTSA recall 12V-597 (fuel pump, Dec 20, 2012). Recall repairs are free at authorized dealers.
At what mileage do 2007 Suzuki XL7 fuel system problems start?
Half of the complaints with a recorded mileage happened before about 115,000 miles, and 15% before 25,000 miles.
Is it dangerous?
Owners linked 0 crashes, 1 fire and 0 injuries to fuel & propulsion system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.