Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2018 Toyota Highlander owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owned a 2018 Toyota Highlander. The contact stated the recall repair for NHTSA Campaign Number: 20V012000 (Fuel System, Gasoline) had been completed on the vehicle. The contact stated while her husband was driving 55-65 MPH, the vehicle inadvertently stalled. An unknown warning light was illuminated. The contact stated that her husband veered to the side of the road. The contact's husband was able to restart the vehicle. The vehicle was taken to the dealer who informed the contact's husband that they could not determine the cause of the failure; however, the computer onboard was reset. The contact stated that the failure recurred while driving. The contact's husband was able to restart the vehicle after several attempts however, the failure recurred several times while the contact's husband was taking the vehicle to the nearest dealer. …
The contact owns a 2018 Toyota Highlander. The contact stated while driving 70 MPH, the check engine warning light illuminated informing the driver that the AWD system and stability were disabled. The vehicle was taken to the dealer where they diagnosed the failure of the sub-assembly and the water temperature sensor needed to be replaced. The contact stated that he was informed that the onboard computer disabled the system due to the weather. The dealer informed the contact that the parts were on national backorder. The dealer performed a temporary repair by placing plastic on the grill to keep cold air out; however, the failure reoccurred several times. The manufacturer was notified of the failure and informed the contact that the parts were not covered under warranty. The approximate failure mileage was 48,000.
The contact owns a 2018 Toyota Highlander. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, and it was determined that there was low compression in cylinder #1. The contact was informed that the engine was damaged and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 61,000.
The contact owns a 2018 Toyota Highlander. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power after coming to a full stop at a traffic light. The vehicle was taken to an independent mechanic and the dealer; however, the mechanic and the dealer were unable to duplicate the failure. The contact related the failure to a faulty Auto Start/Stop feature. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.
Engine cam tower oil leak due to the manufacturer's inadequate assembly of the engine parts. The mating surfaces were not adequately prepared and/or application of a contaminated sealant did not adhere to the surfaces creating a small oil leak that eventually became larger and finally noticed. The Car Care Nut automotive shop performed this repair and documented in the video: [redacted] The 2018 engine (3.5L DOHC V6 D-4S Engine with Dual VVT-i Direct Shift) with 52,500 miles has by now (2024) developed a large oil leak coming from the cam tower seal, and requires replacement. I'm the original owner with the car always being garaged and maintained by the book at the dealer. Toyota of America is refusing any assistance with the defective engine component even though it is under the 60,000 miles powertrain warranty, but past the 60 months warranty period. …
My husband took my car from the carport and parked it in the driveway near the water hose to wash the car. When he finished, it would not start. The message "Braking Power Low" , "STOP in a Safe Place", " See Owner's Manual"showed up. Of course, we could not find anything in the large owner's manual concerning that! I checked with my VIN to see if mine was included in the recall regarding this same matter, but it was NOT, just as all other Toyota Highlander 2018 owners who complained were told!!! We will find out tomorrow and pray it won't be a lot of money. We have a Thanksgiving trip planned to see our grandchildren. Today is Sunday and we planned to leave on Tuesday. I shudder to think what could have happened if it suddenly stopped on [redacted] with all the holiday traffic. My husband was looking to buy a car after the first of the year and was going to buy a Toyota. …
Unable to start vehicle twice. In both instances, foot was placed on the brake before pressing Start button and brake was extremely stiff. When Start button is pushed, electronics engage (control panel lights, A/C, etc.) but engine will not engage. In the first incident, car had been stopped to refuel and would not restart. Car had been started without incident and been running for approximately 20 minutes prior to stopping for refueling. Tried to restart the engine for 20-30 minutes unsuccessfully and had to have vehicle towed to authorized Toyota dealer. Dealer was unable to look at it for two days and was able to start engine on the first try two days later. Dealer could not replicate problem. In the second incident, car had been in a parking lot for two hours on a hot day. Again, brake was extremely stiff, electronics engaged but engine would not start. …
Engine light came on, took to auto parts store and they checked for the code. Was told it was an issue with the fuel pump/ vacuum. Reset engine light, stopped to fill up with gas and car would not restart. The steering wheel locked and car would not crank. Was jumped off by a bystander, still would not turn over. After sitting for approx 15 minutes, I tried to restart vehicle again and it cranked. One week later, on vacation, car would not start after getting gas. Once again, took it to auto part store and same code and check engine light was on. Reset engine light, drove fine. Once check engine light is on, I am unable to use cruise control, this was very inconvenient since we were traveling! I have had this same issue happen about 5 times now! Making appointment with dealership to see if this weill be covered by my warranty and hopefully it is a simple fix.
As I was returning to my house and about to pull into our garage I was driving very slowly, riding the brake in fact. I was going less than 1 mph but as I first entered the garage my car engine suddenly roared very loudly and sped inside. I pressed as hard as I could on the brakes and the car skidded towards the left and slammed into the garage wall. I firmly believe that the only thing that kept my car from traveling farther was the garage door frame. Between my braking and then turning off the engine, I came to a stop. There were skid marks on the pavement at the garage entrance from the hard braking and both the driver's door and the passenger door on that side were severely damaged. The car was now angled to the left and not pointed straight into the garage as it should have been. At no time did I press on the accelerator.
While driving the car at approximately 40 mphs the car suddenly jolted and stopped moving. Luckily no one was behind and I pulled over also noticing check engine light came on. I immediately called Toyota and was able to drive it to them. I spent $140 diagnosis fees for them to say it was ignition coil B. After replacing the coil the light and same problems continued. We took the car to another mechanic, spent $600 diagnosis fees to find out it is the ECM. We then contacted the Toyota dealer asking about previous recalls that were on the ECM for 2018 Toyota Highlanders which is our car. They stated our car based off the VIN has no recalls. How could this recall be for 2018 Toyota Highlanders but not for our 2018 Toyota Highlander with the same issues? Our car only has 80,000 miles.
Engine complaints in other Highlander years
Frequently asked questions
How common are engine problems on the 2018 Toyota Highlander?
NHTSA has 34 complaints about the engine & cooling of the 2018 Toyota Highlander, 13% of the model year's 269 complaints.
Is there a recall for 2018 Toyota Highlander engine problems?
No. NHTSA lists no engine & cooling recall for the 2018 Toyota Highlander, though it has 4 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2018 Toyota Highlander engine problems start?
Half of the complaints with a recorded mileage happened before about 15,000 miles, and 59% before 25,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.