Most common 2007 Ford Fusion problems
Share of the 1,064 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Ford Fusion complaints by model year
Best Fusion years: 2006, 2007, 2020. Years to avoid: 2010, 2011, 2012. Compare all years →
2007 Ford Fusion recalls (4)
Air bags › Frontal › Driver side › Inflator module
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles.
Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge.
Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module
Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.
Remedy: Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap.
Air bags › Frontal › Passenger side › Inflator module
Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the…
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge.
Air bags › Frontal › Passenger side › Inflator module
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California,…
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge.
NHTSA defect investigations
Federal safety investigators have looked into 4 possible defects involving the 2007 Ford Fusion:
Extended Braking Distance
On December 20, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 16-017 to investigate reports of braking concerns in model year 2007 through 2009 Ford Fusion and Mercury Milan vehicles.Complainants report that after an ABS braking event (caused by braking on a slippery or uneven surface) the brake pedal moved towards the floor and the distance in which the vehicle stopped increased…
Tire valve cracking
On October 14, 2008, odi opened pe08-060 to investigate allegations of cracked and leaking snap-in tire valves in model year (my) 2007 vehicles manufactured by Ford motor company.the valves were supplied to Ford by topseal auto-parts, a subsidiary of the shanghai baolong automotive corporation in china.valves made by topseal for aftermarket sale were the subject of two recent safety recalls by tech international…
Extended Braking Distance
On April 18, 2018, the Office of Defects Investigation (ODI) opened Engineering Analysis (EA) 18-002 to investigate reports of braking concerns in model year (MY) 2006-12 Ford Fusion and Lincoln MKZ, and MY 2006-11 Mercury Milan vehicles manufactured with Continental Automotive System?s ABS hydraulic control units (HCUs).
Floor mat interference with accelerator
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined…
What 2007 Ford Fusion owners say
Air bags all 615 →
The contact owned a 2007 Ford Fusion. The contact stated while driving 40 MPH, and merging into the slow lane, he crashed into a vehicle that stopped abruptly. Additionally, the vehicle was rear-ended by another vehicle. The driver air bag exploded. The contact was able to exit the vehicle without assistance. The contact was transported to the hospital with the assistance of Uber. The contact was informed that he had sustained a broken sternum and bruised ribs. A police report was filed. The vehicle was towed to the residence, where it was totaled. The dealer and the manufacturer were not notified of the failure. The contact received a recall notice of NHTSA Campaign Number: 21V158000 (Air Bags), that he related to the failure. The failure mileage was approximately 130,000.
The contact owns a 2007 Ford Fusion. The contact stated while driving at 25 mph, a cable van was parked on the side of the road not allowing the contact to see the other vehicle reversing out of the driveway. As a result, the vehicle rear ended the vehicle in the driveway. The air bags failed to deploy. A police report was filed. There were no injuries sustained. The vehicle was not drivable and was not towed. The vehicle was not diagnosed or repaired. A dealer was not contacted. The contact was relating the failure to NHTSA campaign number: 21V158000 (Air bags). The manufacturer had not been informed of the failure. The failure mileage was 200,000.
Brakes all 147 →
The contact owns a 2007 Ford Fusion. The contact stated while driving at 60 MPH on a bumpy road, the brake pedal was depressed and the vehicle accelerated unintendedly, hit a high curb, and stopped. The air bags did not deploy. There were no warning lights illuminated. The contact was able to continue driving. The dealer was notified of the failure and informed the contact that she would need to pay a diagnostic test fee. The vehicle was not diagnosed or repaired. The contact stated that the failure reoccurred while driving. The contact stated while driving in the rain and in the process of changing lanes, the vehicle in front of her stopped at the traffic light. The contact then depressed the brake pedal. However, the vehicle hydroplaned, accelerated, and crashed into the rear of the vehicle in front of her. The air bags did not deploy. …
The contact owns a 2007 Ford Fusion. The contact received notification of NHTSA Campaign Numbers: 19V904000 (Service Brakes, Hydraulic) and 21V158000 (Air Bags) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the brake pedal went to the floorboard while depressed, and then the vehicle lost motive power with the brake fluid message displayed. Additionally, brake fluid leaked onto the engine and there was smoke coming from underneath the hood. The dealer was not made aware of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000. VIN tool confirms parts not available.
Transmission & drivetrain all 74 →
The contact owns a 2007 Ford Fusion. The contact received notification of NHTSA Campaign Number: 19V001000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle hesitated to accelerate. The air bag and check engine warning lights were illuminated. The vehicle later failed to be started. The vehicle was towed to the residence by AAA, who attempted to jumpstart the vehicle, but the vehicle failed to start. AAA related the failure to the transmission; however, the vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but confirmed that the air bag parts were on backorder. The failure mileage was unknown. …
Our Ford Fusion suddenly lost power and starting acting in an unpredictable fashion, while traveling on rte 95 north in the passing lane. We narrowly avoided a rear end collision with the vehicle behind us, as well as other vehicles as we worked to get over to the safety of the breakdown lane. An orange wrench light was in an "on" state and the car was running very rough. After checking all gauges and fluids, I restarted the car and found it to be in a normal state again, with no wrench light visible. We turned around and headed home. This condition occurred one more time about 45 miles later, just a few miles from our home, same result. I researched the issue and found that the NHTSA is aware of this problem and has been asked to fix over 1 million cars exhibiting the same issue. I contacted Ford, as recommended in a report I discovered online. …
2007 Ford Fusion engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.3L 4-cyl | 5-speed automatic | FWD | 20 / 29 / 23 |
| 2.3L 4-cyl | 5-speed manual | FWD | 20 / 29 / 23 |
| 3.0L 6-cyl | 6-speed automatic | FWD | 18 / 26 / 21 |
| 3.0L 6-cyl | 6-speed automatic | 4WD/AWD | 17 / 24 / 19 |
EPA ratings. Class: Midsize car.
Frequently asked questions
Is the 2007 Ford Fusion a good car?
Based on 1,064 owner complaints filed with NHTSA, the 2007 Fusion rates better than average: 68% fewer complaints than a typical year of the Fusion at the same age. It is one of the best Fusion years by this measure. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2007 Ford Fusion?
The air bags — 615 complaints, 58% of all complaints for this model year, most often about frontal. Next are the brakes (147) and transmission & drivetrain (74).
How many recalls does the 2007 Ford Fusion have?
There are 4 recalls for the 2007 Ford Fusion, the most recent from March 10, 2021 (inflator module). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Ford Fusion?
The best years by complaints, compared at the same age, are 2006, 2007 and 2020. Years to avoid or approach with caution: 2010, 2011 and 2012. See the full Ford Fusion years comparison.
At what mileage do 2007 Ford Fusion problems happen?
The median mileage reported in complaints is about 85,000 miles; 19% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.