Most common 2002 Chevrolet Yukon problems
Share of the 6 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Chevrolet Yukon complaints by model year
Best Yukon years: 1998. Compare all years →
NHTSA defect investigations
Federal safety investigators have looked into 4 possible defects involving the 2002 Chevrolet Yukon:
Steel wheel rim fracture
There have been less than 2 complaints per 100,000 subject vehicles related to the alleged defect.the oldest vehicles (my 1999) have only 2 complaints in over 140 thousand vehicles after over 4 years in service.the rate of warranty claims potentially related to the alleged defect is less than 0.1%.there are no known incidents involving rapid loss of tire pressure or loss of vehicle control.
Brake line corrosion failure
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia,…
Hydraulic pump failres
GM is conducting a recall on all subject vehicles build between May 1999 and October 14, 1999.significant changes were incorporated into production in early October 1999, and vehicles built after that date have lower warranty failure rates.the complaint and warranty data appear to support the effectiveness of these changes.
Parking brake failure
Odi's review of complaint data received since the close of ea04-011 revealed no indication that the investigation should be re-opened.more details can be found in the federal register notice enclosed in the dp05-009 public file.odi reserves the right to reopen the investigation in the future should conditions warrant.
What 2002 Chevrolet Yukon owners say
Engine & cooling
The fuel injection system did not work correctly. The vehicle had been to the dealer on five occasions and the problem still existed. There was a noise coming from under the hood, the pin in the roof continued to fall out, the door did shut properly, the brakes made a noise, the vehicle had a bad steering shaft. Ph
While driving 45 MPH, the vehicle stalled. The consumer managed to pull over and had the vehicle towed. The cause was not determined. Please provide more information.
Brakes
Tl* the contact owns a 2002 Chevrolet Yukon xl. The contact stated that when depressing the brakes they extended to the floor and all of the fluid leaked out. The vehicle was taken to a dealer who advised him that all of the brake lines were completely rusted through and needed to be replaced. The brake lines were repaired. The failure and current mileage was approximately 129,000. Updated 08/31/11 the brake lines were replaced twice. Updated 09/09/11.
The fuel injection system did not work correctly. The vehicle had been to the dealer on five occasions and the problem still existed. There was a noise coming from under the hood, the pin in the roof continued to fall out, the door did shut properly, the brakes made a noise, the vehicle had a bad steering shaft. Ph
Frequently asked questions
Is the 2002 Chevrolet Yukon a good car?
Based on 6 owner complaints filed with NHTSA, the 2002 Yukon rates average: 14% fewer complaints than a typical year of the Yukon at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2002 Chevrolet Yukon?
The engine & cooling — 3 complaints, 50% of all complaints for this model year, most often about engine. Next are the brakes (3) and electrical system (1).
How many recalls does the 2002 Chevrolet Yukon have?
NHTSA lists no recalls for the 2002 Chevrolet Yukon. You can still confirm with your VIN using our VIN recall check.
What are the best and worst years of the Chevrolet Yukon?
The best years by complaints, compared at the same age, are 1998. See the full Chevrolet Yukon years comparison.
At what mileage do 2002 Chevrolet Yukon problems happen?
The median mileage reported in complaints is about 129,000 miles; 50% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.