Which parts fail
Components named in complaints (automatic and manual transmissions, CVT, axles, driveshaft, 4WD/AWD).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2020 Toyota Corolla owners, lightly cleaned up (personal details are redacted by NHTSA).
I am not sure what the component is but I am driving and as I accelerate the gas my car will lose power to increase speed. If I am at the stop sign or stop light and I proceed to go the car will stall and not get going once I place my foot on the gas. I have reached out to the dealer by phone and when I have obtained service I am being advised that it's nothing. But I have experienced it on multiple occasions and even had an accident and nothing is being done to resolve the issue. I know that it can't be normal for the vehicle to do that and I am tired of getting the run around in regards to it. I was able to see that there has been a recall but do not see that it is in regard to me vin number. Can you please assist me with this matter. I should not be in the middle of driving or at a stop light and not able to accelerate my vehicle to a regular speed. …
The contact owns a 2020 Toyota Corolla. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact became aware of an abnormal clunking sound, and that the check engine warning light was illuminated. The contact stated the failure had occurred while driving on a busy road. The contact attempted to shift the gear shifter into different driving modes; however, the vehicle failed to accelerate as intended. The contact stated that several good Samaritans pushed the vehicle into a nearby driveway. The vehicle was taken to an independent mechanic where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 64,000.
The contact owns a 2020 Toyota Corolla. The contact stated while driving, at any speed, as the contact depressed the brake pedal to stop the vehicle would stop, however when the contact depressed the accelerator pedal the vehicle would move backwards with a jolt before moving forward. The contact stated that the failure was intermittent but had become recurring failure. The contact stated no warning light was illuminated. Additionally, the contact stated that an abnormal buzzing sound was coming from the engine compartment. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 131,000.
The contact owns a 2020 Toyota Corolla. The contact stated that while driving at an undisclosed speed, the clutch failed to operate as intended. The contact stated that the clutch seized, and the RPM increased. No warning lights were illuminated. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,330.
The contact owns a 2020 Toyota Corolla. The contact stated while driving 30 MPH, the vehicle was jerking abnormally. The contact noticed a failure with the transmission; however, there were no warning lights illuminated. The contact was concerned that the vehicle might stall while driving. The dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was instructed to contact the NHSTA Hotline for assistance. The failure mileage was approximately 131,000.
My vehicle has 20k miles on it and during acceleration, the CVT would not upshift was bouncing off the rev limiter. I had no controls over the Paddle Shifts or Electronic manual shifter controls. Tried to accelerate again, and bounced off the rev limiter again. Shortly after the CEL came on and the vehicle went into LIMP mode causing me to lose control of accelerator pedal, and the car drastically decelerated on its own until about 35mph Yes. Transmission is currently at shop awaiting for replacement unit This issue happened during a driver education event, and therefore was not on public roads with other pedestrians. Had this happened on a highway during merging or passing on a highway, this could have caused an accident by not having control of car's deceleration, and no warning brake lights to drivers behind me could have caused other drivers to rear end me Yes. …
What component or system failed or malfunctioned: complete slave cylinder failure resulting in loss of braking and ability to shift. Luckily I was traveling at a low rate of speed when this happened, but if this happens to anyone on the freeway or while turning against traffic for example they would have no control of their car and could be seriously injured. I took it to the dealership and they diagnosed it as a slave cylinder failure at only 70k miles. This is incredibly pre-mature. The vehicle has not been inspected by the manufacturer, only the dealership but I am trying to escalate the issue. No warnings at all, I regularly get my car serviced on there were no instances of the clutch acting strange or brakes losing power (because the clutch and brakes share the same fluid reservoir) prior to this incident.
Engine maintenance light came on after turning on air conditioner. Vehicle information: warning light came on at 56,800 miles on 2020 Toyota Corolla, no after market modifications to vehicle. I took vehicle to Toyota dealership for diagnostic testing. Conclusion: coolant bypass valve faulty causing leaks (this can cause overheating, stalling, increased emissions, and total engine failure and also allows coolant to leak into and damage surrounding engine components, including a vehicle's electrical system, the complaint relays). Fortunately, I PURCHASED AN EXTENDED WARRANTY when I bought the vehicle new, which covered the repairs. The faulty coolant bypass valve was replaced at the Toyota dealership. Had I not purchased the extended warranty, I would of been out of pocket for said repairs.
Clutch Slave Cylinder at 51,000 miles failed causing vehicle clutch to not return and loss of fluid. Brake fluid and clutch fluid are used in the same reservoir and could cause issues causing vehicle to not be able to stop. Vehicle has been inspected by shop and has been replicated. The part exploded and leaks fluid inside of transmission housing. This also causes the clutch to fail as-well. Vehicle has always been serviced and maintained and this is a common issue with all vehicles that have 6 speed manual transmission with varying mileage. It is not a matter of if, it's when and due to this being something that happens with generally no warning signs can be dangerous. There needs to be an updated part that can handle the design Toyota chose for this transmission.
The clutch slave cylinder failed at 48,000 miles. On the freeway, I had difficulty shifting into gear and I had cars passing me at high speeds, putting my life and others' lives at risk. This part defect is due to the plastic clutch slave cylinder failing. This common issue is well-documented by numerous other owners, with the part failing before the routine clutch maintenance cycle. My car was inspected by an independent mechanic, who said the lack of clutch pressure is due to the clutch slave cylinder failing. The worst part is that there were no warning lamps or messages before this happened. Toyota is claiming there is no recalls for this part, whic his astounding because the clutch is essential for the 6speed transmission.
Transmission complaints in other Corolla years
Frequently asked questions
How common are transmission problems on the 2020 Toyota Corolla?
NHTSA has 40 complaints about the transmission & drivetrain of the 2020 Toyota Corolla, 13% of the model year's 313 complaints. The component named most often is clutch assembly (1 mentions).
Is there a recall for 2020 Toyota Corolla transmission problems?
No. NHTSA lists no transmission & drivetrain recall for the 2020 Toyota Corolla, though it has 5 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2020 Toyota Corolla transmission problems start?
Half of the complaints with a recorded mileage happened before about 15,000 miles, and 58% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 3 injuries to transmission & drivetrain problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.