What gets recalled
2026 Volvo VN recalls (3)
Steering › Linkages › Knuckle › Spindle › Arm
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VOLVO VAH, VN, VHD, 2026-2027 VNL (4) and VNR (4) vehicles. The steering knuckles may have been manufactured with insufficiently tightened steering arms.
Remedy: Dealers will inspect and tighten the fasteners between the steering arm and steering knuckle, as necessary, free of charge. Owner notification letters were mailed July 27, 2026.
Wheels › Lugs/nuts/bolts/studs
Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VAH, 2026-2027 VN, VHD, VNL (4), and 2027 VNR (4) vehicles. The wheel lug nuts may loosen and allow the wheel to detach.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Dealers will inspect the wheel and hub mating surfaces, remove any masking material, and replace any worn components if necessary, free…
Electrical system › 12V/24V/48V battery › Cables
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2026 Volvo VN trucks. The power cables may have been improperly routed, which can cause an electrical short.
Remedy: Dealers will re-route the power cables, free of charge. Owner notification letters were mailed June 17, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
2025 Volvo VN recalls (8)
Electrical system › 12V/24V/48V battery › Cables
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025-2026 Volvo VN trucks. The power cables may have been improperly routed, which can cause an electrical short.
Remedy: Dealers will re-route the power cables, free of charge. Owner notification letters were mailed June 17, 2025. Owners may contact Volvo Trucks' customer service at 800-528-6586.
Engine and engine cooling › Engine › Diesel
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2025 Volvo VN and 2025 New VN trucks. The idler gear bracket fasteners may have been improperly tightened, allowing the idler gear to detach from the engine.
Remedy: Dealers will inspect and replace the turbo compound units as necessary, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
Electrical system › Software
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2025 VN, VAH, VHD and VNRE trucks, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
Remedy: Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Wheels › Lugs/nuts/bolts/studs
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025 VN and VHD trucks. The wheel lug nuts may be improperly tightened.
Remedy: Dealers will tighten the left-side lug nuts, free of charge. Owner notification letters were mailed September 19, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Show 4 more recalls
Steering › Linkages › Tie rod assembly
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025 VN and VHD trucks equipped with Composilite EXS20 steerable lift axle suspension assemblies. The tie rod assembly ball stud could have been improperly heat treated and can fail.
Remedy: Dealers will inspect and replace the tie rod end assemblies as necessary, free of charge. Owner notification letters were mailed July 15, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Steering › Linkages › Tie rod assembly
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025 VN trucks. The tie rod assemblies may contain an improperly heat-treated ball stud that can fail, resulting in a sudden loss of steering control.
Remedy: Owners are advised not to drive their vehicles until the remedy has been completed. Dealers will inspect and replace the tie rod ends as necessary, free of charge. Owner notification letters were mailed June 18, 2024.
Steering › Linkages › Drag › Link › Connection
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025 VN, VNRe, and VHD trucks. The drag link may contain an improperly heat-treated ball stud that can fail, resulting in a sudden loss of steering control.
Remedy: Owners are advised not to drive their vehicle until the repair has been performed. Dealers will inspect and replace the drag links, as necessary, free of charge. Owner notification letters were mailed June 20, 2024.
Steering › Electric power assist system
Volvo Trucks North America (Volvo Trucks) is recalling certain 2025 VN and VHD trucks. The steering gear may have an improperly seated plug in the valve housing, which can result in a sudden loss of steering control.
Remedy: Dealers will inspect the plug and replace the steering gear as necessary, free of charge. Owner notification letters were mailed June 17, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
2024 Volvo VN recalls (7)
Engine and engine cooling › Engine › Diesel
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2025 Volvo VN and 2025 New VN trucks. The idler gear bracket fasteners may have been improperly tightened, allowing the idler gear to detach from the engine.
