Most common 2007 Suzuki XL7 problems
Share of the 138 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Suzuki XL7 complaints by model year
Best XL7 years: 2009. Years to avoid: 2007. Compare all years →
2007 Suzuki XL7 recalls (2)
Fuel system, gasoline › Delivery › Fuel pump
American Suzuki is recalling certain model year 2007 XL-7 vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; and manufactured June 13, 2006, through December 22, 2006.
Remedy: American Suzuki will notify owners, and dealers will replace the fuel pump module, free of charge. An interim letter was mailed on March 7, 2013. Owners may contact American Suzuki Customer Relations at 1-800-934-0934.
Visibility › Windshield
Certain vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 212, "windshield mounting." an incorrect primer May have been used when installing the windshield.
Remedy: Dealers will inspect and replace any glass (windshield, liftgate glass, or the side stationary glass) that was installed incorrectly.the recall began on July 10, 2007. Owners May contact Suzuki at 1-800-934-0934.
What 2007 Suzuki XL7 owners say
Fuel & propulsion system all 31 →
The contact owns a 2007 Suzuki XL7. The contact stated that the vehicle was taken to the dealer after she discovered that the VIN was included in NHTSA Campaign Number: 12V597000 (Fuel System, Gasoline). The contact stated that after the vehicle was retrieved from the dealer and the recall was presumably completed, the vehicle was driven to the residence and parked. The contact then stated on the same day while driving at an undisclosed speed, there was an abnormal fuel odor throughout the cabin of the vehicle before the vehicle stalled. The vehicle was towed back to the residence. The contact then notified the dealer of the failure, but the contact was denied service. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the crank shaft position sensor was faulty. …
The contact owns a 2007 Suzuki XL7. The contact stated while approaching the vehicle, the contact became aware of gasoline fumes outside of the vehicle. Additionally, while attempting to start the vehicle, several attempts were needed to start the vehicle. The contact took the vehicle to an independent mechanic to be diagnosed. The contact stated that the failure was with the pressure line attached to the fuel pump which leaked and cracked. The mechanic installed a seal into the crack of the fuel pump to temporarily repair the failure. The mechanic recommended that the fuel pump be replaced. The vehicle was not yet repaired. The manufacture was not made aware of the failure. The approximate failure mileage was 194,000.
Engine & cooling all 29 →
I have a check engine light that has come on. I took the car back to where I purchased the vehicle, they tell me it is too bad. That the car was sold as is. I take the car to a local mechanic who says that I need to have the timing chain and tensioner replaced. It will cost $600 plus parts to repair. My vehicle has 116xxx miles. There is paint chipping, and my instrument cluster is showing the temp gauge on hot and rests in the middle position after sitting over night. A class action lawsuit against Suzuki should be considered, because the number of complaints for this issue, and there has not been a recall, is outrageous. This is a 3 day repair job at minimum. Suzuki knew this was an issue, they should show some morality and ethics as to offer their consumers a remedy to this issue. Something needs to be done to rectify this problem. Before an accident or loss of life happens.
I just purchased this vehicle 9 days ago and took it through inspectin today. It failed due to the codes p0008,p0009,p0018,p0017,p0016 which are the timing chains and twin cam position sensors. The repair to the vehicle is $1500.00 or more due to the extent of the procedure for the repair. I was told that this expense is my cost even though I only had the vehicle 9 days. This is an on going issue I have noticed with all these vehicles within the year of 2007. Suzuki told me that it is not in the man. Warranty anymore due to the miles. I really need help there is not even a recall for this issue.
Air bags all 28 →
This vehicle should be recalled. It is a lemon!! I bought my Suzuki 2 years ago used and have had nothing but problems. I have had the timing chain replaced. After I get gas it sputters and struggles starting. The traction control light comes on and the engine power is reduced. Eventually it just stops running. I could not drive my Suzuki most of the winter because of that and no one knows how to fix it. The sunroof and windshield leak. I have had a mechanic look at it a couple of times and it is still leaking. The passenger air bag light doesn't work. The turn signal doesn't work. Now my speedometer stopped working. It is stuck at 80 when it is parked and then goes up from there when I am driving it. Who knows what else is going to stop working. I am so frustrated, there are too many problems with this vehicle. It is unsafe!
Tl* the contact owns a 2007 Suzuki XL7. While driving at various speeds, the passenger side air bag warning indicator illuminated on the instrument panel. The contact stated that the failure would occur intermittently. The vehicle was taken to an independent mechanic where it was diagnosed that the flexibility of the sensor would make the sensor read the passenger's weight intermittently. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 125,225.
2007 Suzuki XL7 engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 3.6L 6-cyl | 5-speed automatic | FWD | 16 / 22 / 18 |
| 3.6L 6-cyl | 5-speed automatic | 4WD/AWD | 16 / 21 / 18 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2007 Suzuki XL7 a good car?
Based on 138 owner complaints filed with NHTSA, the 2007 XL7 rates avoid: 3.0× as many complaints as a typical year of the XL7 at the same age. It is one of the XL7 years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2007 Suzuki XL7?
The fuel & propulsion system — 31 complaints, 22% of all complaints for this model year, most often about delivery › fuel pump. Next are the engine & cooling (29) and air bags (28).
How many recalls does the 2007 Suzuki XL7 have?
There are 2 recalls for the 2007 Suzuki XL7, the most recent from December 20, 2012 (fuel pump). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Suzuki XL7?
The best years by complaints, compared at the same age, are 2009. Years to avoid or approach with caution: 2007. See the full Suzuki XL7 years comparison.
At what mileage do 2007 Suzuki XL7 problems happen?
The median mileage reported in complaints is about 74,000 miles; 28% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.