Which parts fail
Components named in complaints (service brakes, ABS, rotors and pads, parking brake).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2022 Chevrolet Silverado 1500 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that upon starting the vehicle, there was a message related to brakes. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and there was an abnormal grinding sound coming from the brakes. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the brake pads and rotors needed to be replaced. The dealer informed the contact that the brake sensors had detached. The repair was not covered under warranty. The manufacturer was contacted and confirmed that the repair was not covered under warranty. The failure mileage was approximately 35,000.
Was taking an exit car felt like lose control and got hit with the sign pole on the exit. I have been complaining for the safety reasons and the location and other issues in car to onstar and Chevy for months. Went to Freeport Chevy dealer and changed oil, when I bought the car pre-approved but the when I went for the service they said no oil was changed since the car was new. And I have been paying for all the warranty and extended service but they said all oil change and others will cost approx $3200. They changed the oil but I have been seeing on the Chevy app filter was never changed and the car didn't feel same after the service.
The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed but the brakes failed to stop the vehicle immediately. The message "Brake System Failure" was displayed. The failure occurred twice and nearly caused a collision. The vehicle coasted to the side of the roadway and was towed to the dealer; however, no failure was found. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 6,000.
I was at a stop light. Let my foot off brake vehicle revved up and I launched into a vehicle in front of me. Check engine light was on before. Blinking, esc fault , forward collision detection was not working, traction control service light. Throttle body control issue detected code P0205. Valve timing issues detected codes p0353 p0355 p129f p0300. The wire above my shock bolt is completely cut into. GM did an investigation and said no issues were detected at all. There is a TSB for the wire chafing
The contact owns a 2022 Chevrolet Silverado 1500. The contact stated while driving 20 MPH with a trailer attached, the "Trailer Brake Disabled" message was displayed. The vehicle was taken to the dealer to be diagnosed. The dealer confirmed knowledge of the failure however, there was no fix for the vehicle. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The contact was referred to the NHTSA Hotline to file a complaint. The failure mileage was 1,400.
The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that the trailer braking system failure warning light was illuminated. The contact took the vehicle to the dealer who diagnosed that there was an integrated trailer brake system failure. The vehicle had not been repaired due to the manufacturer not having a fix for the failure. The manufacturer was not made aware of the failure. The approximate failure mileage was 1,750.
As I was driving my vehicle on 9/12 the truck reported a brake system failure and I lost power to my brakes. I was able to pull over at the gas station and call the dealership. They said they couldn't assist because they didn't know what the issue was. I called a tow truck and had it towed to the dealer. They had my truck for 8 days and replaced the brake module and gave me back my truck. I noticed that the truck had only moved 1 mile from the time I left it at the dealer. NO ONE TEST DROVE THE VEHICLE prior to giving it back to me. As I was driving home on 9/20 my brakes failed again and I lost power. The dashboard read "Brake system failure ". I called the dealer and this time they towed the vehicle. They said they are replacing the entire master cylinder but I don't have faith that this will solve the issue. …
7500 oil change, tire rotation multi vehicle inspection appt. With issues. - didn't do oil change/inspection. Because of major issue with transmission/engine. Vehicle running rough, happens at idle or while driving. Sounds lik it will stall. When u put vehicle in gear drive or reverse vehicle lunges towards direction its in gear. Radio lights on dash decide to dim on their own, shuts off on its own. Will not let u adjust dimness you must shut off for it to re light up which is a 50/50 chance. Going over bumps loud noise coming from rear, vehicle does get squirmy when you hit a large bump. Large loud whinging noise upon acceleration. Intermittent issue with key fobs usually spare key not found on dash. Still. Diagnosis papers attached. It is a balance shift gear crank shaft case; they have to remove the transmission and the engine completely from my truck and replace parts! …
On 11/10/2022 I was driving in moderate to heavy traffic at low speed; approximately twenty (20) mph. I applied the brakes and immediately experienced a hard pedal coupled with some pulsating. I pressed the pedal as hard as I could as there was traffic stopped in front of me. At the same time every warning light illuminated on the dashboard. My truck stopped just short of colliding with the other vehicle in front of me. The message displayed on the dash read "Brake System Failure" followed by a second message which read "Trailer Brake Failure", and then an additional message that read "Do not exceed 42 mph". Fortunately there was a Chevy dealership nearby. I drove the vehicle at very low speed to their service department and currently wait a diagnosis. …
Purchased 2022 Chevrolet Silverado 1500 new on 10/4/2022. First used to tow on 10/7/2022 with less than 500 miles from new on vehicle. I hooked up our brand new camper (1 month old 2022 Grand Design Imagine) to the truck and the integrated trailer brake controller for the first time and a message appeared on DIC stating "Trailer Brakes Disabled Service Required" and the trailer brakes disengaged. Restarted vehicle and the message west away, only to come back on the first time I applied the brakes. Dealership service department has been helpful in as much as they have evaluated both my truck and the camper. Found the truck integrated brake controller was not communicating properly and had a DTC of C159C. Dealership tested camper trailer brakes and found them to be working properly (as expected). …
Brake complaints in other Silverado 1500 years
Frequently asked questions
How common are brake problems on the 2022 Chevrolet Silverado 1500?
NHTSA has 57 complaints about the brakes of the 2022 Chevrolet Silverado 1500, 9% of the model year's 650 complaints. The component named most often is power assist (1 mentions).
Is there a recall for 2022 Chevrolet Silverado 1500 brake problems?
No. NHTSA lists no brakes recall for the 2022 Chevrolet Silverado 1500, though it has 6 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2022 Chevrolet Silverado 1500 brake problems start?
Half of the complaints with a recorded mileage happened before about 6,000 miles, and 75% before 25,000 miles.
Is it dangerous?
Owners linked 2 crashes, 0 fires and 1 injury to brakes problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.