What gets recalled
2001 Ford F Super Duty recalls (1)
Fuel system, gasoline › Storage › Tank assembly › Filler pipe and cap
Vehicle description: f-super duty crew cab pickup trucks (f-350 short wheelbase trucks equipped with a 6 3/4' pickup box and dual rear wheels) were built after a change was implemented to delete a clamp, and later a bracket that provided a ground for the fuel filler pipe. The pickup box May not have been properly grounded.
Remedy: Dealers will install a fuel filler pipe ground. Owner notification began March 26, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a…
2000 Ford F Super Duty recalls (3)
Exterior lighting › Brake lights › Switch
Vehicle description: motor home chassis. These vehicles May have a mis-routed wire harness that attaches to the brake pedal position switch. The wire could rub on the steering column, resulting in a short circuit and a blown fuse, causing a loss of stop lamp function.
Remedy: Dealers will inspect and, if necessary, repair the wire harness to the brake pedal switch. Owner notification began September 25, 2000.
Service brakes, hydraulic › Pedals and linkages
Vehicle description: f-super duty stripped motor home chassis because they May have a missing or partially installed brake pedal to master cylinder pushrod retaining clip.
Remedy: Dealers will inspect the retaining clip installation. Missing or partially installed clips will be properly installed. In addition, dealers will also inspect vehicles for lower than intended wheel lug nut torque;…
Vehicle speed control
Vehicle description: super duty trucks and chassis-cabs equipped with 5.4l manual transmission powertrains. The accelerator cable core wire can wear the cable conduit end fitting due to a fifteen degree angle it makes with the conduit at the throttle body end.
Remedy: Dealers will replace the accelerator cable and throttle body.
1999 Ford F Super Duty recalls (3)
Vehicle speed control
Vehicle description: super duty trucks and chassis-cabs equipped with 5.4l manual transmission powertrains. The accelerator cable core wire can wear the cable conduit end fitting due to a fifteen degree angle it makes with the conduit at the throttle body end.
Remedy: Dealers will replace the accelerator cable and throttle body.
Vehicle speed control
Vehicle description: motor home chassis. The accelerator cable is susceptible to freezing. Water can accumulate in the end fitting and can freeze at temperatures of 32 degrees fahrenheit and below. The ice could prevent the accelerator from returning to idle.
Remedy: Dealers will replace the accelerator cable with a revised accelerator cable.
Vehicle speed control › Cables
Vehicle description: motor home chassis. The accelerator cable is susceptible to freezing. Water can accumulate in the end fitting and at temperatures of 32 degrees fahrenheit and below, can freeze. The ice could prevent the accelerator from return to idle.
Remedy: Dealers will replace the accelerator cable with a revised accelerator cable.
1997 Ford F Super Duty recalls (3)
Engine and engine cooling › Exhaust system › Emission control › Gas recirculation valve (EGR valve)
Vehicle description: motor home chassis. Hot exhaust gasses can leak from the exhaust gas return (EGR) tube on the engine. A hole can develop in the flexible section of the tube. Heat damage to the passenger compartment floor and floor covering can occur.
Remedy: Dealers will replace the EGR tube.
Tires › Bead
Vehicle description: light duty pickup trucks and chassis. The tires on these vehicles were damaged during mounting onto the wheels. Only trucks produced at the cuautitlan, Mexico plant between September 1, 1996, and July 17, 1997, were affected by the defect.
Remedy: Due to the age of the vehicles and this recall affecting original equipment tires only, Ford will no longer accept claims for this campaign.
Electrical system › 12V/24V/48V battery › Cables
A plastic coated steel support strap for the battery cable was damaged when it was crimped onto the cable.
Remedy: Dealers will inspect the cable insulation and replace the support strap with a revised, uncrimped strap attached with tape. In addition, convolute will be added between the cable and the support strap.
1996 Ford F Super Duty recalls (2)
Engine and engine cooling › Exhaust system › Emission control › Gas recirculation valve (EGR valve)
Vehicle description: motor home chassis. Hot exhaust gasses can leak from the exhaust gas return (EGR) tube on the engine. A hole can develop in the flexible section of the tube. Heat damage to the passenger compartment floor and floor covering can occur.
Remedy: Dealers will replace the EGR tube.
Structure › Frame and members
The crossmember frame gussets were installed with undersized threaded fasteners following a breakdown of the production rivet gun that is generally used. This gusset is the attachment point for the rear strap of the mid-ship fuel tank.
Remedy: Dealers will replace the crossmember gusset fasteners with the specified alternative fasteners (bolts).
1995 Ford F Super Duty recalls (1)
Engine and engine cooling › Exhaust system › Emission control › Gas recirculation valve (EGR valve)
Vehicle description: motor home chassis. Hot exhaust gasses can leak from the exhaust gas return (EGR) tube on the engine. A hole can develop in the flexible section of the tube. Heat damage to the passenger compartment floor and floor covering can occur.
Remedy: Dealers will replace the EGR tube.
Frequently asked questions
How many recalls does the Ford F Super Duty have?
NHTSA lists 10 recalls for the Ford F Super Duty across 6 model years.
How do I know if my Ford F Super Duty has an open recall?
Enter your 17-character VIN in our VIN decoder & recall check or on nhtsa.gov/recalls. Dealers fix recalls for free, even if you are not the original owner.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.