Most common 2016 Hyundai Sonata Hybrid problems
Share of the 133 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Hyundai Sonata Hybrid complaints by model year
Best Sonata Hybrid years: 2019, 2018, 2014. Years to avoid: 2021, 2016, 2012. Compare all years →
2016 Hyundai Sonata Hybrid recalls (5)
Electrical system › Software
Hyundai Motor America (Hyundai) is recalling certain 2015-2017 Sonata, 2016-2017 Sonata Hybrid, and Sonata Plug-In Hybrid vehicles. The Smart Junction Box (SJB) software logic may not properly interpret the signals received from the multifunction switch, which could cause the turn signal to activate in the opposite direction of…
Remedy: Dealers will update the SJB software, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 210.
Latches/locks/linkages › Trunk lid › Latch
Hyundai Motor America (Hyundai) is recalling certain 2017-2018 Sonata, 2016-2018 Sonata Hybrid, 2018-2020 Accent, and 2016-2017 Azera vehicles. The trunk latch may become damaged, preventing the opening of the trunk from the inside.
Remedy: Dealers will replace the trunk latch base, free of charge. Owner notification letters were mailed December 4, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 208.
Engine
Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Veloster, 2012 Santa Fe, 2011-2013 Sonata Hybrid, and 2016 Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage.
Remedy: Hyundai will notify owners, and dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System…
Visibility › Sun/moon roof assembly
Hyundai Motor America (Hyundai) is recalling certain model year 2015-2016 Sonata Hybrid vehicles manufactured December 8, 2014, to August 18, 2015, and Hyundai Sonata vehicles manufactured May 28, 2014, to March 18, 2016, equipped with the panoramic sunroof option.
Remedy: Hyundai will notify owners, and dealers will repair the wind deflector anchor plate, free of charge. The recall began December 2016. Owners may contact Hyundai customer service at 1-800-633-5151.
Air bags › Frontal
Hyundai Motor Company (Hyundai) is recalling certain model year 2015-2016 Sonata vehicles manufactured May 29, 2014 to February 11, 2016, 2017 Elantra vehicles manufactured January 12, 2016 to February 22, 2016, and one 2016 Sonata Hybrid vehicle manufactured October 15, 2015.
Remedy: Hyundai will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began on May 5,2016. Owners may contact Hyundai customer service at 1-855-371-9460.
NHTSA defect investigations
Federal safety investigators have looked into 4 possible defects involving the 2016 Hyundai Sonata Hybrid:
Engine Fires
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles.
Electrical overstress
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events.
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles.
Loss of Motive Power
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021.
What 2016 Hyundai Sonata Hybrid owners say
Engine & cooling all 76 →
The contact owns a 2016 Hyundai Sonata. The contact stated that while the daughter was driving approximately 55 mph smoke was suddenly present coming from under the hood before the engine failed and the vehicle stalled. The vehicle was towed to the local dealer who diagnosed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 140,000.
The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated while driving 50 MPH, the vehicle started to violently shake and lose power while being powered by the engine. The contact stated the accelerator pedal was released and the shaking stopped as the vehicle switched to being powered by the battery. The contact stated as the vehicle was a hybrid vehicle the switch between using the engine and battery was done automatically when the accelerator pedal was released. The contact also stated that an abnormal noise was coming from the engine compartment when the vehicle was started. The check engine warning light was illuminated. The vehicle was taken to the dealer where the failure was diagnosed as an engine misfire and that the coils needed to be replaced. The vehicle was repaired; however, the failure continued as soon as the vehicle was picked up from the dealer. …
Electrical system all 36 →
The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated that while driving at approximately 60 MPH, the brake pedal was depressed and failed to respond. The "Stop Car, Check Brakes" message was displayed. The ABS and traction control warning lights were illuminated. The contact pulled over and turned off the vehicle, and stated that after restarting the vehicle, the warning lights were no longer illuminated. The vehicle was taken to a local dealer where it was diagnosed and serviced under NHTSA Campaign Number: 20V746000 (Engine) and 21V749000 (Exterior Lighting, Electrical System). The vehicle was repaired; however, the failure reoccurred intermittently. The vehicle was then taken to Homestead Hyundai (111 S Homestead Blvd, Homestead, FL 33030) where it was diagnosed that the power brake booster and rear wheel speed sensors needed to be replaced. …
The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, and the message "Warning - Do not Attempt to Restart" was displayed. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure of the engine wiring harness. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the dealer and was diagnosed as a failure with the engine wiring harness. The vehicle was not repaired. The vehicle had been back to the dealer several times. Recently, the contact was informed that the wiring harness was soy-based insulated, and rodents were causing damage to the wiring harness due to the smell. The manufacturer was notified of the failure but provided no assistance. …
Transmission & drivetrain
The parking mechanism in the transmission failed. The car was parked in my garage . The lever was in the "Park" position when the car drove backwards out of my garage and crashed into the fence. It continued driving into the street and into the neighbors yard. Two people were out walking and saw it happen. I know I did not leave my car in neutral or reverse when I parked it in my garage. When I tested this later sitting in my car, in my garage, the car immediately began moving backwards instantly, while i was still at the wheel. Had the car been in neutral or reverse at the time this incident occurred, I would have known it was moving immediately and shifted it into park right away. When this incident happened I put the car into park, and I got out of my car , I got things from my trunk and went inside the house. Then I went back to the car to get more things. …
Vehicle Impact:While driving, the vehicle suddenly displayed a "Check Hybrid System" warning on the dashboard and suffered a complete, sudden loss of propulsion while on the road. The vehicle dropped power completely and would not restart, creating an immediate, severe safety hazard to myself and surrounding traffic.Diagnostic & Component Confirmation:The vehicle was towed to a certified Hyundai dealership (Hyundai of Goshen, Repair Order #6080674). Diagnostic testing confirmed trouble codes P0717 (Input Speed Sensor No Signal) and P0A40 (Drive Motor Position Sensor).The dealership's certified technician explicitly documented that they "followed TSB and found input speed sensor valve body harness is faulty due to heavy corrosion on the sensor connector."Safety Hazard Summary:This is a critical manufacturing and sealing defect where an internal, non-wear component (the transmission valve …
2016 Hyundai Sonata Hybrid engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.0L 4-cyl hybrid | 6-speed dual-clutch | FWD | 38 / 41 / 40 |
EPA ratings. Class: Midsize car.
Frequently asked questions
Is the 2016 Hyundai Sonata Hybrid a good car?
Based on 133 owner complaints filed with NHTSA, the 2016 Sonata Hybrid rates use caution: 1.6× as many complaints as a typical year of the Sonata Hybrid at the same age. It is one of the Sonata Hybrid years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2016 Hyundai Sonata Hybrid?
The engine & cooling — 76 complaints, 57% of all complaints for this model year, most often about exhaust system › emission control › catalytic convertor. Next are the electrical system (36) and transmission & drivetrain (14).
How many recalls does the 2016 Hyundai Sonata Hybrid have?
There are 5 recalls for the 2016 Hyundai Sonata Hybrid, the most recent from September 24, 2021 (software). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Hyundai Sonata Hybrid?
The best years by complaints, compared at the same age, are 2019, 2018 and 2014. Years to avoid or approach with caution: 2021, 2016 and 2012. See the full Hyundai Sonata Hybrid years comparison.
At what mileage do 2016 Hyundai Sonata Hybrid problems happen?
The median mileage reported in complaints is about 66,000 miles; 41% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.