Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2021 Chevrolet Suburban owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving 45 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended, and the vehicle decelerated unintendedly. Additionally, the vehicle failed to exceed 42 MPH. Later in the day, the gear shifter was shifted to reverse; however, the vehicle failed to reverse as intended. The vehicle was taken to the dealer, where it was diagnosed with transmission valve body failure. The contact was informed that the transmission valve body needed to be replaced. The vehicle was repaired. The contact stated that the vehicle was at the dealer from December 2024 until June 2025. The vehicle was picked up from the dealer. The contact stated that while driving at an undisclosed speed, the engine seized and failed to restart. …
The contact owns a 2021 Chevrolet Suburban. The contact stated that while in reverse (R), the vehicle failed to reverse as intended. The contact's wife continued driving at approximately 55 MPH, and an unknown message was displayed, and the vehicle failed to exceed 55 MPH. Additionally, the transmission was stuck in gear and failed to upshift into the next gear as designed. The vehicle was pulled over to the side of the road, and the battery was disconnected and reconnected, but the message remained displayed. The vehicle was towed to an independent mechanic, where it was determined that the transmission control valve needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 81,600.
The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the vehicle jerked abnormally while shifting into reverse(R) or drive(D). The contact stated that the vehicle lost motive power with the check engine warning light illuminated. The contact was able to restart the vehicle; however, the failure persisted while attempting to drive. The contact also stated that the vehicle was put into LIMP Mode several times. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 78,000.
The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving at various speeds, the vehicle jerked while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not covered under NHTSA Campaign Number: 24V797000 (Power Train), which the contact linked to the failure. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 75,000.
Originally we had an engine light come on upon the engine chugging and the vehicle lunging forward at times. The diagnostic showed a bad lifter on the passenger side. They then replaced the passenger side lifters. We asked them to replace both sides since this was a known problem with our year, make, and model. They said they weren't replacing both sides of the lifters. Luckily we were still under the warranty for this repair. Now, a little over a year later on the day we were taking it to trade in, the engine light came on and the engine started chugging again. I knew immediately what the problem was. I took it to the same dealership and they quickly diagnosed it with a lifter failure on the driver side. Unfortunately we are out of warranty at 80,200 miles. The vehicle is only 2 years old. We have been advised not to drive the vehicle until it is repaired. …
Hi, my name is [redacted] . I have two major issues with my 2021 Chevrolet Suburban: The value body failed for the 2021 Suburban in December, causing engine power reduction and the engine transmission was not shifting properly. This was covered by my extended warranty, which I paid $2500 extra for at the time of purchase. Also, this VIN is for a Chevy Suburban Duramax Diesel. The Emissions Control Module ( ECM ) light has come on several times, starting from about 20K miles to now 61K miles. I noticed the ECM light comes on at about a 8K mile interval. I take it into the dealership and they have told me this is due to a software issue and then they reset the light. This has happened on at least 4 occasions since about 20K miles. However, now at 61K miles, they are telling me that the exhaust system has a leak and it may not be a covered repair under even my extended warranty. …
My [redacted] Daughter lost the ability to put the vehicle in reverse while running errands on a Saturday. We had to push the truck out of the parking spot "backwards" in neutral in order to get the vehicle in a position to put it in "drive". She had been going in and out of shopping centers (forwards and backwards) earlier when the reverse suddenly stopped. I dropped the vehicle at a nearby auto shop in a fit of desperation (maybe 1/2 mile away). They told me they thought the transmission was shot, so I picked it up and took it to Andean Chevrolet (Dealer) in Cumming, GA. While driving it to Andean on Tuesday (2/17), the transmission went into low acceleration mode where I couldn't go into upper gears and topped-out at 3,500 rpm's max for the 13+ miles (30 min) drive. …
I am submitting this complaint to report a serious safety issue involving my 2021 Chevrolet Suburban equipped with the 3.0L Duramax diesel engine. The vehicle has experienced a recurring problem related to the engine wiring harness. While driving, the vehicle will unexpectedly stall without warning. At the same time, there is an immediate loss of power steering assist, significantly reducing the ability to safely control the vehicle. This creates a dangerous situation, especially at highway speeds or in traffic. The failure appears to be linked to a defect or malfunction in the engine wiring harness, which may be causing intermittent electrical interruptions to critical engine systems. There were no prior warning signs sufficient to prevent the incident. This issue poses a substantial safety risk not only to the driver and passengers but also to other motorists. …
The failure involved the transmission valve body control valve within the automatic transmission system of the 2021 Chevrolet Suburban, a critical component responsible for regulating hydraulic pressure and controlling gear shifting. The malfunction caused erratic and unreliable shifting behavior, including hesitation, harsh engagement, and loss of proper acceleration; the failed component is in the custody of Northside Chevy in San Antonio, TX. This issue created a significant safety risk, as the unpredictable transmission response impacted the driver's ability to accelerate when necessary (merging onto high traffic roads) and increased the likelihood of dangerous situations like rear-end collisions or loss of control. …
Cylinders were misfiring and lifters had to be completely replaced along with pushrod and camshaft. This cost me $7018.64 to fix out of my own pocket. Received the vehicle back, and there was a slight ticking sound that was new to me. Scheduled to bring the vehicle back in and 2 days before I was scheduled to go in and approximately 1000 miles later, the engine completely shut down while I was driving on the road. As I did not know what was going on and I had my newborn baby in the car, I was panicking as I was trying to figure out how to pull over to get out of traffic. Turns out there are now metal shavings in my engine according to the GM certified dealership that I had the work on the lifters done at in the first place. They are now quoting me an additional $13,000+ dollars to completely replace the engine with one that is not even brand new. …
Related recalls
Power train › Automatic transmission › Fluid/lubricant › Valves/valve body
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a…
Power train › Driveline › Driveshaft
General Motors, LLC (GM) is recalling certain 2021 GMC Yukon, Yukon XL, Cadillac Escalade, Escalade ESV, Chevrolet Suburban, and Chevrolet Tahoe vehicles. The rear wheel driveshaft assemblies may have internal components that were not heat-treated properly, possibly resulting in driveshaft failure.
Remedy: Dealers will replace the left and/or right rear driveshaft assemblies, free of charge. Owner notification letters were mailed on March 14, 2022.
Transmission complaints in other Suburban years
Frequently asked questions
How common are transmission problems on the 2021 Chevrolet Suburban?
NHTSA has 37 complaints about the transmission & drivetrain of the 2021 Chevrolet Suburban, 19% of the model year's 200 complaints.
Is there a recall for 2021 Chevrolet Suburban transmission problems?
Yes — NHTSA recall 24V-797 (valves/valve body, Oct 24, 2024); NHTSA recall 22V-036 (driveshaft, Jan 27, 2022). Recall repairs are free at authorized dealers.
At what mileage do 2021 Chevrolet Suburban transmission problems start?
Half of the complaints with a recorded mileage happened before about 78,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.