Remedy: Dealers will inspect and replace the turbo compound units as necessary, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
Electrical system › Software
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2025 VN, VAH, VHD and VNRE trucks, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
Remedy: Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Vehicle speed control › Throttle › Throttle position sensor (tps)
Volvo Trucks North America (Volvo) is recalling certain 2022-2024 Volvo VN vehicles. When the Controller Area Network (CAN) communications are interrupted and the vehicle is in limp mode, an incorrect accelerator pedal signal can result in unintended acceleration.
Remedy: Dealers will update the electronic control unit (ECU) software, free of charge. Owner notification letters were mailed November 26, 2024. Owners may contact Volvo Customer Service at 1-800-528-6586.
Equipment › Other › Labels
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024 VN and VHD vehicles equipped with size 295/75 or 385/65 Continental tires on the front axle. The Gross Axle Weight Rating (GAWR) listed on the vehicle certification label is incorrect, which can allow the vehicle to be overloaded.
Remedy: Dealers will remove and replace the label, free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Show 3 more recalls
Vehicle speed control
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2024 VN vehicles. The engine may not return to idle within 2 seconds if the accelerator pedal position sensor becomes disconnected.
Remedy: Volvo Trucks will replace the throttle pedal and update the vehicle software, free of charge. Owner letters were mailed February 27, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Seats › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2024 VN and VHD vehicles. The passenger side bench seat may be inadequately attached to the floor. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 207, "Seating Systems" and 210, "Seatbelt Assembly…
Remedy: Dealers will replace the weld nut with two nuts and a washer, free of charge. Owner letters were mailed February 29, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Steering › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2024 VN, VHD, and VAH trucks. The steering gear fasteners may not be properly tightened.
Remedy: Dealers will tighten the steering gear fasteners, free of charge. Owner notification letters are expected to be mailed August 18, 2023. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
2023 Volvo VN recalls (9)
Engine and engine cooling › Engine › Diesel
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2025 Volvo VN and 2025 New VN trucks. The idler gear bracket fasteners may have been improperly tightened, allowing the idler gear to detach from the engine.
Remedy: Dealers will inspect and replace the turbo compound units as necessary, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
Electrical system › Software
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2025 VN, VAH, VHD and VNRE trucks, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
Remedy: Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Vehicle speed control › Throttle › Throttle position sensor (tps)
Volvo Trucks North America (Volvo) is recalling certain 2022-2024 Volvo VN vehicles. When the Controller Area Network (CAN) communications are interrupted and the vehicle is in limp mode, an incorrect accelerator pedal signal can result in unintended acceleration.
Remedy: Dealers will update the electronic control unit (ECU) software, free of charge. Owner notification letters were mailed November 26, 2024. Owners may contact Volvo Customer Service at 1-800-528-6586.
Vehicle speed control
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2024 VN vehicles. The engine may not return to idle within 2 seconds if the accelerator pedal position sensor becomes disconnected.
Remedy: Volvo Trucks will replace the throttle pedal and update the vehicle software, free of charge. Owner letters were mailed February 27, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Show 5 more recalls
Seats › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2024 VN and VHD vehicles. The passenger side bench seat may be inadequately attached to the floor. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 207, "Seating Systems" and 210, "Seatbelt Assembly…
Remedy: Dealers will replace the weld nut with two nuts and a washer, free of charge. Owner letters were mailed February 29, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Steering › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023-2024 VN, VHD, and VAH trucks. The steering gear fasteners may not be properly tightened.
Remedy: Dealers will tighten the steering gear fasteners, free of charge. Owner notification letters are expected to be mailed August 18, 2023. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
Engine and engine cooling › Engine › Engine control module (ECU/ECM)
Volvo Trucks North America (Volvo Trucks) is recalling certain 2023 Volvo VN vehicles. The engine control module (ECM) may experience an internal electrical short-circuit, causing the engine to stall.
Remedy: Cummins will replace the ECM and perform a recalibration. Owner notification letters are expected to be mailed September 29, 2022. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
Steering
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2023 VN tractor trailers. The steering gears may have been assembled incorrectly, which can cause the gear to fracture.
