2023 Hyundai Santa Cruz Engine Problems

Mileage when the problem started

Owner reports

Selected complaints filed with NHTSA by 2023 Hyundai Santa Cruz owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2023 Hyundai Santa Cruz. The contact stated while slowing down at approximately 25 MPH, the vehicle downshifted roughly and would jolt while shifting into gear. The contact stated that the failure had been occurring intermittently. Additionally, the contact stated that the RPMs would remain high while he was at a complete stop. The contact stated that the RPMs would rise above 3,000 RPM while depressing the brake pedal, and he would turn the vehicle off to stop the engine from revving. There was no warning light illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed that the throttle body needed to be replaced. The part was replaced; however, the failure persisted. The vehicle was taken back to the same dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 4,000. …

The contact owns a 2023 Hyundai Santa Cruz. The contact stated while driving approximately 65 MPH with the cruise control engaged, the vehicle started losing motive power. The contact stated that the check engine warning light was illuminated. The contact stated that the vehicle slowed to approximately 15 MPH while depressing the accelerator pedal and failed to respond as needed. The contact was able to drive the vehicle to the residence. The contact turned off the vehicle and attempted to restart the vehicle; however, the vehicle failed to restart. The contact had the vehicle towed to a dealer who diagnosed the vehicle and determined that a fuel injector had failed and needed to be replaced. The vehicle was repaired. The manufacturer was not informed of the failure. The failure mileage was 13,803.

On [redacted], I went out to start my 2023 Hyundai Santa Cruz (SC) to leave work to go home. It was difficult to start, however, it started. As I entered [redacted] , i was nearly rear ended by another car, because my SC lost all acceleration. I turned on my hazards for SAFETY and then began to try to accelerate again and was only able to get up to 45 MPH and then was turning 4,000 RPM. I limped my SC home where I had it towed to a local Hyundai dealer as it has roughly 38,000 miles. The dealership had it for 3 days, but couldn't duplicate the issue, so no repairs were done. The Hyundai Santa Cruz has KNOWN transmission issues and the fact I was nearly rear ended could've caused a nasty wreck, resulting in more damage or even a fatality. I reported the issue to Hyundai customer service on the 11th of September (Case #[redacted]). …

On 3 separate occasions this has occurred . When accelerating, the engine or power train completely loses all propulsion. Twice I was starting a left hand turn and crossing oncoming traffic. On one occasion I was turning right onto a 50 MPH highway and quickly veered off the road onto the berm. The only item on dash board flashing on the third incident was the cruise control preset and it was flashing 20. At the time I was not using the cruise control and I did not set it for 20. No dash board warning lights lit during the first two losses of power. I reported it to the dealer. Today I had a maintenance appointment and inspection at the dealer. After that inspection, they informed me that they found no codes to identify the issue. I should let them know if it continues. My 3 failures happened at approximately 10,000, 15,000 and 20,000 miles. …

The car has 1,360 miles and is only a month old since I bought it. Car sat for 8 hours at my work parking lot. When I went to start it it ran rough like an engine misfire for about 10 seconds then normal. When I drove off with engine cold... the transmission would not shift up and was at 4,000 rpms. The accelerator pedal was not responsive.. even flooring it yielded no acceleration and the car would not go over 25mph. No check engine lights or trouble lights. I was able to put the automatic into paddle shift mode but the car still did not want to accelerate and when it did it seemed to get stuck at 3500-4000 rpm and no accelerator input. Shut the car off then back on again after I pulled over because the car would not accelerate. - now it is fine with no issues it seems like. Took to the dealer and they could not recreate the issue .. …

Car will not start properly and shuts itself off after which a strong odor of burning plastic is present in the vehicle. It will periodically do this almost once a day if not every other day. I have taken it in to the dealer 4 times last time they had my car for two weeks and could not replicate porblem because they only drive it 5 miles and it will not happen unless vehicle is being daily driven. I have found numerous other owners with the same complaint. Hyundai will not authorize shop to work on car and advises them to release it to me each time. They only attempted to fix once and gave it back to me all over times. The car is at the dealer again and they will not work on it till october to try to find the problem again. …

My issue was that I would press the gas pedal, but once I got to 20 mph the engine would stop giving power and I couldn't get up to speed. My top speed was 30 mph, even though I would give it gas to speed up. This was the worst after I would come to a stop at a traffic light. As I pressed the gas to gain speed, it would struggle to gain speed in the middle of the intersection, causing the cars behind me to be frustrated and aggressively tailgate. I was able to find a parking lot, parked and turned the car off for approximately 20 minutes. After that I turned the car back on, I went for a test drive and there was no problem at all. When this all happened no warning lights came on. Very concerned that this will happen again, as I have no clue what triggered this incident. I have reported this to my dealer, but as this just happened today nothing has been inspected.

Coolant leaking onto engine shield and ground from front a small rock that hit of vehicle radiator. The radiator is not nearly shielded well enough to protect it from rocks and other debris. A 1/4 inch diameter rock struck the front of radiator through grill opening resulting in a leak and possible risk of overheating the engine. The radiator tube size is also made of extremely insufficient material to withstand any impacts. Hyundai dealer and corporate at this time refuse to take any responsibility for this issue and will not warranty the replacement. The car is a 3 month old 2023 Santa Cruz Limited with just over 3,000 miles on it. This is an extremely common issue with a quick google search of the 2022-2023 Santa Cruz.

oil leak the oil leak has be too the dealer twice for repair each time they said it was fixed it has now has happend again for the third time in less than 306 miles could cause engine failure at highway speed and engine lockup at such speed first time it was found by dealer after third oil change approx. 15000 miles second 12000 miles later and now 306 miles latter with this time the leak was larger to to the fact that it triggerd the low oil light first two times it told to me it was oil pan gasket and a small leak which at the time made sense it not show up on the dipstick i know this was da problem on other Hyundai santa cruz models in previous years0

My coolant reservoir was so low that there was less than 8oz of coolant left in the tank. I contacted my local Hyundai dealership and had them service my Santa Cruz. The service techs at the dealership told me that there was a known issue with some of the factory coolant reservoir caps and the seal not working correctly, thus causing coolant to flow out through the cap instead of the overflow hose. They explained that the cap's o-ring at the factory is sometimes faulty. They replaced my cap and I am still monitoring for further issues. There is no TSB listed for this "known" issue. It seems that the dealership has not reported this issue.

Engine complaints in other Santa Cruz years