Which parts fail
Components named in complaints (fuel pump, injectors, fuel tank, hybrid and EV propulsion).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2012 Chevrolet Cruze owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2012 Chevrolet Cruze. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The contact connected a diagnostic machine to the vehicle and retrieved a DTC code for a failure with the purge valve and the catalytic convertor. The contact replaced the purge valve; however, the failure reoccurred. The contact stated that several unknown warning lights were illuminated. The contact stated that the warning lights blinked on and off. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 98,039.
I've had this car for less than 2 months I've already spent $3,500 I've had to replace the thermostat the resvoir tank most oxygen sensors lower stream and upper stream now has a blown head gasket and a possible fuel pump
I had no heat for a long time, as well as the engine light constantly being on and never knowing why. There was a lag to accelerate. Also it would suddenly overheat and say turn off ac due to overheating, as well as suddenly fluctuate to cold and back to normal. I change the throttle body inlet heater hose to see if that would get it working. It did for a day. Then all over a sudden the same issues started happening. From what I can tell it is an extremely common issue that has not been address yet or had a recall yet....the thermostat. That is the only thing it could be at this point. I am going to try and bleed out the coolant for air again. But other than that it is the thermostat, it is the only thing that covers every symptom and it is an extremely, well documented problem with these types of cars.
I have filed a complaint 2 other times on my car from the power train to the electrical and now my radiator. Because of the date of my car, which is one week off, my car doesn't fall under all the recalls that have been made. Everything wrong with my car is a recall including the head gasket! I have paid to fix my car out of pocket every time and now the repair isn't worth fixing because i never know whats going to happen next! Just like every other government agency NHTSA is controlled by the big corporations while the little guy gets screwed over! Times are hard as is now throw in this plandemic and car problems life becomes unmanageable at times.
Everything that has to do with the air in cabin and air intake for engine fails. Have issues all the time with it , told I need to fix one part then that fails again. Can't use the AC in this car more than half the time if not an issue arises. Now I can't get my inspection because again the same codes: P0097, P0171,P11c3, P 2199 At first I had only an issue with the MAF new one was placed and now all these errors popped up. The electrical also gave me issues before the lights are not as bright anymore in the car not the headlights. Too afraid to change them because I need the vehicle for my medical appointments and to pick up kids from school
The cars turbo system fails. This causes a loss of power when accelerating. Pulling out into traffic or merging onto the freeway are all unsafe now as the car suddenly doesn't accelerate. This can cause crashes. I have pulled out and assumed I was at a very safe distance only to have the car not pick up as it usually does. I feel very unsafe.
I purchased this vehicle almost three weeks ago...I'm assuming it's out of warranty...J am spending out of pocket expenses to have this car repaired....It has a faulty leakage in transmission that mechanics seem to can't fix....I need my car for transportation....ATP I'm assuming the car is a lemon
Please print off the scanned documents and add them to the complaint form # 11512592. I needed more room to upload 4 more jpeg files to show the history of the problem with the valve cover and PCV valve attached to it. Thank you.
I am wondering when GM is gonna admit fault on these Chevy Cruzes? My mechanic father owns one. He's had to replace Valve cover gasket on his 3x. Mine at least 4-5x now. One bad oil change at a dealership almost cost me my engine at Sunfair Chevrolet. They left 2 rings on the oil fuel filter causing it to leak all over my engine compartment which left me roadside the next day after driving it 2 hours the night before back in Aug 2016. So they gave us 10K miles over this incident in case my engine blew. It ran a bit hotter than it did before this incident. I also noticed a burning smell. Enclosed in the scanned documents you will find a letter from Chevrolet discussing a "engine light" coming on and engine coolant leak from the water pump reservoir leading to a drip of coolant onto the engine or onto the ground. …
Started the purchase June 2022 when dealer said everything is good, Carfax no accidents, good car, nothing wrong. Dealers had me drive MI to CT to get the car, had 5-y.o. kid w/me. Brought car to mechanic when finally delivered July 6, ebrake almost gone; dealers had me drive w/my kiddo CT to MI with no ebrake on 6 speed turbo manual, wonderful. In writing said they would fix & some extras for all the issues they caused such as selling a vehicle w/o having title. Made it home in one peice. Next few weeks, car started shaking and stalling out losing complete power while driving, stopping at lights/signs, it hasn't stopped. Different smells of fluids coming inside ever since. Clouds of smoke coming from exhaust. Fuel seems to slip like sputtering/jolting, more smells coming in car. …
Related recalls
Fuel system, gasoline › Storage › Tank assembly › Mounting
General motors (GM) is recalling certain model year 2011 and 2012 Chevrolet cruze vehicles manufactured from October 2, 2009, through May 14, 2012. Attachment welds for the fuel tank strap secondary brackets May have been omitted.
Remedy: GM will notify owners, and dealers will inspect the vehicle for missing welds. If the vehicle is missing welds, dealers will secure the bracket attachments with fasteners. Repairs will be performed free of charge.
Fuel System complaints in other Cruze years
Frequently asked questions
How common are fuel system problems on the 2012 Chevrolet Cruze?
NHTSA has 52 complaints about the fuel & propulsion system of the 2012 Chevrolet Cruze, 6% of the model year's 865 complaints. The component named most often is storage › evaporative emissions › canister (1 mentions).
Is there a recall for 2012 Chevrolet Cruze fuel system problems?
Yes — NHTSA recall 12V-289 (mounting, Jun 22, 2012). Recall repairs are free at authorized dealers.
At what mileage do 2012 Chevrolet Cruze fuel system problems start?
Half of the complaints with a recorded mileage happened before about 58,000 miles, and 29% before 25,000 miles.
Is it dangerous?
Owners linked 2 crashes, 0 fires and 0 injuries to fuel & propulsion system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.