Most common 2012 Hyundai Sonata Hybrid problems
Share of the 154 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Hyundai Sonata Hybrid complaints by model year
Best Sonata Hybrid years: 2019, 2018, 2014. Years to avoid: 2021, 2016, 2012. Compare all years →
2012 Hyundai Sonata Hybrid recalls (6)
Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge.
Engine
Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Veloster, 2012 Santa Fe, 2011-2013 Sonata Hybrid, and 2016 Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage.
Remedy: Hyundai will notify owners, and dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System…
Equipment › Electrical
Hyundai Motor America (Hyundai) is recalling certain 2011-2012 Hyundai Elantra and Sonata Hybrid, 2012 Accent and Veloster vehicles. The 12V accessory socket outlet may have been over-tightened during installation, possibly disabling the thermal fuse and allowing the outlet to overheat with prolonged use, such as by using the…
Remedy: Hyundai will notify owners, and dealers will replace the Tire Mobility Kit accessory outlet plug with a direct-to-battery connection wire harness kit, free of charge. The recall began September 28, 2020.
Air bags › Air bag/restraint control module
Hyundai Motor America (Hyundai) is recalling certain 2011-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. On February 27, 2018, Hyundai Motor Company (Hyundai) notified NHTSA that they were recalling 154,753 model year 2011 Sonata vehicles.
Remedy: Hyundai will notify owners, and dealers will install an external wire filter kit, free of charge. The recall began October 15, 2018. Owners may contact Hyundai customer service at 1-855-371-9460.
Seat belts › Pretensioner
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
Remedy: Hyundai will notify owners, and dealers will again verify the connection between the seat belt linkage and the pretensioner and additionally install a warning label to prevent future seat belt linkage detachment, free…
Seat belts › Front › Anchorage
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
Remedy: Hyundai will notify owners and dealers will inspect the connection between the seat belt linkages and the seat belt anchor pretensioners, repairing them as necessary, free of charge.
NHTSA defect investigations
Federal safety investigators have looked into 7 possible defects involving the 2012 Hyundai Sonata Hybrid:
Non-crash Vehicle Fires
During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Hyundai Sonata and Santa Fe vehicles equipped with Theta II and Lambda II engines (approximately 1.3 million vehicles).
Air bags may be disabled during crash
The Office of Defects Investigation (ODI) opened PE18-003 on 3/16/18 to investigate incidents involving crashes, resulting in significant collision related damage, where the frontal airbags failed to deploy. ODI reviewed complaint data, available design, test, and field data on the model year (MY) 2011 Hyundai Sonata, MY 2012-2013 Kia Forte and Forte Koup vehicles.
Engine Fires
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles.
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles.
Loss of Motive Power
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021.
Non-crash Vehicle Fires
In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehicles. In a letter dated July 24, 2018, CAS requested that MY 2010-2015 Kia Soul vehicles be added to the petition.
Hyundai and Kia ABS Module Fires
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando.
What 2012 Hyundai Sonata Hybrid owners say
Engine & cooling all 70 →
The contact owned a 2012 Hyundai Sonata. The contact stated that while driving at 75 MPH on the highway, while depressing the accelerator pedal, the vehicle failed to accelerate. No warning lights illuminated. The contact veered over to the right side of the road, turned the vehicle off, and she noticed smoke coming from the engine. A bystander behind her noticed the flames coming up from the engine. The contact mentioned she exited the vehicle and called 911. No injuries were sustained. No medical attention was required. A police report was filed. The fire department extinguished the fire. The vehicle was destroyed. The vehicle was towed to Atow lot. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 160,000.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving at various speeds, the vehicle slowly start to lose motive power. There was smoke coming from the engine compartment. The contact stated that the check engine warning light was illuminated. The contact then received notification of NHTSA campaign number: 20V746000 (Engine). The vehicle was then taken to the local dealer where it was diagnosed with the engine needing to be replaced. The dealer stated that they could not service the recall until the engine had failed. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 72,000.
Transmission & drivetrain all 30 →
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed and attempting to accelerate up a hill, the vehicle inadvertently lost motive power. Several attempts to restart and jumpstart the vehicle failed. The hybrid system warning light was illuminated on the instrument panel. The vehicle was towed to the residence and later towed to an independent mechanic, who determined that the engine had failed due to metal shavings in the engine oil. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 20V746000 (Engine) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 55,000.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving at various speeds, the vehicle hesitated and stalled while depressing the accelerator pedal. There was no warning light illuminated. The contact had taken the vehicle to multiple independent mechanics who were all unable to diagnose the failure due to no warning lights illuminating on the instrument panel. The contact then had the vehicle towed to the dealer where the mechanic was also unable to diagnose the failure. The mechanic informed her that the transmission needed to be replaced. The vehicle was not repaired. The failure mileage was approximately 130,000.
Brakes all 25 →
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the Check Brakes and Hybrid System Warning: Safely Stop and Do Not Drive messages were displayed. The brakes then made a grinding sound while the brake pedal was depressed. Additionally, the vehicle lost motive power while driving. The contact pulled over and restarted the vehicle. The vehicle was taken to the dealer, where it was diagnosed with a faulty HCU (Hybrid Control Unit) and AHB (Active Hydraulic Boost). The dealer retrieved DTC Codes: P1886 (Inappropriate and Low SOC) and C1237: (Primary Pressure Sensor Signal). The dealer replaced the oil valve gasket and recalibrated the brakes. …
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. Additionally, the ABS warning light was illuminated. The contact stated that the vehicle had to be turned off and restarted every ten minutes. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that the vehicle was recently serviced by the dealer and NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) was completed. The contact stated that the failure was present prior to the recall repair being performed. In addition, the contact stated that the failure reoccurred a week after the recall repair was completed. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.
2012 Hyundai Sonata Hybrid engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.4L 4-cyl hybrid | 6-speed automatic | FWD | 34 / 39 / 36 |
EPA ratings. Class: Midsize car.
Frequently asked questions
Is the 2012 Hyundai Sonata Hybrid a good car?
Based on 154 owner complaints filed with NHTSA, the 2012 Sonata Hybrid rates use caution: 1.5× as many complaints as a typical year of the Sonata Hybrid at the same age. It is one of the Sonata Hybrid years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2012 Hyundai Sonata Hybrid?
The engine & cooling — 70 complaints, 45% of all complaints for this model year, most often about exhaust system › emission control › catalytic convertor. Next are the transmission & drivetrain (30) and brakes (25).
How many recalls does the 2012 Hyundai Sonata Hybrid have?
There are 6 recalls for the 2012 Hyundai Sonata Hybrid, the most recent from September 22, 2023 (control unit/module). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Hyundai Sonata Hybrid?
The best years by complaints, compared at the same age, are 2019, 2018 and 2014. Years to avoid or approach with caution: 2021, 2016 and 2012. See the full Hyundai Sonata Hybrid years comparison.
At what mileage do 2012 Hyundai Sonata Hybrid problems happen?
The median mileage reported in complaints is about 77,000 miles; 27% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.