2012 Jeep Patriot Fuel System Problems

Which parts fail

• Storage › Fuel gauge system
  1
• Storage › Tank assembly
  1

Components named in complaints (fuel pump, injectors, fuel tank, hybrid and EV propulsion).

Mileage when the problem started

• Under 25k
  1826%
• 25k–50k
  1522%
• 50k–75k
  1522%
• 75k–100k
  1319%
• 100k–150k
  710%
• 150k+
  11%

Owner reports

Selected complaints filed with NHTSA by 2012 Jeep Patriot owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2012 Jeep Patriot. The contact stated that while his son was attempting to refuel the vehicle, the fuel tank was inoperable. The vehicle was taken to the dealer and diagnosed with a cracked roll-over valve. The roll-over valve needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that the VIN was not included in a recall. The contact related the failure to NHTSA Campaign Number: 12V142000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The failure mileage was approximately 44,500.

The contact owns a 2012 Jeep Patriot. The contact stated that while attempting to refuel the vehicle, fuel was pouring from the fuel tank. There were no warning lights illuminated. The local dealer was not contacted or notified of the failure. The vehicle was not diagnosed or repaired. The contact stated the failure was related to NHTSA Campaign Number: 12V142000 (Fuel System, Gasoline). The failure mileage was approximately 65,000.

The contact owns a 2012 Jeep Patriot. The contact stated that on several occasions, while attempting to refuel the vehicle, the gas pump shut off and only worked manually. The vehicle was taken to an independent mechanic for diagnosis, and it was determined that the fuel tank needed to be replaced due to a faulty fuel tank rollover valve. The manufacturer was notified of the failure. The failure mileage was 101,000.

Unknown: Something is wrong with the gas tank. When refueling, it's nearly impossible to activate the latch on the pump handle without the pump immediately stopping. To refuel, I have to gently squeeze the trigger to enable a very slow flow of fuel. To fill the tank, while gently activating the trigger, takes approximately 15-20 minutes. In the past, you could depress the trigger and activate the locking catch and fill up in 3-4 minutes depending on the pressure of the gas station system. I don't know if this issue points to a safety problem, however, clearly it's a defect. I consulted the Jeep dealership and they recommended to not fully insert the nozzle into the filler neck of the tank. It was a bizarre recommendation because it was never an issue in the past. Of course I tried their recommendation an as expected it made no difference. …

Can't pump gas without it shutting off within seconds of trying to auto click handle. It is taking average 15-25 minutes to pump a tank of gas. It is BY PASSING the auto shut off so gas could spew out of tank when full. This is happening every week when I go get gas, estimate 4 months now. Doesn't matter if cold or hot outside but I am already tired of holding handle trying to get gas in the tank. I read that Chrysler is looking at 2011-2012 models due to the gas tank is split and has valve line that is defective. I have to turn ignition key on so I can see when I put enough gas in vehicle multiple times to get a full tank. I am the original owner. No warning messages that alert for condition. This is unsafe.

My fuel tank problem should be included in the Safety Recall M11/NHTSA 12V-142 Fuel Tank Roll-Over value..I have taken my car to several Jeep dealers and have been informed the problem with this tank falls in the recall...I have been dealing with this problem for years....I recently found out that the problem falls in the recall above...I took my car to the Jeep dealer, Pelegr no in Woodbury,NJ on 5/19/21 for the problem..They informed me tank would have to be removed to be fixed...they never informed me that there was a recall...so I did not get it fixed at the time. I have been dealing with this problem since 2018

I have a problem fueling my 2012 Jeep Patriot. I have to dribble the gas into neck to prevent gas from blowing out of neck. My mechanic replaced neck. Still have the same problem. I have read of a recall due to valve inside tank sticking which could cause fuel to pour out if a rollover occurs but I'm hearing from mechanic that the problem with valve sticking is why I'm having a problem refueling. If both issues are due to the same valve problem, shouldn't the recall cover my jeep? I have had my jeep to my mechanic 3 times now for this issue in the past month. I have also had my jeep stall if I accelerate quickly.

I cannot put gas in my car, continuously shuts off and spits fuel back out like its full. It takes about 20 minutes to get enough gas in it to feel like I can drive a little distance without worrying I will run out since It always acts as if its full. It also seems as if it wants to stall out at times and I just give it more gas. I have had this car for a few months now and Im scared its going to stall and cause an accident. Having a difficult time with getting someone to work on it, codes will not diagnose. After reading I saw this had recalls in the past. Should this car have been recalled?

When filling the tank with gas and then driving the vehicle, the vehicle either stalls, bucks really bad, or hesitates when accelerating. There is a heavy smell of gas. This unsafe condition has been traced to a faulty fuel tank valve that requires the entire fuel tank to be replaced ($1,000- $1,800). Others have experienced fuel being spewed out suddenly when refueling very slowly due to this same faulty valve. Any fuel system issue puts the vehicle at risk of fire, which is risks my life and my family's life.

Fueling vehicle takes upwards of 15-20 minutes. I am worried it may have something to do with recall 12V142000 along with recall 13V120000. Which are both hazardous to the driver and passenger being that one may cause an accident and the other may result in death of the occupants.

Related recalls

NHTSA investigations

Fuel System complaints in other Patriot years