Which parts fail
Components named in complaints (engine, cooling system, oil leaks, timing chain, exhaust).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2020 GMC Sierra 1500 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2020 GMC Sierra 1500. The contact stated that while driving with cruise control mode set at 55 MPH, the vehicle independently accelerated to 98 MPH, and then the vehicle lost motive power. Additionally, the contact stated that the vehicle had failed to turn off upon pressing the Engine Start/Stop button. No warning light was illuminated. The vehicle was able to restart and was taken to a local dealer to be diagnosed, but the cause of the failure could not be determined. Additionally, the contact noticed that water was leaking inside the vehicle through the rear window on rainy days. The contact stated that the infotainment screen had failed to turn on as intended on some occasions, and the screen had displayed a rearview camera image while the vehicle was in drive(D) on other occasions. …
The contact owned a 2020 GMC Sierra 1500. The contact stated that after the vehicle was purchased and while driving at an undisclosed speed, the check engine warning light illuminated. The dealer was contacted. However, the check engine light turned off, and the dealer refused to inspect the vehicle. The contact stated that while driving at an undisclosed speed, the vehicle jerked and the check engine light illuminated. The dealer was contacted. However, the warranty had expired, and the dealer refused to inspect the vehicle. The manufacturer was contacted, and the contact was offered a five-hundred-dollar coupon. The vehicle was taken back to the dealer. However, no cause for the failure was found. The contact stated that an unknown part was replaced. The contact stated that the failure persisted. …
The contact owns a 2020 GMC Sierra 1500. The contact stated that while driving at approximately 35-40 MPH and hauling a trailer in stop-and-go traffic, there was white smoke coming from the exhaust pipe, and the vehicle started losing power. The contact was able to pull over to the side of the road, where the Electronic Stability Control (ESC) and the check engine warning lights illuminated. The parking brake was engaging and disengaging independently. After turning off the vehicle and waiting for approximately 15-20 minutes, the vehicle was restarted, and the contact drove to the nearest independent mechanic. The mechanic diagnosed the vehicle and determined that the ignition coils needed to be replaced. The vehicle was repaired; however, it was determined that the repair had not resolved the failure. The mechanic then diagnosed the vehicle's cylinder #4 failure. …
The contact owns a 2020 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the engine seized. No warning lights were illuminated. The contact disabled the stop-to-start feature, and the failure ceased. The vehicle was taken to the dealer, and the contact was informed that the repair was not covered under recall. In addition, the contact was informed that the vehicle needed to remain with the dealer for two weeks while performing diagnostic tests on the vehicle. The contact was unable to be without a vehicle for two weeks. The vehicle was the only means of transportation. The contact stated that the failure was a known failure with the vehicle and that the manufacturer needed to repair the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, and a case was filed. …
The contact owns a 2020 GMC Sierra 1500. The contact stated while driving at an undisclosed speed, the parking brake was independently activated. In addition, the contact stated that the vehicle had an oil leak from the oil pan. The contact stated that the oil needed to be added every two days. The contact stated that the alert system warning light was illuminated. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact was informed that the failure could not be duplicated, because no active codes were retrieved. In addition, the contact stated that the frame had corrosion. The vehicle was taken to the dealer for corrosion failure, however, the contact stated that the previous dealer had failed to help. The dealer confirmed the corrosion; however, the vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. …
The contact owns a 2020 GMC Sierra 1500. The contact stated that while driving 55 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, there was an abnormal sound coming from the engine. Multiple warning lights were illuminated. The contact was able to coast to the side of the road. The vehicle was towed to the dealer, where it was diagnosed with engine failure. The engine was repaired. Most recently, while driving 35 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal, with an abnormal sound coming from the engine. Multiple warning lights were illuminated. The vehicle was towed to the dealer, where it was diagnosed with engine failure. The contact was informed that the camshaft, bearings, and lifters in cylinder #4 had failed. The vehicle remained at the dealer unrepaired. …
Hi, was driving Vehicle GMC 1500 Denali, vehicle Lost power, all Lites lite up on Dashboard, Vehicle Just lost power and i swerved off Road and sideswiped a Plant Holder on side of Road, damaging side passenger Rear door. I bought the truck to GMC Rvc and they said vehicle Blew Cam shaft and Lifters. I explained to them I'm very concerned for others safety in these Vehicles with the 6.2 Engine. Someone is going to get Killed or even a family. I did look up this vehicle its not listed in Recall, but this vehicle has same engine as ones in Recall. Rvc Gmc issued me a bill for repairs for the amount of $8185.20 and they stated they took 3k off invoice. I did Pay total Invoice....I'm just asking you to please look into this as this is defiantly an issue and this year should be listed on Recall as well.. Thanku for at least looking at this. …
The contact owns a 2020 GMC Sierra 1500. The contact stated while driving at various speeds, the vehicle was stuck in gear. While driving there was an abnormal burning odor coming from the vehicle. The vehicle failed to start on several occasions. There were sparks from the passenger's side front seat. Several unknown warning lights were illuminated. The vehicle was taken to the local dealer, where it was diagnosed with electrical, transmission module, wiring harness, air alternator cooler, and exhaust system failures. The vehicle was repaired; however, the failure recurred. Additionally, while driving at undisclosed speeds, there was a failure with the vault meter. The OnStar system provided an error with the antilock braking system. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 44,000.
The contact owns a 2020 GMC Sierra 1500. The contact stated that while driving approximately 35 MPH, the vehicle lost automotive power with the check engine warning light illuminated and the message "Vehicle Might Lose Power" displayed. The vehicle remained at the residence, and the contact used a self-diagnostic tool to retrieve a fault code related to the coolant valve D. The contact determined that the coolant valve D needed to be replaced. The vehicle was taken to an independent mechanic; however, the contact was unaware of the part that needed to be fixed in the vehicle. The vehicle was repaired. The contact researched and was made aware of an unknown NHTSA Campaign Number; however, the VIN was not under recall. The manufacturer was contacted and confirmed that the VIN was not under recall. The failure mileage was approximately 31,000.
The contact owns a 2020 GMC Sierra 1500. The contact stated that while driving approximately 55 MPH, the vehicle started losing power and decelerated. The check engine warning light was flashing with several unknown messages displayed. The vehicle was parked on the side of the road and later towed to the local dealer to be diagnosed. The contact was informed that the lifters, push rods, and camshaft had failed and needed to be replaced. The lifters, push rods, and camshaft were replaced, and the vehicle was repaired. The contact stated that approximately 6,900 miles later, the failure reoccurred. The vehicle was towed back to the local dealer, and the contact was informed that the engine crankshaft and connecting rods had failed and the engine needed to be replaced. The vehicle was not yet repaired. The failure mileage was 115,000.
NHTSA investigations
Loss of motive power due to engine failure
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM's full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine.
Loss of motive power due to engine failure
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274.
Engine complaints in other Sierra 1500 years
Frequently asked questions
How common are engine problems on the 2020 GMC Sierra 1500?
NHTSA has 257 complaints about the engine & cooling of the 2020 GMC Sierra 1500, 53% of the model year's 481 complaints. The component named most often is exhaust system › emission control › urea injection system (def) (2 mentions).
Is there a recall for 2020 GMC Sierra 1500 engine problems?
No. NHTSA lists no engine & cooling recall for the 2020 GMC Sierra 1500, though it has 12 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2020 GMC Sierra 1500 engine problems start?
Half of the complaints with a recorded mileage happened before about 65,000 miles, and 25% before 25,000 miles.
Is it dangerous?
Owners linked 3 crashes, 1 fire and 0 injuries to engine & cooling problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.