Remedy: Dealers will inspect and replace steering gears on vehicles. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Volvo Truck customer service at 1-800-528-6586.
Structure › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2023 VN L4 and L4E (Sleeper) trucks. The cabinets may be improperly secured to the walls due to the bolts being installed without the required washers.
Remedy: Dealers will install washers to the existing bolts, free of charge. Owner notification letters were mailed March 17, 2022. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
2022 Volvo VN recalls (6)
Engine and engine cooling › Engine › Diesel
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2025 Volvo VN and 2025 New VN trucks. The idler gear bracket fasteners may have been improperly tightened, allowing the idler gear to detach from the engine.
Remedy: Dealers will inspect and replace the turbo compound units as necessary, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
Electrical system › Software
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2025 VN, VAH, VHD and VNRE trucks, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
Remedy: Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Vehicle speed control › Throttle › Throttle position sensor (tps)
Volvo Trucks North America (Volvo) is recalling certain 2022-2024 Volvo VN vehicles. When the Controller Area Network (CAN) communications are interrupted and the vehicle is in limp mode, an incorrect accelerator pedal signal can result in unintended acceleration.
Remedy: Dealers will update the electronic control unit (ECU) software, free of charge. Owner notification letters were mailed November 26, 2024. Owners may contact Volvo Customer Service at 1-800-528-6586.
Seats › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2024 VN and VHD vehicles. The passenger side bench seat may be inadequately attached to the floor. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 207, "Seating Systems" and 210, "Seatbelt Assembly…
Remedy: Dealers will replace the weld nut with two nuts and a washer, free of charge. Owner letters were mailed February 29, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Show 2 more recalls
Steering
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2023 VN tractor trailers. The steering gears may have been assembled incorrectly, which can cause the gear to fracture.
Remedy: Dealers will inspect and replace steering gears on vehicles. Owner notification letters are expected to be mailed July 29, 2022. Owners may contact Volvo Truck customer service at 1-800-528-6586.
Structure › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2023 VN L4 and L4E (Sleeper) trucks. The cabinets may be improperly secured to the walls due to the bolts being installed without the required washers.
Remedy: Dealers will install washers to the existing bolts, free of charge. Owner notification letters were mailed March 17, 2022. Owners may contact Volvo Trucks' customer service at 1-800-528-6586.
2021 Volvo VN recalls (2)
Electrical system › Software
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2025 VN, VAH, VHD and VNRE trucks, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
Remedy: Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Seats › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2024 VN and VHD vehicles. The passenger side bench seat may be inadequately attached to the floor. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 207, "Seating Systems" and 210, "Seatbelt Assembly…
Remedy: Dealers will replace the weld nut with two nuts and a washer, free of charge. Owner letters were mailed February 29, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
2020 Volvo VN recalls (2)
Electrical system › Software
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2025 VN, VAH, VHD and VNRE trucks, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
Remedy: Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
Seats › Critical fasteners
Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2024 VN and VHD vehicles. The passenger side bench seat may be inadequately attached to the floor. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 207, "Seating Systems" and 210, "Seatbelt Assembly…
Remedy: Dealers will replace the weld nut with two nuts and a washer, free of charge. Owner letters were mailed February 29, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586.
2016 Volvo VN recalls (2)
Power train › Manual transmission
Volvo Trucks North America (Volvo) is recalling certain model year 2016 VN trucks manufactured January 6, 2015, to January 15, 2015, equipped with certain Eaton Fuller FR-Series 10-speed manual transmissions.
Remedy: Volvo will notify owners, and dealers will inspect and repair the transmissions, if necessary, free of charge. The recall began on December 21, 2015.
Electrical system › Ignition › Module
Volvo Trucks North America (Volvo) is recalling certain model year 2016 Volvo VN trucks manufactured on August 13, 2015. The affected vehicles are equipped with certain Cummins engines whose engine control module (ECM) may short circuit and blow a fuse resulting in the engine stalling without warning.
