Most common 2007 Volvo S80 problems
Share of the 24 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Volvo S80 complaints by model year
Best S80 years: 2011, 2005, 2012. Years to avoid: 2001, 2002, 2004, 2003, 2008. Compare all years →
2007 Volvo S80 recalls (5)
Seat belts › Front
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles.
Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552.
Steering › Hydraulic power assist › Hose, piping, and connections
Volvo is recalling certain model year 2007 s80 passenger cars manufactured from March 8, 2006, through May 16, 2007. The power steering reservoir return hose May have been incorrectly routed, which can result in increased pressure in the power steering system.
Remedy: Volvo dealers will inspect the routing of the power steering reservoir return hose and make repairs as necessary, free of charge. The safety recall is expected to begin during August 2011.
Equipment › Electrical › Navigational system(global positioning system)
Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (GPS) units because the batteries on those units May overheat.
Remedy: Volvo advises owners to please stop using the garmin portable GPS device immediately, and visit the garmin website to determine if their unit is affected.
Tires › Pressure monitoring and regulating systems
Volvo is recalling certain model year 2007-2010 s80 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." the tire and loading information label and a page in the owner's manual contain incorrect maximum permissible inflation pressure and the tire…
Remedy: Dealers will update the vehicles with a new tire and loading information label, owner's manual label and TPMS software. This service will be performed free of charge.
Electrical system › Software
Volvo is recalling 12,303 my 2007-2008 s80 and v70 vehicles. The diagnostic software in the central electronic module (cem) May cause a malfunction of the windshield wiper functionality.
Remedy: Dealers will inspect the cem and upgrade the software free of charge. The recall began on May 15, 2009. Owners May contact Volvo customer care center at 1-800-458-1552, or customercare@volvoforlife.com.
What 2007 Volvo S80 owners say
Body & structure
The contact owns a 2007 Volvo S80. The contact stated that while operating the vehicle during a rainstorm; rainwater leaked into the vehicle from the top section of the driver's side of the windshield, creating a visibility hazard for the driver. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted regarding the failure. The failure mileage was 150,000.
Severe subframe rust due to excessive heat from the exhaust on the v8 models of the Volvo s80s only. Dealer said the excessive heat will melt the paint off, causing rust to attract to the subframe. The subframe is a critical component to the car, unfortunately although Volvo has said this is a common problem on the v8 models, they will not do anything to fix the problem. This is the only place my vehicle has rust, and the car is undercoated yearly.
Windows, wipers & sunroof
The contact owns a 2007 Volvo S80. The contact stated that while operating the vehicle during a rainstorm; rainwater leaked into the vehicle from the top section of the driver's side of the windshield, creating a visibility hazard for the driver. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted regarding the failure. The failure mileage was 150,000.
These generation of Volvo p3 platform cars had a defective windshield seal that was not the best from the factory. Many cars of this generation (S60, S80, XC90, etc) have had the seals break, causing extreme water leakage as mine has had. And the possibility of the windshield falling out. Mine is bad enough that pushing it lightly from the inside to create a significant gap in the window and the frame of the A pillar. There are many forums and reports of this exact problem and Volvo has yet to voluntarily recall these cars. Many people have reported it to many dealers, but all say they cant replace them. This problem definitely puts the driver and other people in the cabin in danger. And no warning lights go off in relation to the problem. I appreciate your consideration.
Electrical system
Warning light on dashboard indicated right front headlamp out. Repair shop removed and replaced original component with new component. Internal inspection of light assembly revealed missing insulation(photos attached) on wiring harness causing a short circuit which also ruined the headlight igniter and control module. Shop stated that this issue is NOT uncommon with Volvo lighting systems. The current concern is the same condition is present in the left(driver) headlight and could cause a short and fire within the headlight assembly. Correspondence with Volvo resulted in no resolution of the issue and lack of concern for the reliability of installed components or possible safety concern for their product.
The passenger side head light while I was driving home from work bulb went out had message stating bulb failure replaced bulbs and within 2 days. Lights were out again and the wiring connected to head lights were frayed as if they had shorted out or had melted and the back side signal on passenger side stopped working the car was being driven at that time
2007 Volvo S80 engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 3.2L 6-cyl | 6-speed automatic | 4WD/AWD | 16 / 24 / 19 |
| 3.2L 6-cyl | 6-speed automatic | FWD | 16 / 25 / 19 |
| 4.4L 8-cyl | 6-speed automatic | 4WD/AWD | 15 / 23 / 18 |
EPA ratings. Class: Midsize car.
Frequently asked questions
Is the 2007 Volvo S80 a good car?
Based on 24 owner complaints filed with NHTSA, the 2007 S80 rates average: about as many complaints as a typical year of the S80 at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2007 Volvo S80?
The body & structure — 6 complaints, 25% of all complaints for this model year, most often about body. Next are the windows, wipers & sunroof (4) and electrical system (4).
How many recalls does the 2007 Volvo S80 have?
There are 5 recalls for the 2007 Volvo S80, the most recent from June 30, 2020 (front). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Volvo S80?
The best years by complaints, compared at the same age, are 2011, 2005 and 2012. Years to avoid or approach with caution: 2001, 2002, 2004, 2003 and 2008. See the full Volvo S80 years comparison.
At what mileage do 2007 Volvo S80 problems happen?
The median mileage reported in complaints is about 90,000 miles; 25% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.