Most common 2000 Dodge Grand Caravan problems
Share of the 442 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Dodge Grand Caravan complaints by model year
Best Grand Caravan years: 2020, 2007, 2006. Years to avoid: 2008, 2016, 2005, 2010, 1996. Compare all years →
2000 Dodge Grand Caravan recalls (5)
Seats
Access options is recalling certain trucks and vans built on Ford e150, e350, Toyota sienna, and Dodge grand caravan chassis and equipped with vmi/ricon 6-way power seat bases. The six way power seat base May have a defective (cold) weld on the pivot pin which is welded to the swivel plate. The weld could fail.
Remedy: The swivel plate will be replaced free of charge if necessary. The recall began on June 8, 2010. Owners May contact access option at 831-722-6804.
Air bags
On certain minivans, the driver's air bag May become disabled due to a failure of the clockspring, which is located in the hub of the steering wheel.
Remedy: Dealers will replace the clockspring assembly on all covered vehicles with 70,000 miles or less. For those vehicles with more than 70,000 miles, daimlerchrysler will offer an extended lifetime warranty under which it…
Equipment › Other › Labels
On certain minivans and 4x2 pickup trucks, the vehicle certification label May have gross axle weight ratings (gawr) that exceed the maximum tire load capacity as defined in federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars."
Remedy: Owners will be provided with vehicle certification label overlays containing corrected information relative to vehicle gawr and tire size. Owner notification began March 1, 2004.
Structure
Certain pickup truck, van, and Mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by American technology components, inc. These units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
Remedy: Dealers will replace the wiring harness on these running boards. Owner notification began March 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free…
Fuel system, gasoline › Fuel injection system
Vehicle description: Mini vans built with 3.3l and 3.8l engines have fuel rails with nitrole rubber o-ring seals that can degrade over time. Fuel leakage from the underhood fuel injection fuel rail could result, increasing the likelihood of a vehicle fire.
Remedy: Dealers will install a seal on the vehicle fuel rails to prevent external leakage of fuel from the fuel rail crossover tube, should the existing o-rings continue to degrade. Owner notification began on January 25, 2002.
NHTSA defect investigations
Federal safety investigators have looked into 3 possible defects involving the 2000 Dodge Grand Caravan:
Dc minivan fuel injector rail leak
There is no summary currently available
Driver air bag clockspring failure
The driver air bag clockspring can develop an open-circuit condition resulting in nonfunctional driver-side frontal air bag, horn, cruise control (if equipped), and/or steering wheel radio control (if equipped).in its October 5, 2004 letter to NHTSA, daimlerchrysler stated that it will conduct a safety recall and replace the clockspring assembly on all my 1998.5-2000 daimlerchrysler minivans, built between March…
Air bag clockspring
There is no summary currently available
What 2000 Dodge Grand Caravan owners say
Transmission & drivetrain all 95 →
I started my 2000 Dodge Grand Caravan and turned on the air conditioner. I opened the doors to let the heat out and my 2 1/2 year old son reached into the front seat and pulled the shifter into drive. The van shifter shifted without pushing the brake and the van ran into my chain-link fence. This is a saety issue and I do not think it was recalled. If it does not get recalled then I will trade in my vehicle for a more safe one.
2000 Dodge Grand Caravan se has no shift lock. 2 year old child was able to shift transmission from park to drive without depressing the brake pedal. $1800 damage to Caravan and $2300 to another customized van; all in the expanse of 50 feet and 1 minute in a flat and level private school parking lot.
Engine & cooling all 88 →
I was driving at 75 MPH on an Interstate Highway. The 3.3 liter V6 engine, with 120,800 miles on it, threw a rod and cracked a 3 to 4" diameter hole in the block. I have cared for this car religiously for 14 years. It had full oil level. It is available for the next couple of weeks for examination if desired. I was able to get off the highway onto the shoulder safely.
The serpentine belt on 96-2000 Chrysler minivans slipping off is a known issue and has been for years. Time and time again Chrysler has refused to issue a recall for it. It is due to a manufacturing defect in one of the engine mounts causing a pulley misalignment. The belt slipping off causes loss of power steering, water pump, and alternator. The power steering loss can cause a driver to not be able to correct in time and cause an accident. The loss of the water pump can cause overheating resulting in engine damage. The loss of the alternator can cause the car to eventually stop running when the battery is drained, causing motorists to be stranded. I live in alaska and I'm not always in cellular signal when driving and temperatures in the winter get down to -30 f at times. …
Suspension all 56 →
Tl* the contact owns a 2000 Dodge Grand Caravan. The contact stated that the shock support and the framing near the front of the vehicle was rusted to the point of corrosion. The contact mentioned that the springs were faulty and deteriorated near the shock support and the framing. The vehicle was taken to an independent mechanic who diagnosed that the support system on the driver side failed and the support brackets needed to be replaced in the front of the vehicle. The vehicle was included in NHTSA campaign number: 04V480000 (air bags); however, the contact was not notified of the safety recall. The manufacturer was not notified of the failure. The approximate failure mileage was 170,000.
Strut towers on my 2000 Dodge Grand Caravan have rusted through. Visible, significant rust has been present for at least 7 years, however, it is now not driveable. I did not realize this is such a broadscale, significant problem to most owners of 1996-2000 vans. Please recall this mess! Strut towers are not cosmetic!
2000 Dodge Grand Caravan engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.4L 4-cyl | 3-speed automatic | FWD | 18 / 24 / 20 |
| 3.0L 6-cyl | 4-speed automatic | FWD | 16 / 23 / 19 |
| 3.3L 6-cyl | 4-speed automatic | FWD | 16 / 23 / 19 |
| 3.8L 6-cyl | 4-speed automatic | FWD | 15 / 22 / 18 |
| 3.8L 6-cyl | 4-speed automatic | 4WD/AWD | 15 / 21 / 17 |
EPA ratings. Class: Minivan.
Frequently asked questions
Is the 2000 Dodge Grand Caravan a good car?
Based on 442 owner complaints filed with NHTSA, the 2000 Grand Caravan rates average: about as many complaints as a typical year of the Grand Caravan at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2000 Dodge Grand Caravan?
The transmission & drivetrain — 95 complaints, 21% of all complaints for this model year, most often about automatic transmission. Next are the engine & cooling (88) and suspension (56).
How many recalls does the 2000 Dodge Grand Caravan have?
There are 5 recalls for the 2000 Dodge Grand Caravan, the most recent from June 17, 2010 (seats). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Dodge Grand Caravan?
The best years by complaints, compared at the same age, are 2020, 2007 and 2006. Years to avoid or approach with caution: 2008, 2016, 2005, 2010 and 1996. See the full Dodge Grand Caravan years comparison.
At what mileage do 2000 Dodge Grand Caravan problems happen?
The median mileage reported in complaints is about 80,000 miles; 26% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.