Remedy: Cummins will notify owners on behalf of Volvo, and will replace any defective ECM, free of charge. The recall began in October 2015. Owners may contact Cummins customer service at 1-800-343-7357.
2013 Volvo VN recalls (2)
Suspension › Front › Control arm › Lower ball joint
Volvo Trucks North America (Volvo) is recalling certain model year 2009-2015 Volvo VN trucks manufactured April 14, 2008, to December 23, 2014. The affected vehicles may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint.
Remedy: Volvo will notify owners, and dealers will inspect and replace the drag links, free of charge. Parts are not currently available. Volvo issued an interim notification to owners on October 28, 2015.
Seat belts
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
2012 Volvo VN recalls (2)
Suspension › Front › Control arm › Lower ball joint
Volvo Trucks North America (Volvo) is recalling certain model year 2009-2015 Volvo VN trucks manufactured April 14, 2008, to December 23, 2014. The affected vehicles may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint.
Remedy: Volvo will notify owners, and dealers will inspect and replace the drag links, free of charge. Parts are not currently available. Volvo issued an interim notification to owners on October 28, 2015.
Seat belts
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
2011 Volvo VN recalls (2)
Suspension › Front › Control arm › Lower ball joint
Volvo Trucks North America (Volvo) is recalling certain model year 2009-2015 Volvo VN trucks manufactured April 14, 2008, to December 23, 2014. The affected vehicles may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint.
Remedy: Volvo will notify owners, and dealers will inspect and replace the drag links, free of charge. Parts are not currently available. Volvo issued an interim notification to owners on October 28, 2015.
Seat belts
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
2010 Volvo VN recalls (4)
Suspension › Front › Control arm › Lower ball joint
Volvo Trucks North America (Volvo) is recalling certain model year 2009-2015 Volvo VN trucks manufactured April 14, 2008, to December 23, 2014. The affected vehicles may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint.
Remedy: Volvo will notify owners, and dealers will inspect and replace the drag links, free of charge. Parts are not currently available. Volvo issued an interim notification to owners on October 28, 2015.
Seat belts
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
Service brakes, air › Supply › Quick release valve
Volvo trucks is recalling certain model year 2007 and 2009 vhd, model year 2006 through 2010 vn, and model year 2007 through 2009 vt trucks manufactured from November 7, 2005, through October 30, 2009, equipped with an air release fifth wheel.
Remedy: Dealers will inspect the inversion valve and replace as required. This service will be performed free of charge. The safety recall is expected to begin on or before February 18, 2011.
Visibility › Glass, side/rear
Volvo trucks is recalling certain model year 2009-2010 vnl, vt, and 780 trucks manufactured from March 1, 2008 through February 6, 2009. The bottom track that attaches to the arms used to open and close the window May de-bond, which results in the glass coming loose at the bottom.
Remedy: Dealers will inspect and repair as required free of charge. The safety recall began on December 1, 2010. Owners May contact Volvo trucks at 1-800-528-6586.
2009 Volvo VN recalls (4)
Suspension › Front › Control arm › Lower ball joint
Volvo Trucks North America (Volvo) is recalling certain model year 2009-2015 Volvo VN trucks manufactured April 14, 2008, to December 23, 2014. The affected vehicles may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint.
Remedy: Volvo will notify owners, and dealers will inspect and replace the drag links, free of charge. Parts are not currently available. Volvo issued an interim notification to owners on October 28, 2015.
Seat belts
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
Service brakes, air › Supply › Quick release valve
Volvo trucks is recalling certain model year 2007 and 2009 vhd, model year 2006 through 2010 vn, and model year 2007 through 2009 vt trucks manufactured from November 7, 2005, through October 30, 2009, equipped with an air release fifth wheel.
Remedy: Dealers will inspect the inversion valve and replace as required. This service will be performed free of charge. The safety recall is expected to begin on or before February 18, 2011.
