Which parts fail
Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2011 Toyota Prius owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2011 Toyota Prius. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, the vehicle had unexpectedly shut off. Additionally, the transmission failed to shift into the intended gear. The vehicle was towed to the local dealer who replaced the catalytic converter, but the failure persisted. The vehicle was towed back to the dealer who diagnosed that the inverter was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 14V053000 (HYBRID PROPULSION SYSTEM, ELECTRICAL SYSTEM). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 117,000.
Odometer Fraud. The contact purchased a 2011 Toyota Prius. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the mileage was 145,000 and at the time of registration, it was discovered that the mileage was 227,000. The contact stated that while driving at 60 MPH, the check engine warning light illuminated. The contact took the vehicle to Auto Zone and was informed that the catalytic converter had failed and needed to be replaced. The contact was informed that it was not a new failure and that there was a possibility that the dealer may have removed the check engine light prior to the sale.
The contact owns a 2011 Toyota Prius. The contact stated that the battery was drained frequently upon starting the vehicle. There was no warning light illuminated. The contact also stated that while driving at various speeds, the brake pedal was firm while depressing, with several warning lights including the ABS warning light illuminated. The vehicle was taken to a dealer and based from the noise coming from the vehicle; the mechanic determined that the brake booster and brake booster assembly were defective. The manufacturer was notified of the issue. The vehicle was not repaired. The failure mileage was approximately 204,000.
The contact owns a 2011 Toyota Prius. The contact stated that upon starting the vehicle, there was an abnormal beeping sound heard. The contact stated that several warning lights were illuminated. While reversing in the driveway, the brake pedal was depressed to the floorboard before the vehicle stopped. The contact's husband an independent mechanic informed her that the brake actuator needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 147,000.
The contact owns a 2011 Toyota Prius. The contact stated while driving approximately 55 MPH, the vehicle stalled with the check hybrid system warning light illuminated continuously. The vehicle was able to restart. The vehicle was taken to the dealer where it was diagnosed that the inverter needed to be repaired. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 141,000.
one year after bought, was losing power, replacing a lot of batteries, headlights and lamps then car would lose power while driving, not start continually everyday for each day after and even started on its own. i took in a lot and they put my vin to the wrong person..someone rainsford so my service recs were not recorded. said no battery code, didnt check altenator, and even tho serv advisor said the break was squishy to him and he heard the loud buzz noise when pushing, it was not replaced. they tried to blame it on keys being in car which is how it starts and runs! not parked on hill or in bad temps and driven long trips, none of which SHOULD BE REQIRED to start a car to get to dying patients on time. we bought charger and use on both priuses daily. lost power while driving, got hurt, and josh's pt. died. nothing but headache nightmares. …
I was driving my car at over 70 mph on a highway, no check engine, no issues, just had oil changed when check hybrid system alert came on with check engine light. I started to change lanes to get to shoulder when my car just died, completely. It died in the middle of the highway merging with another major road, so I was stuck between 2 lanes of 70mph traffic on either side. The time to react to the sudden warning to my car dying was less than 2 minutes. I quickly called 911 to ask for help and was told someone had already reported my breakdown as well because my car had died in a horribly dangerous area. I was very lucky that a state trooper came quickly and blocked off my car until it could be towed for repair. I was told that I need a new Hybrid Battery. …
After approximately 6 1/2 years of owning this 2011 Toyota Prius Hybrid (purchased in 2012), the brake pedal went completely to the floor and there was no braking. The brake fluid was completely FULL. Intermittently, this would occur, but brakes would come back operational in a few minutes. In 2022, the brake lights on dashboard started lighting up intermittently and go off. I had the complete brake pads, etc. replaced in June 2022. Last 1/2 of 2022 the entire brake dash lit up. I got into Toyota dealership 1/12/2023. They said the complete brake Master Cyclinder and Brake Pump replacement was required. They got the dash lights off. This car has only 133,023 miles. I finally checked the internet to see this is a TOYOTA issue! A recall on this brake assembly should be issued! I was unaware of this 5 years ago. This could cause a serious accident and should be fixed at Toyota's expense!
The low-beam headlamps on thousands of 2011 Toyota Priuses were burning out very prematurely (a matter of weeks, not months). Toyota Corporate said they created a customer support program to replace the headlight wiring harness free of charge, but this program ended in 2019. I believe that Toyota should be compelled to issue a recall to replace the wiring harnesses on all 2011 Toyota Priuses, because working headlights are a critical component of a safely traveling vehicle. The cost of replacing the wiring harness is more than $700, a real dent in a working family's budget. For now, we are replacing the burned-out bulbs. However, we believe a recall initiated by NHTSA is warranted in this case.
Around 14 months ago (march 2024) I purcheded a replacment battery pack for our 2011 Toyota Prius form NexPower Energy (also going by, project lithium, sodiumhybrid) based out of CA. The battery pack is a lithum pack that replaces the orginal nickel metal hydride pack. In the beginning of June 2025, the car through an battery error and went into limp mode wile my wife was driving, when i go home and plugged in my scanner to check the battery out i noticed that the cells were out of balance and some were becoming very over charged. My fear is that if the cells were continued to be overcharged an thermal runaway event might occure due to BMS not being included with the overall pack.
Related recalls
Electrical system › Software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge.
NHTSA investigations
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles.
Electrical complaints in other Prius years
Frequently asked questions
How common are electrical problems on the 2011 Toyota Prius?
NHTSA has 68 complaints about the electrical system of the 2011 Toyota Prius, 13% of the model year's 521 complaints. The component named most often is instrument cluster/panel (2 mentions).
Is there a recall for 2011 Toyota Prius electrical problems?
Yes — NHTSA recall 14V-053 (software, Feb 12, 2014). Recall repairs are free at authorized dealers.
At what mileage do 2011 Toyota Prius electrical problems start?
Half of the complaints with a recorded mileage happened before about 83,000 miles, and 13% before 25,000 miles.
Is it dangerous?
Owners linked 3 crashes, 4 fires and 1 injury to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.