2013 Hyundai Azera Brake Problems

Which parts fail

• Antilock/traction control/electronic limited slip › Control unit/module
  1

Components named in complaints (service brakes, ABS, rotors and pads, parking brake).

Mileage when the problem started

• Under 25k
  00%
• 25k–50k
  114%
• 50k–75k
  114%
• 75k–100k
  229%
• 100k–150k
  229%
• 150k+
  114%

Owner reports

Selected complaints filed with NHTSA by 2013 Hyundai Azera owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2013 Hyundai Azera. The contact stated while driving approximately 35 MPH the vehicle began to vibrate and was losing forward momentum. The contact stated that he depressed the accelerator and the vehicle was not gaining forward momentum. The contact stated that several warning lights had been illuminated, but he was not sure which lights were illuminated. The contact stated that he pulled into a parking lot, stopped the vehicle, and turned it off. The contact was able to turn the vehicle on but he observed that smoke was being emitted from under the hood. The contact turned the vehicle off and opened the hood. The contact stated that he saw several sparks coming from the right side of the vehicle firewall. The contact stated that flames were forming from the bottom of the engine and up to the firewall. The contact stated that he called the fire department. …

The contact's wife owns a 2013 Hyundai Azera. The contact stated while driving at various speeds, the vehicle was shuddering and then stalled. The check engine warning light was illuminated. The vehicle was taken to Auto Zone, where it was diagnosed and determined that the spark plugs, and ignition coils needed to be replaced. The contact purchased the parts, and the vehicle was taken to an independent mechanic, where the parts were replaced; however, the vehicle was still shuddering while driving. A mobile independent mechanic recommended that the key fob battery be replaced. The key fob battery was replaced; however, the failure persisted. The vehicle was towed to the dealer, where it was determined that the starter had failed. The dealer replaced the starter; however, the failure persisted. …

The contact owns a 2013 Hyundai Azera. The contact stated while driving at an undisclosed speed and attempting to slow the vehicle, the brakes made an abnormal squeaking sound. After a visual inspection of the engine compartment, the contact observed that the brake fluid reservoir was low. Upon refilling the brake fluid reservoir, the contact became aware that the brake fluid was draining abnormally fast. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who determined that there was brake fluid leaking within the engine compartment. The vehicle was not repaired. After investigating the failure, the contact related it to NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic); the VIN was included, but the remedy was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. …

The contact owns a 2013 Hyundai Azera. The contact stated that right after the vehicle had an oil change, the contact was driving at 55 MPH when she noticed smoke coming from underneath the hood. The check engine warning light was illuminated. Additionally, prior to the oil change, the engine made knocking sounds while driving. The police escorted the vehicle to the side of the road. The vehicle was towed to an independent mechanic, who diagnosed that the engine needed to be replaced. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 142,000. VIN tool confirms parts not available.

The contact owns a 2013 Hyundai Azera. The contact stated that while driving at an undisclosed speed, he heard an abnormal buzzing sound coming from the engine compartment. Upon turning off the vehicle, the contact observed that the buzzing sound continued, prompting him to disconnect the battery, after which the sound ceased. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the ABS. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic); for which the VIN was included. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 86,000.

The contact owns a 2013 Hyundai Azera. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic). The contact stated that the remedy to replace the fuse was inadequate and did not address the possible brake fluid leak, which could cause an electrical short. The contact stated that while driving at an undisclosed speed, the MIL warning light illuminated. The contact stated that the diagnostic test and recall repair appointment was scheduled. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 65,000. Parts distribution disconnect.

On 3/4/24 my break light came on approx 9:15pm . I drove the car about 10 min home and pulled in the driveway at 9:30 PM. My husband assessed brake fluid, to find it needed and brake fluid. He added break fluid and told me to take the car to get it checked in the am. The car was making a continuous humming noise. @ 4:55 AM on 3/5/24 we awoke to the tires exploding & the car fully engulfed in flames. Fire department had to put out fire. Then we remember the ABS BREAK recall from Hyundai was no remedy.

The Car started to emit Smoke while Driving on highway. All the feature indicate that the issue is purely related to the recall but the Hyndai took in the vehicle and gave me a decision that the engine failure is not related to recall. Said that the recall has been completed.

According to the recall letter that was mailed to me in October of 2023, it says "IMPORTANT SAFETY RECALL- Owners are advised to park their vehicles outside and away from structures until the recall remedy is completed." It says that the Anti Lock Brake System could leak brake fluid internally and cause an electrical short over time. This could lead to an engine compartment fire while parked or driving. As of today, April 6, 2024 there is no remedy for this recall. I have called the Hyundai dealer many times and asked for a solution. They said there is still no solution and refused to buy back the vehicle because of its age. Instead they suggested I try to sell the car privately.

The contact owns a 2013 Hyundai Azera. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brake, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts are not available.

Related recalls

NHTSA investigations

Brake complaints in other Azera years