Visibility › Glass, side/rear
Volvo trucks is recalling certain model year 2009-2010 vnl, vt, and 780 trucks manufactured from March 1, 2008 through February 6, 2009. The bottom track that attaches to the arms used to open and close the window May de-bond, which results in the glass coming loose at the bottom.
Remedy: Dealers will inspect and repair as required free of charge. The safety recall began on December 1, 2010. Owners May contact Volvo trucks at 1-800-528-6586.
2008 Volvo VN recalls (2)
Seat belts
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
Service brakes, air › Supply › Quick release valve
Volvo trucks is recalling certain model year 2007 and 2009 vhd, model year 2006 through 2010 vn, and model year 2007 through 2009 vt trucks manufactured from November 7, 2005, through October 30, 2009, equipped with an air release fifth wheel.
Remedy: Dealers will inspect the inversion valve and replace as required. This service will be performed free of charge. The safety recall is expected to begin on or before February 18, 2011.
2007 Volvo VN recalls (3)
Seat belts
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
Service brakes, air › Supply › Quick release valve
Volvo trucks is recalling certain model year 2007 and 2009 vhd, model year 2006 through 2010 vn, and model year 2007 through 2009 vt trucks manufactured from November 7, 2005, through October 30, 2009, equipped with an air release fifth wheel.
Remedy: Dealers will inspect the inversion valve and replace as required. This service will be performed free of charge. The safety recall is expected to begin on or before February 18, 2011.
Steering › Gear box › Shaft sector
On certain heavy duty class 8 trucks equipped with dana steering shafts, there is a potential that the steering shaft pinch bolt hole May be incorrectly located. The pinch bolt fits into a groove in the steering gear input shaft to ensure that the steering shaft does not separate from the steering gear if the pinch bolt comes…
Remedy: Dealers will inspect the steering shaft and replace it as required free of charge. The recall began on August 28, 006. Owners May contact Volvo trucks at 1-800-528-6586.
2006 Volvo VN recalls (4)
Seat belts
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
Service brakes, air › Supply › Quick release valve
Volvo trucks is recalling certain model year 2007 and 2009 vhd, model year 2006 through 2010 vn, and model year 2007 through 2009 vt trucks manufactured from November 7, 2005, through October 30, 2009, equipped with an air release fifth wheel.
Remedy: Dealers will inspect the inversion valve and replace as required. This service will be performed free of charge. The safety recall is expected to begin on or before February 18, 2011.
Power train › Axle assembly
On certain trucks equipped with arvinmeritor series 145 and 160 rear drive axles. Some of the spindles were overheated during the heat treat process which could result in a fracture of the spindle.
Remedy: Dealers will inspect the spindle for suspect heat codes and replace the axle if necessary. The recall began on December 12, 2005. Owners May contact vovlo trucks at 1-800-528-6586.
Wheels
On certain heavy duty class 8 trucks equipped with accuride aluminum wheels, the wheels were not properly pre-stressed. This allows cracks to develop over time.
Remedy: Dealers will replace the wheels free of charge. The recall began on June 30, 2005 owners May contact Volvo trucks at 1-800-528-6586.
2005 Volvo VN recalls (2)
Seat belts
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
Suspension
On certain heavy duty class 8 trucks, equipped with holland air suspension systems, a transverse beam casting May fracture under normal loads. If a casting breaks when the vehicle is traveling on a roadway there is the potential for pieces of the casting to become projectiles and the suspension?s transverse beam May drop down…
Remedy: Dealers will inspect and replace the defective transverse beam assemblies. The recall began on August 26, 2005. Owners May contact Volvo trucks at 1-800-528-6586.
2004 Volvo VN recalls (4)
Seat belts
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
Visibility › Windshield wiper/washer › Motor
On certain trucks equipped with valeo wiper systems, the wiper motor May be susceptive to salt intrusion that could possibly lead to a condition where the connector overheats to a point where the connector could ignite.
Remedy: Dealers will inspect and replace the connector plate on the windshield wiper motor. Phase 2 of the recall began on November 1, 2004. Owners should contact Volvo trucks at 1-800-528-6586.
