Brake complaints by model year
Which parts fail
Components named in complaints (service brakes, ABS, rotors and pads, parking brake).
Mileage when the problem started
What owners report
on Jan 15, 2025. A cold start for the Bronco, putting in reverse, the vehicle lurched back and to the hard right, uncommanded acceleration at a high rate of speed, steering locked up, brakes locked up, tires spinning, engine revving causing the bronco to smash into the exterior of my home garage area. Then, shifting to drive, the vehicle again lurched, uncommanded acceleration hard to the left now, steering locked up, brakes locked up, tires spinning engine revving traveling 20-30 feet crashing into the electrical box coming to rest on top of it. Numerous faults showing multiple systems malfunctioning causing this incident.
Loss of braking. Note weather was cold in single digits Fahrenheit and midly snowy. I drove my 2025 Ford Bronco that was purchased in Octorber about 20 minutes to drop off my child at daycare. Going into the daycare I turned to Slippery/4A mode. After about 5 minutes inside I pulled out and switched back to Normal/2H mode. Less than half a mile later I got multiple warnings that the brakes, EBB, collision detect, and ABS had faulted, and I should service now. I only had the electronic parking brake available. I was able to use it and engine braking with my manual transmission to get to off the road to a parking lot, although I did also receive a parking brake overheat fault the turn before getting into the parking lot. I shut the vehicle off without the parking brake on. I turned it back on and the dash warning lights all disappeared after a few seconds. …
The contact owns a 2024 Ford Bronco. The contact stated that while driving at an undisclosed speed, the "Pre-Collision System Fault Detected" message was displayed. The vehicle returned to normal functionality, but the failure became a regular occurrence. The vehicle was towed to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The contact stated that later while driving at an undisclosed speed, the "Powertrain Fault Detected - Reduced Power", "Service Engine Soon" and "Brake Fault Detected" messages were displayed. The vehicle was taken back to the dealer, who diagnosed a failure with the brake actuator. The vehicle was repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 5,000.
The contact owns a 2024 Ford Bronco. The contact stated that while driving approximately 65 MPH, the brake warning light illuminated, and the brake pedal needed to be depressed with more force. The contact stated that the brake pedal was soft and there was no pressure on the pedal. The vehicle was taken to the residence. The vehicle was then taken to a dealer, where it was diagnosed and determined that the brake vacuum hose was leaking and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 48,000.
The contact owns a 2023 Ford Bronco. The contact stated that upon starting the vehicle, the message "Parking Brake Fault - Service Now" message was displayed. The vehicle was taken to a local dealer to be diagnosed; however, the contact was informed that further diagnostic test was needed to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 33,990.
Emergency brake failure. I have a very slight slope on my driveway. My car rolled halfway down my driveway. I assumed I did something wrong although I knew I had the car in gear with the E brake on. Two hours later I came back from an errand parked on my driveway was sitting in my car and my car started rolling backwards. The car was off in gear with the E brake on. I videotaped this happening every 20 seconds the car with balance, and roll back an inch or two. After 4 1/2 minutes, the car rolled the rest of the way down my driveway until it hit the street where it was flat. The car was in gear turned off with the E brake on, and nothing stopped the car from rolling. I tried putting it in an out of gear as this was happening and stomping on the break and nothing happened. I tried several times until it came to a complete stop. I have reported this to Ford. …
The contact owns a 2022 Ford Bronco. The contact stated that while driving approximately 60 MPH, the accelerator pedal was depressed and the brakes unintendedly engaged. The contact stated that the brakes were intermittently engaged even though the brake pedal was not depressed. The message "Check Braking System" was displayed on the instrument panel. The failure had occurred several times. The contact researched and was made aware of NHTSA Campaign Numbers: 25V488000 (Service Brakes, Hydraulic), 25V823000 (Service Brakes, Hydraulic); however, the VIN was not included in the recalls. The vehicle was taken to a dealer to be diagnosed; however, the dealer stated that without a fault code, the vehicle could not be diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that dealers were independent. …
The contact owns a 2022 Ford Bronco. The contact stated that while reversing and attempting to accelerate, the brakes activated erroneously, and the vehicle stopped unintendedly. The contact also stated that at 68 degrees Fahrenheit or under, the vehicle failed to properly shift gears as intended. No warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to call the NHTSA Hotline for assistance. The failure mileage was approximately 75,000.
Related recalls (2)
Service brakes, hydraulic › Power assist › Electric › Control module
Ford Motor Company (Ford) is recalling certain 2025 Lincoln Navigator, F-150, Expedition, Bronco, and Ranger vehicles. The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.
Remedy: Dealers will replace the electronic brake booster, free of charge. Owner notification letters were mailed February 26, 2026. Owners may contact Ford customer service at 1-866-436-7332.
Service brakes, hydraulic › Power assist › Electric › Control module › Software
Ford Motor Company (Ford) is recalling certain 2025 Lincoln Navigator, F-150, Expedition, Bronco, and Ranger vehicles. The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.
Remedy: The EBB module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed on August 22, 2025. Owners may contact Ford customer service at 1-866-436-7332.
Frequently asked questions
Which Ford Bronco years have brake problems?
By NHTSA complaints, the 2022 (42), 1995 (35), 2021 (22), 2023 (17) and 1996 (16) model years. Brake complaints make up 11% of all complaints for the 2022.
Is there a recall for Ford Bronco brake problems?
Yes — 2 recalls, including 25V-823 (control module, Dec 1, 2025); 25V-488 (software, Jul 25, 2025). Recall repairs are free at authorized dealers; check a specific car with the VIN recall check.
At what mileage do Ford Bronco brake problems start?
Across all years, half of the complaints with a recorded mileage happened before about 45,000 miles; 75% happened before 50,000 miles.
What part fails most often?
Owners most often name the antilock/traction control/electronic limited slip (19 mentions), followed by the foundation components (12).
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.