Most common 1999 Volvo S80 problems
Share of the 199 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Volvo S80 complaints by model year
Best S80 years: 2011, 2005, 2012. Years to avoid: 2001, 2002, 2004, 2003, 2008. Compare all years →
1999 Volvo S80 recalls (4)
Vehicle speed control
On certain passenger vehicles, a combination of throttle positioning sensor irregularities, a dirty throttle housing, and/or inefficient software calibration May cause a warning lamp to light and the subsequent onset of limp home modes.
Remedy: Dealers will install the current software upgrade onto the involved vehicles. The recall began on December 29, 2006. Owners May contact Volvo at 1-800-458-1552.
Engine and engine cooling › Cooling system › Fan
On certain passenger and sport utility vehicles, under certain operating conditions, some electric cooling fans May overheat potentially causing heat damage and, in rare instances, a fire in the engine compartment.
Remedy: Dealers will replace the cooling fan. The recall began on November 29, 2004. Customers should contact Volvo cars at 1-800-458-1552.
Engine and engine cooling › Cooling system › Fan
On some passenger vehicles, certain electric cooling fans could be inadequate in a hot climate. Under certain circumstances, excessive heat could be generated.
Remedy: Dealers will replace the engine cooling fan. Owner notification began April 1, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a…
Suspension › Front › Control arm › Upper ball joint
Vehicle description: passenger vehicles. Over time, the ball joint between the front wheel king pin and the suspension link arm, can experience increased looseness.
Remedy: Dealers will replace both front ball joints.
NHTSA defect investigations
Federal safety investigators have looked into 2 possible defects involving the 1999 Volvo S80:
Throttle control malfunction
Pe05-041 was opened on July, 26, 2005, based on 136 consumer complaints to odi alleging throttle control malfunctions in the subject vehicles.odi has now received 591 complaints of etm failures which allege symptoms with potential safety related consequences.these include allegations of engine stall, vehicle surging forward without accelerator input, vehicle hesitation upon acceleration and sudden and unexpected…
Throttle control malfunction
On November 14, 2006 Volvo submitted a defect information report to NHTSA concerning etm failures in model year (my) 1999 through 2001 Volvo models (not including the s40 and v40), my 2002 s60 and v70 with naturally aspirated engines and my 2002 v70s.according to Volvo, ?a combination of throttle positioning sensor irregularities, a dirty throttle housing and/or inefficient software calibration May cause a warning…
What 1999 Volvo S80 owners say
Speed control & acceleration all 53 →
While we were try I g to repair this vehicle we were test driving it a d came to a full stop at a stoplight signal and could not downshift vehicle into 1st gear from a stop after the vehicle was at normal running temperature. Causing it to go I to a limp home mode. So while we were driving we noticed that the floor was saturated with antifreeze and a sweet odor from the vents was noticed with a smoke . We serviced the transmission without success . Also noticed an no oil pressure read on dash only when we were not in acceleration. This disappear when upon acceleration and returned when idling. We serviced the oil filter the fluids performed a motor flush first and replaced the oil pressure switch. Without successful repairs and continue of the code returns after performing a drive cycle numerous times. We are convinced this is caused by the recall #r155. …
When im driving and have to come to a slow stop im hearing the master cylinder sound like its rubbing against something loudly even with the appropriate brake fluid and measure is filled within it, also the air conditioner blows hot air during the summer causing the car to fail during hot weather
Engine & cooling all 38 →
While we were try I g to repair this vehicle we were test driving it a d came to a full stop at a stoplight signal and could not downshift vehicle into 1st gear from a stop after the vehicle was at normal running temperature. Causing it to go I to a limp home mode. So while we were driving we noticed that the floor was saturated with antifreeze and a sweet odor from the vents was noticed with a smoke . We serviced the transmission without success . Also noticed an no oil pressure read on dash only when we were not in acceleration. This disappear when upon acceleration and returned when idling. We serviced the oil filter the fluids performed a motor flush first and replaced the oil pressure switch. Without successful repairs and continue of the code returns after performing a drive cycle numerous times. We are convinced this is caused by the recall #r155. …
Tl* the contact owns a 1999 Volvo S80. The contact stated that as the vehicle was being started, a strong burning odor began to circulate inside of the vehicle. Immediately, the contact exited the vehicle and noticed flames emitting from the exhaust pipe. The contact then extinguished the flames. The vehicle had been repaired four times prior to the recent fire for a severe oil leak. The turbo oil trap pcv was replaced each time. The repairs were performed by an authorized dealer. The contact also replaced the part himself. The vehicle had not been repaired for the most recent failure. The manufacturer was notified of the problem. The approximate failure mileage was 65,000.
Electrical system all 35 →
Tl* the contact owns a 1999 Volvo S80. While stationary, the vehicle leaked fuel onto the ground. Wallace Volvo in stuart, florida diagnosed the vehicle as having a mass air flow failure. The vehicle was repaired by don imports auto service in vero beach, florida. In addition, while driving 2 MPH, the vehicle caught fire underneath the driver's seat. A police report was filed. The contact extinguished the fire with the assistance of a neighbor. There were no injuries sustained. The vehicle was towed to wallace Volvo in stuart, florida. The vehicle was not destroyed. The manufacturer was made aware of the issue. The failure mileage and VIN were unknown.
Theres a recent recall on the airbags of the 1999 S80 Volvo that we need our airbags replaced because its a hazard that can lead up to death. Also the electricity keeps zapping down from the car creating no starts or very poor driving, I almost was stranded because the car seems like it wanted to shut down one night I was getting off work, I hit full gas and it only gave me 3 MPH and also when I made a right turn one night from work I feel the wheel feel like its coming apart from the inside or loosening I dont know what it is but it feels and sounds rough
1999 Volvo S80 engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.9L 6-cyl | 4-speed automatic | FWD | 17 / 25 / 20 |
| 2.8L 6-cyl turbo | 4-speed automatic | FWD | 16 / 25 / 19 |
EPA ratings. Class: Midsize car.
Frequently asked questions
Is the 1999 Volvo S80 a good car?
Based on 199 owner complaints filed with NHTSA, the 1999 S80 rates avoid: 15.0× as many complaints as a typical year of the S80 at the same age. It is one of the S80 years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 1999 Volvo S80?
The speed control & acceleration — 53 complaints, 27% of all complaints for this model year, most often about cruise control. Next are the engine & cooling (38) and electrical system (35).
How many recalls does the 1999 Volvo S80 have?
There are 4 recalls for the 1999 Volvo S80, the most recent from November 15, 2006 (vehicle speed control). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Volvo S80?
The best years by complaints, compared at the same age, are 2011, 2005 and 2012. Years to avoid or approach with caution: 2001, 2002, 2004, 2003 and 2008. See the full Volvo S80 years comparison.
At what mileage do 1999 Volvo S80 problems happen?
The median mileage reported in complaints is about 83,000 miles; 13% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.