Power train › Driveline › Driveshaft
On certain trucks, the bolts that retain the universal joint to the yoke at the transmission May not be tightened correctly.
Remedy: Dealers will remove and install removing new bolts, inspect for cross-threaded bolts, and replace the yoke if necessary. The recall began October 1, 2004. Owners should contact Volvo trucks at 1-800-528-6586.
Trailer hitches › Fifth wheel assembly
On certain trucks, a malfunction in the solenoid valve May allow air to be released to fifth wheel latch when the park brake is engaged.
Remedy: Dealers will add an additional solenoid valve in series with the existing pneumatic circuit for the fifth wheel air release. The recall began on August 9, 2004. Owners should contact Volvo at 1-800-528-6586.
2003 Volvo VN recalls (4)
Seat belts
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
Visibility › Windshield wiper/washer › Motor
On certain trucks equipped with valeo wiper systems, the wiper motor May be susceptive to salt intrusion that could possibly lead to a condition where the connector overheats to a point where the connector could ignite.
Remedy: Dealers will inspect and replace the connector plate on the windshield wiper motor. Phase 2 of the recall began on November 1, 2004. Owners should contact Volvo trucks at 1-800-528-6586.
Trailer hitches › Fifth wheel assembly
On certain trucks, a malfunction in the solenoid valve May allow air to be released to fifth wheel latch when the park brake is engaged.
Remedy: Dealers will add an additional solenoid valve in series with the existing pneumatic circuit for the fifth wheel air release. The recall began on August 9, 2004. Owners should contact Volvo at 1-800-528-6586.
Engine and engine cooling
On certain heavy-duty class 8 trucks, the assembled engine pre-heater jumper wiring harness was incorrectly assembled.
Remedy: Dealers will repair the affected circuits in the jumper wiring harness connector. Owner notification is expected to begin during March 2004.
2002 Volvo VN recalls (5)
Seat belts
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
Visibility › Windshield wiper/washer › Motor
On certain trucks equipped with valeo wiper systems, the wiper motor May be susceptive to salt intrusion that could possibly lead to a condition where the connector overheats to a point where the connector could ignite.
Remedy: Dealers will inspect and replace the connector plate on the windshield wiper motor. Phase 2 of the recall began on November 1, 2004. Owners should contact Volvo trucks at 1-800-528-6586.
Trailer hitches › Fifth wheel assembly
On certain trucks, a malfunction in the solenoid valve May allow air to be released to fifth wheel latch when the park brake is engaged.
Remedy: Dealers will add an additional solenoid valve in series with the existing pneumatic circuit for the fifth wheel air release. The recall began on August 9, 2004. Owners should contact Volvo at 1-800-528-6586.
Engine and engine cooling
On certain heavy-duty class 8 trucks, the assembled engine pre-heater jumper wiring harness was incorrectly assembled.
Remedy: Dealers will repair the affected circuits in the jumper wiring harness connector. Owner notification is expected to begin during March 2004.
Show 1 more recall
Suspension › Multiple axle
On certain heavy duty class 8 trucks with Volvo b-ride rear suspension, the forward and/or rear drive axle upper axle seat could break allowing the affected axle to shift out of alignment.
Remedy: Dealers will replace the upper axle seat on both rear drive axles. Owner notification began January 14, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the…
2001 Volvo VN recalls (2)
Visibility › Windshield wiper/washer › Motor
On certain trucks equipped with valeo wiper systems, the wiper motor May be susceptive to salt intrusion that could possibly lead to a condition where the connector overheats to a point where the connector could ignite.
Remedy: Dealers will inspect and replace the connector plate on the windshield wiper motor. Phase 2 of the recall began on November 1, 2004. Owners should contact Volvo trucks at 1-800-528-6586.
Power train › Axle assembly
On certain heavy duty class 8 trucks, the forward and/or rear drive axle upper axle seat can break allowing the axle to shift out of alignment.
