2024 Hyundai Palisade Engine Problems

Owner reports

Selected complaints filed with NHTSA by 2024 Hyundai Palisade owners, lightly cleaned up (personal details are redacted by NHTSA).

Engine fire caused by AC compressor. On 09/28/24, at 1700 miles and in the parking lot of a restaurant, smoke suddenly began filling the cabin and when I looked out the window the entire car's front was engulfed in a gray smoke. The overpowering smell was of burning wire insulation, plastic, and rubber. I immediately shut the car off, popped the hood, and was ready to run into the restaurant for a fire extinguisher when I noticed the large cloud of smoke was dissipating, but the heat was still incredibly extreme and a good amount of smoke was still pouring from the engine. My sister-in-law entered the car to retrieve her purse, and her eyes instantly started watering and she had a headache for several days. She is still complaining of her chest burning. After calling roadside, the AAA driver stated the car really smelled badly burned, and hauled the car off to the dealer of purchase. …

1. The exact component that failed is unknown at this time. The fire appeared to originate in the driver-side front area of the engine compartment near the headlight. Prior to the fire the vehicle experienced engine shaking and a check engine light. The vehicle has been towed to a Hyundai dealership and is available for inspection by insurance investigators, the manufacturer, or safety investigators upon request. 2. The vehicle caught fire while it was being operated on a public roadway shortly after leaving our residence. Flames were visible from the engine compartment within minutes of driving. This created an immediate safety risk to the occupants of the vehicle and to other motorists because the fire occurred suddenly while the vehicle was in motion. 3. The problem has not been reproduced. …

Component/System: Engine - specifically the engine valve springs and related components. Description of what happened: While driving, the vehicle began to shake violently, and the check engine light came on. At times, the vehicle loses power and shuts off completely, then restarts and drives normally for a short period before the issue returns. It feels and sounds like the engine is about to fall out. These symptoms match the description in Hyundai Safety Recall 255 for the 2024 Palisade (fractured engine valve springs that can cause engine failure, loss of power, and fire risk). Safety risk: The sudden loss of power and engine shaking put my safety and the safety of others at risk, especially while driving in traffic or at higher speeds. The problem could lead to a crash or engine fire if the valve springs fracture or the engine block is damaged. …

While driving on a high-speed interstate with two children in the vehicle, and without any prior warning signs or issues, the dashboard began displaying sequential warnings from multiple Advanced Driver Assistance Systems (ADAS) sensors. As the vehicle continued cycling through numerous dashboard warnings, the power steering failed, making the vehicle difficult to control. Additional electronic systems also began malfunctioning, including the display screen, cameras, and safety sensors, while the driver attempted to safely maneuver the vehicle to the shoulder of the road. After reaching the shoulder, the driver powered the vehicle off in an attempt to reset the electrical systems. However, once powered down, the engine would no longer start. When the tow truck arrived, the technician was required to jump-start the battery in order to shift the vehicle into neutral for towing. …

ALTERNATOR FAILURE: My family and I were moving to [redacted] from [redacted]. A few hours into the drive, the vehicle battery light came on. It was intermittent though. It would be on for a little while 10-15 mins and then shut off and then repeat this process. I stopped at an Autozone and they tested the battery and it was showing a charge of 7%. I could not afford to get stranded somewhere so I went ahead and had the battery replaced, even though I suspected the alternator was going bad. We continued on the trip, but the battery light continued to turn on and off. The vehicle ultimately began losing power about 2 hours after replacing the battery, causing all the warning lights on the dash to turn on, the main center console display lost power and then I lost power steering. All of this happened while I was on the interstate, putting myself and my family in serious danger. …

While driving the vehicle, the accelerator pedal was pressed but the vehicle failed to respond and did not accelerate, it simply rolled slowly as the engine continued to idle. The driver increased throttle input in an attempt to get the vehicle to accelerate. The vehicle continued to show no response to the additional throttle. After a delay, the vehicle suddenly resumed normal operation while the higher throttle input was still applied. This resulted in an abrupt and undesired surge of power. While this was occurring, another vehicle was rolling forward in preparation for a left turn. The other driver appeared confused by the Palisade's lack of acceleration (apparently believing it was yielding) and had not yet turned into the path of the Palisade. The sudden surge of power created a near-miss situation. …

On January 12, 2026, the vehicle shut off twice during the same trip while driving in traffic. All dashboard warning lights illuminated, the tachometer spiked, RPM readings did not correspond, the gear selector became unresponsive, and the vehicle lost propulsion while in motion. On February 15, 2026, the vehicle shut off again while driving under similar conditions. The vehicle was taken to a Hyundai dealership for diagnosis. The battery failed a load test and was replaced. According to the repair order narrative, after the battery replacement, the stall condition recurred during dealership testing. Multiple extended road tests and datalogging were later performed. The dealership has stated they are unable to re-replicate the condition and that no active diagnostic codes are present. The vehicle has experienced multiple loss-of-power events while in motion. …

Vehicle developed a check engine light and underwent warranty repair, during which all six fuel injectors were replaced (Repair Order #1HWS5031079, dated 7/8/2026, 33,768 miles). Despite this repair, the check engine light returned, and the vehicle subsequently developed an intermittent hard-start and no-start condition - in some instances the engine would not start on the first attempt and required a second attempt. The vehicle was returned to the dealership for a second repair visit (Repair Order #1HCS55031999, dated 7/28/2026, 34,090 miles), during which the dealership considered multiple possible causes, including a sensor issue and fuel-related concerns, before completing the repair. The vehicle was out of service for a cumulative total of approximately 22 days across both repair visits. …

Multiple problems since purchasing brand new 2024 Hyundai Palisade Calligraphy Edition last November. Within the first 2 weeks we experienced electrical problems and the entire dashboard add monitor had to be replaced. 2nd- recall on the engine and was replaced, recall issued in February and was never notified, only found out in August when taken in for complimentary service oil change. 3rd- engine light came on 1 week later. 4. Paint was damaged and mirror was cracked while at dealership. 5. Condensation in both headlights. 6. 2nd cracked windshield since purchase. 6. The driver side window does not roll up all the way. I absolutely do not feel safe in this car with my children and elderly parents. First and Last Hyundai. Nothing but constant problems. The dealership was fraudulent in the mileage the brand new car had- 500. Was not given any purchase paperwork and we paid cash for car.

After the "9C9" emissions recall update the vehicle randomly fails to respond to appropriately throttle input when attempting to accelerate into traffic. The issue is very intermittent - it may occur twice in 10 minutes or drive fine for hours. It has demonstrated both a "bucking" / stuttering / misfire feeling as well as a complete lack of any throttle response. After a few seconds of bucking, the vehicle returns to normal and accelerates smoothly with no change in throttle input. If the throttle failed to respond, pumping the pedal a few times has resumed normal operation. Situation has occurred multiple times since the update and has allowed the vehicle to roll into traffic without the ability to promptly accelerate to speed creating a safety hazard. There are no warning lights, and the dealership is unable to reproduce the issue.

Related recalls

Engine complaints in other Palisade years