Remedy: Dealers will inspect the upper axle seat for a certain date code that is stamped on the part, and those axles will be replaced. Owner notification began March 15, 2002.
2000 Volvo VN recalls (2)
Visibility › Windshield wiper/washer › Motor
On certain trucks equipped with valeo wiper systems, the wiper motor May be susceptive to salt intrusion that could possibly lead to a condition where the connector overheats to a point where the connector could ignite.
Remedy: Dealers will inspect and replace the connector plate on the windshield wiper motor. Phase 2 of the recall began on November 1, 2004. Owners should contact Volvo trucks at 1-800-528-6586.
Steering › Linkages › Tie rod assembly
On some heavy duty class 8 vehicles equipped with arvinmeritor axle assemblies which May have been manufactured with trw model 20edl ball sockets, the tie rod ball-socket bearings have a below specification case depth and/or hardness which can lead to premature wear out of the socket in some applications.
Remedy: Dealers will replace the ball socket assemblies. This campaign supersedes NHTSA campaign nos. 01v-139.001 and 02v-037.002. Owner notification began July 25, 2002.
1999 Volvo VN recalls (5)
Steering › Linkages › Tie rod assembly
On some heavy duty class 8 vehicles equipped with arvinmeritor axle assemblies which May have been manufactured with trw model 20edl ball sockets, the tie rod ball-socket bearings have a below specification case depth and/or hardness which can lead to premature wear out of the socket in some applications.
Remedy: Dealers will replace the ball socket assemblies. This campaign supersedes NHTSA campaign nos. 01v-139.001 and 02v-037.002. Owner notification began July 25, 2002.
Equipment › Other › Labels
Vehicle description: heavy duty class 8 vehicles. Under certain operating conditions, the weight certification label which contains front gross axle weight rating (gawr) information pursuant to the requirements of FMVSS no.
Remedy: The weight certification label will be brought into compliance by one or more of the following means: (1) replacement of the label with one which contains correct information; or (2) replacement of front axle tires,…
Steering › Linkages › Tie rod assembly
Vehicle description: heavy duty class 8 vehicles equipped with arvinmeritor axle assemblies which May have been manufactured with trw model 20edl ball sockets. The tie rod ball-socket bearings have a below specification case depth and/or hardness which can lead to premature wear out of the socket in some applications.
Remedy: Dealers will replace the ball socket assemblies. The campaign has been superceded by recall no. 02V037002. Owner notification began November 17, 2000.
Visibility › Defroster/defogger/HVAC system
Vehicle description: heavy duty trucks equipped with an espar compact heater mounted in the luggage compartment. The fuel-metering pump that supplies fuel to the compact heater is not wired through a rollover protection switch. This does not comply with 49 cfr 393.77, "heaters."
Remedy: Dealers will wire the fuel-metering pump through a rollover protection switch.
Show 1 more recall
Service brakes, air
Vehicle description: heavy duty trucks equipped with meritor air brake automatic slack adjusters. Some of the automatic slack adjusters had insufficient torque applied to the guide pawl cap screw.
Remedy: Dealers will check the torque on the automatic slack adjuster guide pawl. If there is no torque, the brakes will be adjusted and the guide pawl will be tightened to 15-20 ft. Lbs.
1998 Volvo VN recalls (6)
Equipment › Other › Labels
Vehicle description: heavy duty class 8 vehicles. Under certain operating conditions, the weight certification label which contains front gross axle weight rating (gawr) information pursuant to the requirements of FMVSS no.
Remedy: The weight certification label will be brought into compliance by one or more of the following means: (1) replacement of the label with one which contains correct information; or (2) replacement of front axle tires,…
Parking brake
Vehicle description: heavy duty trucks equipped with haldex manifold dash valves (mdv) used in tractor and trailer parking brakes. These valves do not meet the requirements of FMVSS no.
Remedy: Dealers will replace the suspect valves.
Visibility › Defroster/defogger/HVAC system
Vehicle description: heavy duty trucks equipped with an espar compact heater mounted in the luggage compartment. The fuel-metering pump that supplies fuel to the compact heater is not wired through a rollover protection switch. This does not comply with 49 cfr 393.77, "heaters."
Remedy: Dealers will wire the fuel-metering pump through a rollover protection switch.
Steering › Linkages
Vehicle description: heavy duty trucks equipped with a fal 8.0 front steer axle. The upper steering arm can fail without warning.
Remedy: Dealers will inspect the upper steering arm and replace it, if required.
Show 2 more recalls
Wheels › Rim
Vehicle description: heavy duty trucks equipped with aftermarket aluminum dual wheels, 22.5x8.25, one-piece, tubeless, supplied by accuride/akw. Certain design revisions combined with process conditions caused fatigue cracks in these wheels.
Remedy: Accuride/akw will replace these wheels.
Exterior lighting › Headlights › Switch
Vehicle description: class 8 heavy duty trucks. The electronic module that controls the daytime running lights (drl) and headlights can fail without warning resulting in the loss of the drl and headlight functions.
Remedy: Dealers will replace the drl control module.
1997 Volvo VN recalls (9)
Equipment › Other › Labels
Certain heavy duty class 8 trucks fail to comply with the requirements of federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars." the weight certification label which contains front gross axle weight rating (gawr) information does not accurately reflect the actual…
Remedy: Dealers will install new front steer axle tires and new certification label stating the new front steer axle weight rating. Owner notification began December 19, 2002.
Equipment › Other › Labels
Vehicle description: heavy duty class 8 vehicles. Under certain operating conditions, the weight certification label which contains front gross axle weight rating (gawr) information pursuant to the requirements of FMVSS no.
Remedy: The weight certification label will be brought into compliance by one or more of the following means: (1) replacement of the label with one which contains correct information; or (2) replacement of front axle tires,…
Parking brake
Vehicle description: heavy duty trucks equipped with haldex manifold dash valves (mdv) used in tractor and trailer parking brakes. These valves do not meet the requirements of FMVSS no.
Remedy: Dealers will replace the suspect valves.
Steering › Linkages
Vehicle description: heavy duty trucks equipped with a fal 8.0 front steer axle. The upper steering arm can fail without warning.
Remedy: Dealers will inspect the upper steering arm and replace it, if required.
Show 5 more recalls
Wheels › Rim
Vehicle description: heavy duty trucks equipped with aftermarket aluminum dual wheels, 22.5x8.25, one-piece, tubeless, supplied by accuride/akw. Certain design revisions combined with process conditions caused fatigue cracks in these wheels.
Remedy: Accuride/akw will replace these wheels.
Exterior lighting › Headlights › Switch
Vehicle description: class 8 heavy duty trucks. The electronic module that controls the daytime running lights (drl) and headlights can fail without warning resulting in the loss of the drl and headlight functions.
Remedy: Dealers will replace the drl control module.
Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Vehicle description: class 8 heavy duty trucks. A wire that connects the engine control module (ECU) to the automatic braking control system (ABS) controller is missing. The engine brake can lock up the rear axle wheels on a slick pavement, and the ABS would not prevent the lock up.
Remedy: Dealers will install the missing wiring circuit on the ABS brakes.
Visibility › Windshield wiper/washer › Motor
Vehicle description: heavy duty trucks. The relay that controls the electrical power to the windshield wiper motor can fail.
Remedy: Dealers will replace the suspect relays.
Power train › Manual transmission › Column shift assembly
The transmission shift control lever can break off at the transmission.
Remedy: Dealers will replace these transmission shift control levers with new control levers.
Frequently asked questions
How many recalls does the Volvo VN have?
NHTSA lists 47 recalls for the Volvo VN across 25 model years, 3 of them with a do-not-drive or park-outside warning.
How do I know if my Volvo VN has an open recall?
Enter your 17-character VIN in our VIN decoder & recall check or on nhtsa.gov/recalls. Dealers fix recalls for free, even if you are not the original owner.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.